Design and Simulation of Next-Generation High-Power, High-Brightness Laser Diodes

High-brightness laser diode technology is progressing rapidly in response to competitive and evolving markets. The large volume resonators required for high-power, high-brightness operation makes their beam parameters and brightness sensitive to thermal- and carrier-induced lensing and also to multimode operation. Power and beam quality are no longer the only concerns for the design of high-brightness lasers. The increased demand for these technologies is accompanied by new performance requirements, including a wider range of wavelengths, direct electrical modulation, spectral purity and stability, and phase-locking techniques for coherent beam combining. This paper explores some of the next-generation technologies being pursued, while illustrating the growing importance of simulation and design tools. The paper begins by investigating the brightness limitations of broad-area laser diodes, including the use of asymmetric feedback to improve the modal discrimination. Next, tapered lasers are considered, with an emphasis on emerging device technologies for applications requiring electrical modulation and high spectral brightness.

[1]  E. Larkins,et al.  The impact of hot-phonons on the performance of 1.3µm dilute nitride edge-emitting quantum well lasers , 2007 .

[2]  Trevor M. Benson,et al.  Nonlinear properties of tapered laser cavities , 2003 .

[3]  Mitsuo Fukuda,et al.  Reliability and degradation of semiconductor lasers and LEDs , 1991 .

[5]  D. Masanotti,et al.  Optical guiding properties of high-brightness parabolic bow-tie laser arrays , 2005, IEEE Journal of Quantum Electronics.

[6]  J. Gustavsson,et al.  Simulation of DQW GaInNAs laser diodes , 2007 .

[7]  Measurement of optical gain, effective group index and linewidth enhancement factor in 1.3 μm dilute nitride double-quantum-well lasers , 2007 .

[8]  Govind P. Agrawal,et al.  Fast‐Fourier‐transform based beam‐propagation model for stripe‐geometry semiconductor lasers: Inclusion of axial effects , 1984 .

[9]  B. Hakki,et al.  Gain spectra in GaAs double−heterostructure injection lasers , 1975 .

[10]  Nicolas Michel,et al.  High-power, low-divergence, linear array of quasi-diffraction-limited beams supplied by tapered diodes. , 2007, Applied optics.

[11]  Andrey Yu. Rodionov,et al.  Fourier-optical transverse mode selection in external-cavity broad-area lasers: experimental and numerical results , 2003 .

[12]  Alan H. Paxton,et al.  High power, nearly diffraction-limited output from a semiconductor laser with an unstable resonator , 1991 .

[13]  Peter Blood,et al.  Characterization of semiconductor laser gain media by the segmented contact method , 2003 .

[14]  S. O'Brien,et al.  2.0 W CW, diffraction-limited operation of a monolithically integrated master oscillator power amplifier , 1993, IEEE Photonics Technology Letters.

[15]  P. Sewell,et al.  Quasi-3-D simulation of high-brightness tapered lasers , 2004, IEEE Journal of Quantum Electronics.

[16]  Ramon U. Martinelli,et al.  High-power (>10 W) continuous-wave operation from 100-μm-aperture 0.97-μm-emitting Al-free diode lasers , 1998 .

[17]  Wei Sun,et al.  Electro-optic measurement of poled polymer-based asymmetric Fabry–Perot cavity , 2000 .

[18]  A. Siegman,et al.  Unstable optical resonator loss calculations using the prony method. , 1970, Applied optics.

[19]  Mark S. Hybertsen,et al.  Simulation of semiconductor quantum well lasers , 2000 .

[20]  P. Adamiec,et al.  5-W DBR Tapered Lasers Emitting at 1060 nm With a Narrow Spectral Linewidth and a Nearly Diffraction-Limited Beam Quality , 2008, IEEE Photonics Technology Letters.

[21]  Robert J. Lang,et al.  Lateral modes of broad area semiconductor lasers: theory and experiment , 1991 .

[22]  S. Chinn,et al.  High-power, strained-layer amplifiers and lasers with tapered gain regions , 1993, IEEE Photonics Technology Letters.

[23]  J. Gustavsson,et al.  Simulation of double quantum well GalnNAs laser diodes , 2007 .

[24]  G. Agrawal,et al.  Spatio-temporal characteristics of filamentation in broad-area semiconductor lasers: experimental results , 1998, IEEE Photonics Technology Letters.

[25]  D. Welch,et al.  Theory of grating-confined broad-area lasers , 1998 .

[26]  K. Hess,et al.  Simulation of carrier transport and nonlinearities in quantum-well laser diodes , 1998 .

[27]  Jerry R. Meyer,et al.  Band parameters for III–V compound semiconductors and their alloys , 2001 .

[28]  Jorg Hader,et al.  Linewidth enhancement factor and optical gain in (GaIn)(NAs)/GaAs lasers , 2004 .

[29]  Daniel T. Cassidy,et al.  Technique for measurement of the gain spectra of semiconductor diode lasers , 1984 .

[30]  Paul Michael Petersen,et al.  Lateral mode selection in a broad-area laser diode by self-injection locking with a mirror stripe , 2004, SPIE LASE.

[31]  D. E. Ackley,et al.  Single longitudinal mode operation of high power multiple-stripe injection lasers , 1983 .

[32]  R. Indik,et al.  Full space-time simulation for high-brightness semiconductor lasers , 1997, IEEE Photonics Technology Letters.

[33]  Self-Organizing Laser Cavities , 2007 .

[34]  E. Larkins,et al.  The impact of nonequilibrium gain in a spectral laser diode model , 2006, 2006 International Conference on Numerical Simulation of Semiconductor Optoelectronic Devices.

[35]  Richard V. Penty,et al.  Design of high-brightness tapered laser arrays , 1999 .

[36]  James R. Leger,et al.  Lateral mode control of an AlGaAs laser array in a Talbot cavity , 1989 .

[37]  T.M. Benson,et al.  Design of wide-emitter single-mode laser diodes , 2005, IEEE Journal of Quantum Electronics.

[38]  Dan Botez,et al.  Phase-locked array of antiguided lasers with monolithic spatial filter , 1989 .

[39]  G. Erbert,et al.  Modeling and measurements of the radiative characteristics of high-power /spl alpha/-DFB lasers , 2003 .

[40]  E. Larkins,et al.  Numerical modeling of high-power self-organizing external cavity lasers , 2008 .

[41]  E. Larkins,et al.  Inclusion of thermal boundary resistance in the simulation of high-power 980 nm ridge waveguide lasers , 2008 .

[42]  Michel Calligaro,et al.  1 W high brightness index guided tapered laser at 980 nm using Al-free active region materials , 2003 .

[43]  Patrick Georges,et al.  Narrow-line coherently combined tapered laser diodes in a Talbot external cavity with a volume Bragg grating , 2008 .

[44]  S. Sujecki,et al.  Enhanced Brightness of Tapered Laser Diodes Based on an Asymmetric Epitaxial Design , 2007, IEEE Photonics Technology Letters.

[45]  I. White,et al.  Design of High-Brightness Tapered Laser Arrays K. A. Williams, R. V. Penty, I. H. White, Member, IEEE, D. J. Robbins, , 1999 .

[46]  S. P. McAlister,et al.  A self-consistent two-dimensional model of quantum-well semiconductor lasers: optimization of a GRIN-SCH SQW laser structure , 1992 .

[47]  Wolfgang Fichtner,et al.  A multidimensional laser simulator for edge-emitters including quantum carrier capture , 2000 .

[48]  A. Wetzel,et al.  High-brightness tapered semiconductor laser oscillators and amplifiers with low-modal gain epilayer-structures , 1998, IEEE Photonics Technology Letters.

[49]  C. Wyon,et al.  Spectroscopic properties and fluorescence dynamics of Er/sup 3+/ and Yb/sup 3+/ in Y/sub 2/SiO/sub 5/ , 1992 .

[50]  Stephan W Koch,et al.  Filamentation and beam propagation in broad-area semiconductor lasers , 1995 .

[51]  J. W. Orton,et al.  Reliability and Degradation of Semiconductor Lasers and LEDs , 1992 .

[53]  Darling.  Defect-state occupation, Fermi-level pinning, and illumination effects on free semiconductor surfaces. , 1991, Physical review. B, Condensed matter.

[54]  G. R. Hadley,et al.  Multistep method for wide-angle beam propagation. , 1992, Optics letters.

[55]  J. López,et al.  10W near-diffraction-limited peak pulsed power from Al-free, 0.98 /spl mu/m-emitting phase-locked antiguided arrays , 1997 .

[56]  Birgitte Thestrup,et al.  High brightness laser source based on polarization coupling of two diode lasers with asymmetric feedback , 2003 .

[57]  A. Bryce,et al.  Laser structure for generating high optical power in a singlemode waveguide , 1998 .

[58]  Thomas Koprucki,et al.  Simulation of static and dynamic properties of edge-emitting multiple-quantum-well lasers , 2003 .

[59]  M. Krakowski,et al.  Quantitative imaging of intracavity spontaneous emission distributions using tapered lasers fabricated with windowed n-contacts , 2006 .