Influence of Oxygen Vacancy Behaviors in Cooling Process on Semiconductor Gas Sensors: A Numerical Analysis

The influence of oxygen vacancy behaviors during a cooling process in semiconductor gas sensors is discussed by the numerical analysis method based on the gradient-distributed oxygen vacancy model. A diffusion equation is established to describe the behaviors of oxygen vacancies, which follows the effects of diffusion and exclusion in the cooling process. Numerical analysis is introduced to find the accurate solutions of the diffusion equation. The solutions illustrate the oxygen vacancy distribution profiles, which are dependent on the cooling rate as well as the temperature interval of the cooling process. The gas-sensing characteristics of reduced resistance and response are calculated. Both of them, together with oxygen vacancy distribution, show the grain size effects and the re-annealing effect. It is found that the properties of gas sensors can be controlled or adjusted by the designed cooling process. The proposed model provides a possibility for sensor characteristics simulations, which may be beneficial for the design of gas sensors. A quantitative interpretation on the gas-sensing mechanism of semiconductors has been contributed.

[1]  Bing Yang,et al.  Both oxygen vacancies defects and porosity facilitated NO2 gas sensing response in 2D ZnO nanowalls at room temperature , 2016 .

[2]  Joachim Maier,et al.  Investigations of the bulk defect chemistry of polycrystalline tin(IV) oxide , 1988 .

[3]  Jiang Tang,et al.  Resistive gas sensors based on colloidal quantum dot (CQD) solids for hydrogen sulfide detection , 2015 .

[4]  Dongxiang Zhou,et al.  Tin oxide thin films prepared by aerosol-assisted chemical vapor deposition and the characteristics on gas detection , 2010 .

[5]  Norio Miura,et al.  Grain‐Size Effects in Tungsten Oxide‐Based Sensor for Nitrogen Oxides , 1994 .

[6]  Dongxiang Zhou,et al.  Nanocrystalline In2O3–SnO2 thick films for low-temperature hydrogen sulfide detection , 2011 .

[7]  Dongxiang Zhou,et al.  Time-dependent oxygen vacancy distribution and gas sensing characteristics of tin oxide gas sensitive thin films , 2010 .

[8]  Dongxiang Zhou,et al.  Properties and mechanism study of SnO2 nanocrystals for H2S thick-film sensors , 2009 .

[9]  S. Morrison,et al.  Mechanism of semiconductor gas sensor operation , 1987 .

[10]  H. Grubin.  The physics of semiconductor devices , 1979, IEEE Journal of Quantum Electronics.

[11]  Xiaojing Zhao,et al.  Templated bicontinuous Tin oxide thin film fabrication and the NO2 gas sensing , 2016 .

[12]  Ming Hu,et al.  NO2-sensing properties of porous WO3 gas sensor based on anodized sputtered tungsten thin film , 2012 .

[13]  Wenjie Zhao,et al.  Synthesis of flower-like Al doped ZnO microstructures by hydrothermal process and analysis of their gas sensing properties , 2014 .

[14]  Kengo Shimanoe,et al.  Theory of power laws for semiconductor gas sensors , 2008 .

[15]  Zhong Wei,et al.  Highly sensitive and rapid chemiresistive sensor towards trace nitro-explosive vapors based on oxygen vacancy-rich and defective crystallized In-doped ZnO , 2017 .

[16]  Man Siu Tse,et al.  Semiconductor gas sensor based on Pd-doped SnO2 nanorod thin films , 2008 .

[17]  Baohui Zhang,et al.  Colloidal synthesis of tungsten oxide quantum dots for sensitive and selective H2S gas detection , 2017 .

[18]  Zhou Dongxiang,et al.  Highly sensitive SnO2 thin film with low operating temperature prepared by sol–gel technique , 2008 .

[19]  Kengo Shimanoe,et al.  Roles of Shape and Size of Component Crystals in Semiconductor Gas Sensors I. Response to Oxygen , 2008 .

[20]  Zhaoxia Zhai,et al.  Simulation of the grain size effect in gas-sensitive SnO2 thin films using the oxygen vacancy gradient distribution model , 2015, Electronic Materials Letters.

[21]  Miao Zhang,et al.  Defect distribution and evolution in He+ implanted Si studied by variable-energy positron beam , 1998 .

[22]  Baohui Zhang,et al.  Sensitive H2S gas sensors employing colloidal zinc oxide quantum dots , 2017 .

[23]  Lin Quan,et al.  Evaluation of depletion layer width and gas-sensing properties of antimony-doped tin oxide thin film sensors , 2015 .

[24]  Chao-Nan Xu,et al.  Grain size effects on gas sensitivity of porous SnO2-based elements , 1991 .

[25]  Zhaoxia Zhai,et al.  Gas-sensing properties and sensitivity promoting mechanism of Cu-added SnO2 thin films deposited by ultrasonic spray pyrolysis ☆ , 2017 .

[26]  Zhaoxia Zhai,et al.  Effect of depletion layer width on electrical properties of semiconductive thin film gas sensor: a numerical study based on the gradient-distributed oxygen vacancy model , 2016 .

[27]  Dongxiang Zhou,et al.  Gas sensing characteristics of SnO2 thin films and analyses of sensor response by the gas diffusion theory , 2009 .

[28]  Kengo Shimanoe,et al.  New perspectives of gas sensor technology , 2009 .

[29]  Dongxiang Zhou,et al.  Influences of cooling rate on gas sensitive tin oxide thin films and a model of gradient distributed oxygen vacancies in SnO2 crystallites , 2010 .

[30]  T. Seiyama,et al.  A New Detector for Gaseous Components Using Semiconductive Thin Films. , 1962 .

[31]  Subho Mozumdar,et al.  Influence of CuO catalyst in the nanoscale range on SnO2 surface for H2S gas sensing applications , 2005 .

[32]  Zhaoxia Zhai,et al.  Numeral description of grain size effects of tin oxide gas-sensitive elements and evaluation of depletion layer width , 2015, Electronic Materials Letters.

[33]  Changsheng Xie,et al.  Al-doping induced formation of oxygen-vacancy for enhancing gas-sensing properties of SnO2 NTs by electrospinning , 2014 .

[34]  A R Plummer,et al.  Introduction to Solid State Physics , 1967 .

[35]  Yoshitaka Okada,et al.  Improvement of crystal quality of GaInNAs films grown by atomic hydrogen-assisted RF-MBE , 2005 .

[36]  Kengo Shimanoe,et al.  Roles of Shape and Size of Component Crystals in Semiconductor Gas Sensors , 2008 .

[37]  Noboru Yamazoe,et al.  Interactions of tin oxide surface with O2, H2O AND H2 , 1979 .

[38]  Ghenadii Korotcenkov,et al.  Influence of surface Pd doping on gas sensing characteristics of SnO2 thin films deposited by spray pirolysis , 2003 .

[39]  C. Zou,et al.  Synthesis and oxygen vacancy related NO2 gas sensing properties of ZnO:Co nanorods arrays gown by a hydrothermal method , 2015 .

[40]  S. Morrison,et al.  Semiconductor gas sensors , 1985 .

[41]  Udo Weimar,et al.  Conduction mechanisms in SnO2 based polycrystalline thick film gas sensors exposed to CO and H2 in different oxygen backgrounds , 2011 .

[42]  Chao Zhang,et al.  Role of oxygen vacancy in tuning of optical, electrical and NO2 sensing properties of ZnO1-x coatings at room temperature , 2017 .

[43]  Huan Liu,et al.  Inhomogeneous Oxygen Vacancy Distribution in Semiconductor Gas Sensors: Formation, Migration and Determination on Gas Sensing Characteristics , 2017, Sensors.

[44]  N. Bârsan,et al.  Conduction models in gas-sensing SnO2 layers: grain-size effects and ambient atmosphere influence , 1994 .