Design, fabrication, and performance analysis of GaN vertical electron transistors with a buried p/n junction

The Current Aperture Vertical Electron Transistor (CAVET) combines the high conductivity of the two dimensional electron gas channel at the AlGaN/GaN heterojunction with better field distribution offered by a vertical design. In this work, CAVETs with buried, conductive p-GaN layers as the current blocking layer are reported. The p-GaN layer was regrown by metalorganic chemical vapor deposition and the subsequent channel regrowth was done by ammonia molecular beam epitaxy to maintain the p-GaN conductivity. Transistors with high ON current (10.9 kA/cm2) and low ON-resistance (0.4 mΩ cm2) are demonstrated. Non-planar selective area regrowth is identified as the limiting factor to transistor breakdown, using planar and non-planar n/p/n structures. Planar n/p/n structures recorded an estimated electric field of 3.1 MV/cm, while non-planar structures showed a much lower breakdown voltage. Lowering the p-GaN regrowth temperature improved breakdown in the non-planar n/p/n structure. Combining high breakdown vol...

[1]  D. Bour,et al.  Hydrogen passivation of Mg acceptors in GaN grown by metalorganic chemical vapor deposition , 1995 .

[2]  Umesh K. Mishra,et al.  Current status and scope of gallium nitride-based vertical transistors for high-power electronics application , 2013 .

[3]  Umesh K. Mishra,et al.  Lateral and Vertical Transistors Using the AlGaN/GaN Heterostructure , 2013, IEEE Transactions on Electron Devices.

[4]  S. Denbaars,et al.  Mass transport regrowth of GaN for ohmic contacts to AlGaN/GaN , 2001 .

[5]  Bantval J. Baliga,et al.  The future of power semiconductor device technology , 2001, Proc. IEEE.

[6]  Umesh K. Mishra,et al.  AlGaN/GaN current aperture vertical electron transistors with regrown channels , 2004 .

[7]  Shreepad Karmalkar,et al.  Enhancement of breakdown voltage in AlGaN/GaN high electron mobility transistors using a field plate , 2001 .

[8]  F. Recht,et al.  Nonalloyed ohmic contacts in AlGaN/GaN HEMTs by ion implantation with reduced activation annealing temperature , 2006, IEEE Electron Device Letters.

[9]  S. Nakamura,et al.  Thermal Annealing Effects on P-Type Mg-Doped GaN Films , 1992 .

[10]  Characterization of AlGaN/GaN p-n diodes with selectively regrown n-AlGaN by metal-organic chemical-vapor deposition and its application to GaN-based bipolar transistors , 2005 .

[11]  E. Santi,et al.  An assessment of wide bandgap semiconductors for power devices , 2003 .

[12]  B. J. Baliga,et al.  Planar Nearly Ideal Edge-Termination Technique for GaN Devices , 2011, IEEE Electron Device Letters.

[13]  U. K. Mishra,et al.  CAVET on Bulk GaN Substrates Achieved With MBE-Regrown AlGaN/GaN Layers to Suppress Dispersion , 2012, IEEE Electron Device Letters.

[14]  A. Agarwal,et al.  SiC Power Devices for Microgrids , 2010, IEEE Transactions on Power Electronics.

[15]  Isik C. Kizilyalli,et al.  400-A (Pulsed) Vertical GaN p-n Diode With Breakdown Voltage of 700 V , 2014, IEEE Electron Device Letters.

[16]  D. Bour,et al.  1.5-kV and 2.2-m (Omega ) -cm (^{2}) Vertical GaN Transistors on Bulk-GaN Substrates , 2014 .

[17]  Umesh K. Mishra,et al.  Crystallographic orientation dependence of dopant and impurity incorporation in GaN films grown by metalorganic chemical vapor deposition , 2009 .

[18]  B. J. Baliga,et al.  Power semiconductor device figure of merit for high-frequency applications , 1989, IEEE Electron Device Letters.

[19]  Effect of p-doped overlayer thickness on RF-dispersion in GaN junction FETs , 2002, IEEE Electron Device Letters.

[20]  O. Bierwagen,et al.  p-n junctions on Ga-face GaN grown by NH3 molecular beam epitaxy with low ideality factors and low reverse currents , 2010 .

[21]  Y.-F. Wu,et al.  Total GaN solution to electrical power conversion , 2011, 69th Device Research Conference.

[22]  K. Boutros,et al.  1200-V Normally Off GaN-on-Si Field-Effect Transistors With Low Dynamic on -Resistance , 2011, IEEE Electron Device Letters.

[23]  G. Simin,et al.  The 1.6-kV AlGaN/GaN HFETs , 2006, IEEE Electron Device Letters.

[24]  U. Mishra,et al.  The impact of surface states on the DC and RF characteristics of AlGaN/GaN HFETs , 2001 .

[25]  L. Eastman,et al.  The effect of surface passivation on the microwave characteristics of undoped AlGaN/GaN HEMTs , 2000, IEEE Electron Device Letters.

[26]  G. Meneghesso,et al.  Surface-related drain current dispersion effects in AlGaN-GaN HEMTs , 2004, IEEE Transactions on Electron Devices.

[27]  C. Thomsen,et al.  Micro-Raman and cathodoluminescence studies of epitaxial laterally overgrown GaN with tungsten masks: A method to map the free-carrier concentration of thick GaN samples , 2000 .

[28]  S. Denbaars,et al.  Metalorganic chemical vapor deposition of high mobility AlGaN/GaN heterostructures , 1999 .

[29]  A. Chini,et al.  High breakdown voltage AlGaN-GaN HEMTs achieved by multiple field plates , 2004, IEEE Electron Device Letters.

[30]  P. Burke,et al.  Effects of growth temperature on Mg-doped GaN grown by ammonia molecular beam epitaxy , 2012 .