Thermal performance of nanofluid in ducts with double forward-facing steps

Abstract The turbulent heat transfer to nanofluid flow over double forward-facing steps was investigated numerically. The duct geometry and computational mesh were developed with ANSYS 14 ICEM. Two-dimensional governing equations were discretized and integrated using finite volume technique. The k-ɛ turbulence model was used in the analysis. Al2O3 and CuO nanoparticles at volume fractions varying from 1% to 4% with water as the base fluid were employed for turbulent flow in a passage with a double forward-facing step. The effects of volume fraction and step height were compared with the base fluid thermal performance. The obtained results showed an increase in the Nusselt number with the increase in volume fraction of nanofluid, Reynolds number, and step height. A higher local Nusselt number value was found at the second step compared to the first step for all cases. Velocity contours were developed to visualize the recirculation regions before and after the first and second steps. The results also demonstrated enhanced heat transfer with the increase of nanoparticle concentration, and the largest thermal enhancement factor occurred for the highest nanoparticle volume fraction (4%) of Al2O3 considered in this investigation.

[1]  Mohd Nashrul Mohd Zubir,et al.  Numerical simulation of heat transfer to separation air flow in an annular pipe , 2012 .

[2]  Hosni I. Abu-Mulaweh,et al.  Turbulent mixed convection flow over a forward-facing step—the effect of step heights , 2005 .

[3]  Hakan F. Oztop,et al.  Turbulence forced convection heat transfer over double forward facing step flow , 2006 .

[4]  Salim Newaz Kazi,et al.  A review of studies on forced, natural and mixed heat transfer to fluid and nanofluid flow in an annular passage. , 2014 .

[5]  C. Tinney,et al.  A study of a 3-D double backward-facing step , 2009 .

[6]  Hosni I. Abu-Mulaweh,et al.  Investigations on the Effect of Backward-Facing and Forward-Facing Steps on Turbulent Mixed-Convection Flow Over a Flat Plate , 2009 .

[7]  T. Teng,et al.  The effect of alumina/water nanofluid particle size on thermal conductivity , 2010 .

[8]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[9]  Ahmad Badarudin,et al.  CFD Simulation of Heat Transfer and Turbulent Fluid Flow over a Double Forward-Facing Step , 2013 .

[10]  P. Luchini,et al.  Adjoint analysis of the flow over a forward-facing step , 2009 .

[11]  Salim Newaz Kazi,et al.  An experimental study of heat transfer to turbulent separation fluid flow in an annular passage , 2011 .

[12]  A. Badarudin,et al.  A Review of Experimental Study of Turbulent Heat Transfer in Separated Flow , 2011 .

[13]  S. Aminossadati.  Hydromagnetic natural cooling of a triangular heat source in a triangular cavity with water–CuO nanofluid , 2013 .

[14]  Toshihiko Shakouchi,et al.  Flow and forced-convection heat transfer over forward-facing double steps (effects of step ratio) , 1994 .

[15]  An Li,et al.  Measurements in three-dimensional laminar separated flow , 2003 .

[16]  H. Mohammed,et al.  Numerical Investigation of Heat Transfer from a Two-Dimensional Sudden Expansion Flow Using Nanofluids , 2012 .

[17]  F. Hormozi,et al.  Scale formation and subcooled flow boiling heat transfer of CuO-water nanofluid inside the vertical annulus , 2014 .

[18]  E. Abu-Nada.  Application of nanofluids for heat transfer enhancement of separated flows encountered in a backward facing step , 2008 .

[19]  Mohd Khairol Anuar Mohd Ariffin,et al.  Numerical study of turbulent heat transfer in separated flow: review , 2013 .

[20]  Mohd Khairol Anuar Mohd Ariffin,et al.  Numerical Study of Turbulent Heat Transfer in Annular Pipe with Sudden Contraction , 2013 .

[21]  B. Armaly,et al.  Laminar natural convection flow over a vertical forward-facing step , 1996 .

[22]  Mohd Khairol Anuar Mohd Ariffin,et al.  Heat Transfer and Turbulent Fluid Flow over Vertical Double Forward-Facing Step , 2014 .

[23]  A. Badarudin,et al.  Investigation of Heat Transfer Enhancement in a Forward-Facing Contracting Channel Using FMWCNT Nanofluids , 2014 .

[24]  M. Corcione.  Heat transfer features of buoyancy-driven nanofluids inside rectangular enclosures differentially heated at the sidewalls , 2010 .

[25]  Mohd Khairol Anuar Mohd Ariffin,et al.  Heat Transfer to Laminar Flow over a Double Backward-Facing Step , 2013 .

[26]  Emad Sadeghinezhad,et al.  Numerical simulation of laminar to turbulent nanofluid flow and heat transfer over a backward-facing step , 2014, Appl. Math. Comput..

[27]  S. Sarvari,et al.  Turbulent forced convection flow adjacent to inclined forward step in a duct , 2009 .

[28]  Yanhui Yuan,et al.  The thermal conductivity of alumina nanofluids in water, ethylene glycol, and ethylene glycol + water mixtures , 2010 .

[29]  P. R. Kanna,et al.  Application of an ADI scheme for steady and periodic solutions in a lid‐driven cavity problem , 2007 .

[30]  S. Suresh,et al.  Experimental investigations and theoretical determination of thermal conductivity and viscosity of Al2O3/water nanofluid , 2010 .

[31]  Clement Kleinstreuer,et al.  Impact analysis of nanoparticle motion mechanisms on the thermal conductivity of nanofluids , 2005 .

[32]  Smith Eiamsa-ard,et al.  Heat transfer enhancement by using CuO/water nanofluid in corrugated tube equipped with twisted tape ☆ , 2012 .

[33]  Ravikanth S. Vajjha,et al.  Experimental determination of thermal conductivity of three nanofluids and development of new correlations , 2009 .

[34]  L. Kleiser,et al.  Application of a Spectral Element Method to Two-Dimensional Forward-Facing Step Flow , 2002, J. Sci. Comput..

[35]  Ahmad Badarudin,et al.  Computational simulation of heat transfer to separation fluid flow in an annular passage , 2013 .

[36]  Hakan F. Oztop,et al.  Analysis of turbulent flow and heat transfer over a double forward facing step with obstacles , 2012 .

[37]  I. Tavman,et al.  An Investigation on Thermal Conductivity and Viscosity of Water Based Nanofluids , 2010 .