Quantification of Spontaneous W/O Emulsification and its Impact on the Swelling Kinetics of Multiple W/O/W Emulsions.

An osmotic imbalance between the two water phases of multiple water-in-oil-in-water (W1/O/W2) emulsions results in either emulsion swelling or shrinking due to water migration across the oil layer. Controlled mass transport is not only of importance for emulsion stability but also allows transient emulsion thickening or the controlled release of encapsulated substances, such as nutriments or simply salt. Our prior work has shown that mass transport follows two sequential stages. In the first stage, the oil-phase structure is changed in a way that allows rapid, osmotically driven water transport in the second, osmotically dominated stage. These structural changes in the oil layer are strongly facilitated by the spontaneous formation of tiny water droplets in the oil phase, induced by the oil-soluble surfactant, i.e., polyglycerol polyricinoleate (PGPR). This study provides a simple method based on microscopy image analysis, allowing a detailed investigation of spontaneous W/O emulsification. It quantitatively describes the volume of droplets generated and the rate of droplet creation. Moreover, it describes the effect of spontaneous W/O emulsification on the swelling kinetics of microfluidic processed W1/O/W2 emulsions. Two different concentration regimes of the oil-soluble surfactant are identified: below a critical concentration the overall water transport rate increases, and above a critical concentration water transport stagnates because of maximized structure formation.

[1]  Peter Fischer,et al.  Decoupling of mass transport mechanisms in the stagewise swelling of multiple emulsions. , 2015, Langmuir : the ACS journal of surfaces and colloids.

[2]  A. Juadjur,et al.  AFM approach to study the function of PGPR's emulsifying properties in cocoa butter based suspensions , 2015 .

[3]  R. Hayward,et al.  Osmotically driven formation of double emulsions stabilized by amphiphilic block copolymers. , 2014, Angewandte Chemie.

[4]  P. Fischer,et al.  Studying bacterial hydrophobicity and biofilm formation at liquid-liquid interfaces through interfacial rheology and pendant drop tensiometry. , 2014, Colloids and surfaces. B, Biointerfaces.

[5]  D. Mcclements,et al.  Controlling W/O/W multiple emulsion microstructure by osmotic swelling and internal protein gelation , 2013 .

[6]  Peter Fischer,et al.  The self-assembly, aggregation and phase transitions of food protein systems in one, two and three dimensions , 2013, Reports on progress in physics. Physical Society.

[7]  M. Corredig,et al.  Interactions at the interface between hydrophobic and hydrophilic emulsifiers: Polyglycerol polyricinoleate (PGPR) and milk proteins, studied by drop shape tensiometry , 2012 .

[8]  A. Pilosof,et al.  Protein–polysaccharide interactions at fluid interfaces , 2011 .

[9]  E. Dickinson.  Double Emulsions Stabilized by Food Biopolymers , 2011 .

[10]  P. Cox,et al.  Food grade duplex emulsions designed and stabilised with different osmotic pressures. , 2010, Journal of colloid and interface science.

[11]  Ryan C Hayward,et al.  Spontaneous generation of amphiphilic block copolymer micelles with multiple morphologies through interfacial Instabilities. , 2008, Journal of the American Chemical Society.

[12]  Gerald Muschiolik,et al.  Multiple emulsions for food use , 2007 .

[13]  D. Mcclements,et al.  Preparation and characterization of water/oil and water/oil/water emulsions containing biopolymer-gelled water droplets. , 2007, Journal of agricultural and food chemistry.

[14]  E. Yurtov,et al.  Water mass transfer in W/O emulsions. , 2006, Journal of colloid and interface science.

[15]  M. Goto,et al.  Bioseparation Through Liquid—Liquid Interfaces , 2005 .

[16]  R. Pal,et al.  Effects of aqueous-phase acidity and salinity on isotonic swelling of W/O/W emulsion liquid membranes under agitation conditions , 2004 .

[17]  D. Weitz,et al.  Swollen vesicles and multiple emulsions from block copolymers , 2004 .

[18]  Erich J. Windhab,et al.  Stress- and strain-controlled measurements of interfacial shear viscosity and viscoelasticity at liquid/liquid and gas/liquid interfaces , 2003 .

[19]  R. Pal,et al.  Isotonic swelling behavior of W/O/W emulsion liquid membranes under agitation conditions , 2003 .

[20]  D. Shah,et al.  Spontaneous Emulsification: Mechanisms, Physicochemical Aspects, Modeling, and Applications , 2002 .

[21]  F. Nielloud,et al.  Emulsions in Health Care Applications—An Overview , 2002 .

[22]  E. Windhab,et al.  Measurement of the Surface and Interfacial Tension from Maximum Volume of a Pendant Drop , 2001 .

[23]  T. Vliet,et al.  Interfacial rheological properties of adsorbed protein layers and surfactants: a review. , 2001, Advances in colloid and interface science.

[24]  K. Papadopoulos,et al.  Effects of Osmotic Pressure on Water Transport in W(1)/O/W(2) Emulsions. , 2001, Journal of colloid and interface science.

[25]  K. Papadopoulos,et al.  Visualization of water transport in W1/O/W2 emulsions , 2000 .

[26]  K. Papadopoulos,et al.  Effects of Surfactants on Water Transport in W1/O/W2 Emulsions , 2000 .

[27]  B. Campbell,et al.  Interactions between Mica Surfaces across Triglyceride Solution Containing Phospholipid and Polyglycerol Polyricinoleate , 2000 .

[28]  and Abraham Aserin,et al.  Stabilization of water-in-oil emulsions by submicrocrystalline α-form fat particles , 1998 .

[29]  R. Wilson,et al.  Overview of the preparation, use and biological studies on polyglycerol polyricinoleate (PGPR). , 1998, Food and chemical toxicology : an international journal published for the British Industrial Biological Research Association.

[30]  J. Grossiord,et al.  Influence of lipophilic surfactant on the release kinetics of water-soluble molecules entrapped in a W/O/W multiple emulsion , 1997 .

[31]  R. Granek.  Spontaneous curvature-induced Rayleigh-like instability in swollen cylindrical micelles , 1996 .

[32]  S. Magdassi,et al.  Release of markers from the inner water phase of W / O / W emulsions stabilized by silicone based polymeric surfactants , 1995 .

[33]  M. Aronson,et al.  Highly concentrated water-in-oil emulsions: Influence of electrolyte on their properties and stability , 1993 .

[34]  M. Cates,et al.  Dynamics of spontaneous emulsification , 1993 .

[35]  Julian Eastoe,et al.  Small-angle neutron scattering from dilute didodecyldimethylammonium bromide water-in-oil microemulsions. Evidence for polymer-like aggregates , 1992 .

[36]  T. Tadros.  Future developments in cosmetic formulations , 1992, International journal of cosmetic science.

[37]  E. Kaler,et al.  Alkali metal ion transport through thin bilayers , 1990 .

[38]  Clarence A. Miller.  Spontaneous emulsification produced by diffusion. A review , 1988 .

[39]  A. Florence,et al.  The Nature of the Oil Phase and the Release of Solutes from Multiple (w/o/w) Emulsions , 1986, The Journal of pharmacy and pharmacology.

[40]  S. Magdassi,et al.  Transfer phenomena across the oil phase in water-oil-water multiple emulsions evaluated by Coulter counter: 1. Effect of emulsifier 1 on water permeability , 1985 .

[41]  H. Renon,et al.  Water transfer in emulsified liquid membrane processes , 1984 .

[42]  A. Florence,et al.  The formulation and stability of multiple emulsions , 1982 .

[43]  Masanori Kohda,et al.  Water permeability of oil layers in W/O/W emulsions under osmotic pressure gradients , 1980 .

[44]  J. Bron,et al.  On thermodynamically stable emulsions , 1979 .

[45]  Y. Kita,et al.  An attempt at preparing water-in-oil-in-water multiple-phase emulsions , 1976 .

[46]  A. Florence,et al.  Effect of formulation of intramuscular injections of phenothiazines on duration of activity. , 1976, Journal of pharmaceutical sciences.

[47]  C. Rhodes,et al.  Potential use of Liquid Membranes for Emergency Treatment of Drug Overdose , 1976 .

[48]  D. Shah,et al.  Interfacial instability and spontaneous formation of microemulsions , 1972 .

[49]  L. M. Prince,et al.  A theory of aqueous emulsions I. Negative interfacial tension at the oil/water interface , 1967 .

[50]  J. Schulman,et al.  Mechanism of Formation and Structure of Micro Emulsions by Electron Microscopy , 1959 .

[51]  W. Davies.  The Grassland Environment , 1957, Proceedings of the Nutrition Society.