Morphological design of alumina hollow fiber membranes for desalination by air gap membrane distillation

Abstract Alumina hollow fiber membranes were prepared by the phase inversion technique under different spinning conditions in order to induce various types of structural morphologies. In the membrane fabrication process, the studied parameters were the polymer concentration in the inorganic suspension and its flow rate, the gap distance, the bore liquid, the outer coagulant composition and their flow rates. After sintering, the hollow fibers were chemically modified by grafting (1H,1H,2H,2H-perfluorodecyltriethoxysilane) rendering them hydrophobic for their use in membrane distillation (MD) process. The effects of the membrane morphology on the obtained MD membrane characteristics and on air gap membrane distillation (AGMD) desalination performance were studied in order to figure out the most promising structure for MD. The suitability of alumina hollow fibers for AGMD was confirmed by various membrane characterization techniques. In general, the membranes prepared with lower polymer concentration in the inorganic suspension exhibited higher AGMD performance (i.e. higher permeate flux with a smaller flux reduction factor and a good salt rejection factor). Among all prepared hollow fiber membranes prepared in this study, the one with the largest micro-channel structure exhibited the best AGMD performance, even better than all hydrophobic ceramic membranes used so far in desalination by AGMD and DCMD.

[1]  Saeed M. Al-Zahrani,et al.  Design and fabrication of a portable and hybrid solar-powered membrane distillation system , 2016 .

[2]  Kang Li,et al.  From Polymeric Precursors to Hollow Fiber Carbon and Ceramic Membranes , 2008 .

[3]  H. Kull.  Theory of the Rayleigh-Taylor instability , 1991 .

[4]  S. Cerneaux,et al.  Investigation of the stability of metal oxide powders and ceramic membranes grafted by perfluoroalkylsilanes , 2014 .

[5]  Enrico Drioli,et al.  Membrane distillation: Recent developments and perspectives , 2015 .

[6]  S. Ji,et al.  Review of thermal efficiency and heat recycling in membrane distillation processes , 2015 .

[7]  Chusheng Chen,et al.  β-Sialon ceramic hollow fiber membranes with high strength and low thermal conductivity for membrane distillation , 2016 .

[8]  Yuexiang Lu,et al.  Mg(OH)2 Complex Nanostructures with Superhydrophobicity and Flame Retardant Effects , 2010 .

[9]  M. Khayet.  Membranes and theoretical modeling of membrane distillation: a review. , 2011, Advances in colloid and interface science.

[10]  Marek Gryta,et al.  Influence of morphology of PVDF capillary membranes on the performance of direct contact membrane distillation , 2010 .

[11]  Stephen K. Gray,et al.  Next generation membranes for membrane distillation and future prospects , 2015 .

[12]  Xing Yang,et al.  Performance improvement of PVDF hollow fiber-based membrane distillation process , 2011 .

[13]  André Bardow,et al.  Efficient technologies for worldwide clean water supply , 2012 .

[14]  Kang Li,et al.  Micro-structured alumina hollow fibre membranes – Potential applications in wastewater treatment , 2014 .

[15]  Xing-qin Liu,et al.  Influences of internal coagulant composition on microstructure and properties of porous YSZ hollow fibre membranes for water treatment , 2015 .

[16]  M. C. García-Payo,et al.  Effects of PVDF-HFP concentration on membrane distillation performance and structural morphology of hollow fiber membranes , 2010 .

[17]  Peng Wang,et al.  Morphological architecture of dual-layer hollow fiber for membrane distillation with higher desalination performance. , 2011, Water research.

[18]  Kang Li,et al.  Micro-structured alumina multi-channel capillary tubes and monoliths , 2015 .

[19]  D. Sharp.  An overview of Rayleigh-Taylor instability☆ , 1984 .

[20]  M. C. García-Payo,et al.  Effects of mixed solvents on the structural morphology and membrane distillation performance of PVDF-HFP hollow fiber membranes , 2014 .

[21]  Huanting Wang,et al.  Hydrophobic porous alumina hollow fiber for water desalination via membrane distillation process , 2012 .

[22]  S. Cerneaux,et al.  Highly hydrophobic ceramic membranes applied to the removal of volatile organic compounds in pervaporation , 2015 .

[23]  Kang Li,et al.  A multifunctional Pd/alumina hollow fibre membrane reactor for propane dehydrogenation , 2010 .

[24]  Tai‐Shung Chung,et al.  Recent advances in membrane distillation processes: Membrane development, configuration design and application exploring , 2015 .

[25]  Kang Li,et al.  New designs of ceramic hollow fibres toward broadened applications , 2016 .

[26]  D. J. Lewis.  The instability of liquid surfaces when accelerated in a direction perpendicular to their planes. II , 1950, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[27]  Wojciech Kujawski,et al.  Application of fluoroalkylsilanes (FAS) grafted ceramic membranes in membrane distillation process of NaCl solutions , 2006 .

[28]  Chusheng Chen,et al.  Preparation and characterization of silicon nitride hollow fiber membranes for seawater desalination , 2014 .

[29]  Kang Li,et al.  Preparation and Characterization of a Robust and Hydrophobic Ceramic Membrane via an Improved Surface Grafting Technique , 2009 .

[30]  Vincent G. Gomes,et al.  Hybrid nanostructures based on titanium dioxide for enhanced photocatalysis , 2015 .

[31]  Kang Li,et al.  Preparation and characterization of hydrophobic ceramic hollow fibre membrane , 2007 .

[32]  Kang Li,et al.  Ceramic asymmetric hollow fibre membranes—One step fabrication process , 2008 .

[33]  Mohamed Khayet,et al.  Self-sustained webs of polyvinylidene fluoride electrospun nano-fibers: Effects of polymer concentration and desalination by direct contact membrane distillation , 2014 .

[34]  M. Khayet.  The effects of air gap length on the internal and external morphology of hollow fiber membranes , 2003 .

[35]  Nidal Hilal,et al.  Mechanical properties of water desalination and wastewater treatment membranes , 2017 .

[36]  Wojciech Kujawski,et al.  Comparison of various membrane distillation methods for desalination using hydrophobic ceramic membranes , 2009 .

[37]  M. Persin,et al.  Desalination of sodium chloride solutions and seawater with hydrophobic ceramic membranes , 2007 .

[38]  Wojciech Kujawski,et al.  Water desalination using ceramic membrane distillation , 2004 .

[39]  M. C. García-Payo,et al.  Membranes used in membrane distillation: preparation and characterization , 2015 .

[40]  Kang Li,et al.  A morphological study of ceramic hollow fibre membranes , 2009 .

[41]  Mohamed Khayet Souhaimi.  Membrane Distillation: Principles and Applications , 2011 .

[42]  Mark R. Wiesner,et al.  Surface modification of nanostructured ceramic membranes for direct contact membrane distillation , 2009 .

[43]  S. Cerneaux,et al.  Characterization of the surface modification process of Al2O3, TiO2 and ZrO2 powders by PFAS molecules , 2014 .

[44]  Chusheng Chen,et al.  Preparation and characterization of hydrophobic alumina planar membranes for water desalination , 2015 .

[45]  Ce Wang,et al.  Dual-biomimetic superhydrophobic electrospun polystyrene nanofibrous membranes for membrane distillation. , 2014, ACS applied materials & interfaces.

[46]  T. Lee,et al.  Contact Angle and Wetting Properties , 2013 .

[47]  G. Meng,et al.  Highly permeable porous YSZ hollow fiber membrane prepared using ethanol as external coagulant , 2010 .

[48]  Mahbub Hassan,et al.  Carbon functionalized TiO2 nanofibers for high efficiency photocatalysis , 2014 .

[49]  X. Tan,et al.  Morphology control of the perovskite hollow fibre membranes for oxygen separation using different bore fluids , 2011 .

[50]  S. Cerneaux,et al.  Influence of hydrophobization conditions and ceramic membranes pore size on their properties in vacuum membrane distillation of water–organic solvent mixtures , 2016 .

[51]  Shaomin Liu,et al.  Preparation of porous aluminium oxide (Al2O3) hollow fibre membranes by a combined phase-inversion and sintering method , 2003 .

[52]  K. Sondhi,et al.  Development of hydrophobic clay–alumina based capillary membrane for desalination of brine by membrane distillation , 2016 .

[53]  Wojciech Kujawski,et al.  Membrane distillation properties of TiO2 ceramic membranes modified by perfluoroalkylsilanes , 2013 .

[54]  G. Taylor.  The instability of liquid surfaces when accelerated in a direction perpendicular to their planes. I , 1950, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[55]  Chusheng Chen,et al.  Preparation of silicon nitride hollow fibre membrane for desalination , 2012 .

[56]  M. C. García-Payo,et al.  Desalination and concentration of saline aqueous solutions up to supersaturation by air gap membrane distillation and crystallization fouling , 2016 .

[57]  Kang Li,et al.  A morphological study of ceramic hollow fibre membranes: A perspective on multifunctional catalytic membrane reactors , 2010 .

[58]  Kang Li,et al.  Formation of micro-channels in ceramic membranes – Spatial structure, simulation, and potential use in water treatment , 2015 .