The effect of natural gas composition on the regulated emissions, gaseous toxic pollutants, and ultrafine particle number emissions from a refuse hauler vehicle

This study investigated the impact of varying natural gas composition on the exhaust emissions from a waste hauler equipped with a 2002 Cummins 8.3L, C Gas Plus, lean burn, spark ignited natural gas engine and an oxidation catalyst while operated on the William H. Martin Refuse Truck Cycle on a chassis dynamometer. The vehicle was tested on seven different fuel gas blends with varying compositions of light hydrocarbon species and inerts, resulting in different properties in terms of methane number and Wobbe number. The higher hydrocarbons gases exhibited higher fuel economy and CO2 (carbon dioxide) emissions. NOx (Nitrogen oxides) emissions were also impacted by fuel composition, and increased for gases with higher levels of heavier hydrocarbons. THC (Total hydrocarbons), CH4 (methane), CO (carbon monoxide), PM (particulate matter), and particle number emissions all showed some reductions for the gases with higher hydrocarbons, higher Wobbe numbers, and higher energy content. Formaldehyde and acetaldehyde were the most dominant aldehydes in the tailpipe, and decreased with the low methane number and high Wobbe number gases. Ammonia emissions did not show consistent fuel trends, however, ammonia emission levels were higher for the higher speed and load phase of the cycle.

[1]  E. R. Jayaratne,et al.  A comparative investigation of ultrafine particle number and mass emissions from a fleet of on-road diesel and CNG buses. , 2008, Environmental science & technology.

[2]  M. Gautam,et al.  Effect of an economical oxidation catalyst formulation on regulated and unregulated pollutants from natural gas fueled heavy duty transit buses , 2011 .

[3]  J. G. Crawford,et al.  ENGINE OPERATING PARAMETER EFFECTS ON THE SPECIATED ALDEHYDE AND KETONE EMISSIONS FROM A NATURAL GAS FUELLED ENGINE , 1995 .

[4]  Kimmo Erkkilae,et al.  TRANSIT BUS EMISSION STUDY: COMPARISON OF EMISSIONS FROM DIESEL AND NATURAL GAS BUSES , 2004 .

[5]  R. Okamoto,et al.  Emissions of toxic pollutants from compressed natural gas and low sulfur diesel-fueled heavy-duty transit buses tested over multiple driving cycles. , 2005, Environmental science & technology.

[6]  Paola Helena Barros Zarante,et al.  Evaluating carbon emissions reduction by use of natural gas as engine fuel , 2009 .

[7]  W. O. Siegl,et al.  Improved Emissions Speciation Methodology for Phase II of the Auto/Oil Air Quality Improvement Research Program - Hydrocarbons and Oxygenates , 1993 .

[8]  G. Karavalakis,et al.  Impact of diesel fuels on the emissions of non-regulated pollutants , 2012 .

[9]  Gordon McTaggart-Cowan,et al.  Natural gas fuelling for heavy‐duty on‐road use: current trends and future direction , 2006 .

[10]  A. Winer,et al.  Ammonia emissions from a representative in-use fleet of light and medium-duty vehicles in the California South Coast Air Basin , 2009 .

[11]  W. Bunn,et al.  A comparison of emissions from vehicles fueled with diesel or compressed natural gas. , 2008, Environmental science & technology.

[12]  Panagiota Dilara,et al.  Effect of a change towards compressed natural gas vehicles on the emissions of the Milan waste collection fleet , 2011 .

[13]  A. Kakaee,et al.  The influence of fuel composition on the combustion and emission characteristics of natural gas fueled engines , 2014 .

[14]  David R. Cocker,et al.  Emission rates of regulated pollutants from on-road heavy-duty diesel vehicles , 2006 .

[15]  W. Bushe,et al.  Experimental and kinetic study of autoignition in methane/ethane/air and methane/propane/air mixtures under engine-relevant conditions , 2006 .

[16]  B. Holmén,et al.  Ultrafine PM emissions from natural gas, oxidation-catalyst diesel, and particle-trap diesel heavy-duty transit buses. , 2002, Environmental science & technology.

[17]  P. G. Hill,et al.  The influence of fuel composition on a heavy-duty, natural-gas direct-injection engine , 2010 .

[18]  J Wayne Miller,et al.  Development and application of a mobile laboratory for measuring emissions from diesel engines. 1. Regulated gaseous emissions. , 2004, Environmental science & technology.

[19]  Edward G. Barrett,et al.  Health Effects of Inhaled Gasoline Engine Emissions , 2007, Inhalation toxicology.

[20]  Kent C. Johnson,et al.  Impact of natural gas fuel composition on criteria, toxic, and particle emissions from transit buses equipped with lean burn and stoichiometric engines , 2013 .

[21]  Kubesh.  Effect of gas composition on octane number of natural gas fuels. Topical report, December 1991-March 1992 , 1992 .

[22]  E. R. Jayaratne,et al.  Volatile properties of particles emitted by compressed natural gas and diesel buses during steady-state and transient driving modes. , 2012, Environmental science & technology.

[23]  N. Clark,et al.  Emissions comparisons from alternative fuel buses and diesel buses with a chassis dynamometer testing facility , 1997 .

[24]  Brent G. Schuchmann,et al.  Emission changes resulting from the San Pedro Bay, California Ports Truck Retirement Program. , 2012, Environmental science & technology.

[25]  M. Gambino,et al.  Evaluation of emission toxicity of urban bus engines: compressed natural gas and comparison with liquid fuels. , 2006, The Science of the total environment.

[26]  J. Naber,et al.  Natural Gas Autoignition Under Diesel Conditions: Experiments and Chemical Kinetic Modeling , 1994 .

[27]  Ralph D. Nine,et al.  Chassis Dynamometer Emission Measurements from Refuse Trucks Using Dual-Fuel™ Natural Gas Engines , 2003 .

[28]  Kyugo Hamai,et al.  Effects of Clean Fuels (Reformulated Gasolines, M85, and CNG) on Automotive Emissions , 1992 .

[29]  Tao Huai,et al.  Investigation of NH3 emissions from new technology vehicles as a function of vehicle operating conditions. , 2003, Environmental science & technology.

[30]  Robert L. McCormick,et al.  Effect of Fuel Composition and Altitude on Regulated Emissions from a Lean-Burn, Closed Loop Controlled Natural Gas Engine , 1997 .

[31]  T. Korakianitis,et al.  Natural-gas fueled spark-ignition (SI) and compression-ignition (CI) engine performance and emissions , 2011 .

[32]  Mauro Colombo,et al.  Assessment of on-road emissions of four Euro V diesel and CNG waste collection trucks for supporting air-quality improvement initiatives in the city of Milan. , 2012, The Science of the total environment.

[33]  Bang-quan He,et al.  Spark ignition natural gas engines—A review , 2007 .

[34]  Zhi Ning,et al.  Ultrafine particles from diesel engines induce vascular oxidative stress via JNK activation. , 2009, Free radical biology & medicine.

[35]  Michael D. Feist,et al.  The Effect of Fuel Composition on Performance and Emissions of a Variety of Natural Gas Engines , 2010 .

[36]  Francisco Aparicio,et al.  Comparison of GHG emissions from diesel, biodiesel and natural gas refuse trucks of the City of Madrid , 2009 .

[37]  E. R. Jayaratne,et al.  Particle and gaseous emissions from compressed natural gas and ultralow sulphur diesel-fuelled buses at four steady engine loads. , 2009, The Science of the total environment.

[38]  Thomas D. Durbin,et al.  Air pollutant emissions of light-duty vehicles operating on various natural gas compositions , 2012 .