Interface Resolving Two-phase Flow Simulations in Gas Channels Relevant for Polymer Electrolyte Fuel Cells Using the Volume of Fluid Approach

Abstract With the increased concern about energy security, air pollution and global warming, the possibility of using polymer electrolyte fuel cells (PEFCs) in future sustainable and renewable energy systems has achieved considerable momentum. A computational fluid dynamic model describing a straight channel, relevant for water removal inside a PEFC, is devised. A volume of fluid (VOF) approach is employed to investigate the interface resolved two-phase flow behavior inside the gas channel including the gas diffusion layer (GDL) surface. From this study, it is clear that the impact on the two-phase flow pattern for different hydrophobic/hydrophilic characteristics, i.e., contact angles, at the walls and at the GDL surface is significant, compared to a situation where the walls and the interface are neither hydrophobic nor hydrophilic (i.e., 90° contact angle at the walls and also at the GDL surface). A location of the GDL surface liquid inlet in the middle of the gas channel gives droplet formation, while a location at the side of the channel gives corner flow with a convex surface shape (having hydrophilic walls and a hydrophobic GDL interface). Droplet formation only observed when the GDL surface liquid inlet is located in the middle of the channel. The droplet detachment location (along the main flow direction) and the shape of the droplet until detachment are strongly dependent on the size of the liquid inlet at the GDL surface. A smaller liquid inlet at the GDL surface (keeping the mass flow rates constant) gives smaller droplets.

[1]  Xianguo Li,et al.  Water transport in polymer electrolyte membrane fuel cells , 2011 .

[2]  Yutaka Tabe,et al.  Water Transport and PEFC Performance with Different Interface Structure between Micro-Porous Layer and Catalyst Layer , 2016 .

[3]  Yulong Ding,et al.  Numerical investigation of the impact of two-phase flow maldistribution on PEM fuel cell performance , 2014 .

[4]  Junliang Zhang,et al.  Effect of height/width-tapered flow fields on the cell performance of polymer electrolyte membrane fuel cells , 2017 .

[5]  C. Hochenauer,et al.  Water droplet accumulation and motion in PEM (Proton Exchange Membrane) fuel cell mini-channels , 2012 .

[6]  D. Noble,et al.  Simplified models for predicting the onset of liquid water droplet instability at the gas diffusion layer/gas flow channel interface , 2005 .

[7]  J. Benziger,et al.  The role of the gas diffusion layer on slug formation in gas flow channels of fuel cells , 2013 .

[8]  M. Santini,et al.  Micro computed tomography and CFD simulation of drop deposition on gas diffusion layers , 2014 .

[9]  Feng-Yuan Zhang,et al.  Liquid Water Removal from a Polymer Electrolyte Fuel Cell , 2006 .

[10]  Mehdi Mortazavi,et al.  Effect of the PTFE content in the gas diffusion layer on water transport in polymer electrolyte fuel cells (PEFCs) , 2014 .

[11]  Akeel A. Shah,et al.  Recent trends and developments in polymer electrolyte membrane fuel cell modelling , 2011 .

[12]  Ken S. Chen,et al.  Droplet dynamics in a polymer electrolyte fuel cell gas flow channel: Forces, deformation, and detachment. I: Theoretical and numerical analyses , 2012 .

[13]  Adam Z. Weber,et al.  Interactions between liquid-water and gas-diffusion layers in polymer-electrolyte fuel cells , 2015 .

[14]  Omar Z. Sharaf,et al.  An overview of fuel cell technology: Fundamentals and applications , 2014 .

[15]  Ken S. Chen,et al.  Droplet dynamics in a polymer electrolyte fuel cell gas flow channel: Forces, Deformation and detachment. II: Comparisons of analytical solution with numerical and experimental results , 2012 .

[16]  C. Qin.  Numerical investigations on two-phase flow in polymer electrolyte fuel cells , 2012 .

[17]  Chao-Yang Wang,et al.  Liquid Water Transport in Gas Diffusion Layer of Polymer Electrolyte Fuel Cells , 2004 .

[18]  Shohji Tsushima,et al.  Impacts of channel wettability and flow direction on liquid water transport in the serpentine flow field of a polymer electrolyte fuel cell , 2015 .

[19]  Jinsheng Xiao,et al.  Mechanism of water transport in serpentine cathode channels of proton exchange membrane fuel cells , 2012 .

[20]  C. Amon,et al.  Effect of porosity heterogeneity on the permeability and tortuosity of gas diffusion layers in polymer electrolyte membrane fuel cells , 2014 .

[21]  D. Wilkinson,et al.  Three dimensional numerical simulation of gas–liquid two-phase flow patterns in a polymer–electrolyte membrane fuel cells gas flow channel , 2011 .

[22]  Werner Lehnert,et al.  Investigation of water droplet kinetics and optimization of channel geometry for PEM fuel cell cathodes , 2009 .

[23]  K. Bouzek,et al.  Novel approach to mathematical modeling of the complex electrochemical systems with multiple phase interfaces , 2015 .

[24]  S. Souza,et al.  Numerical study of two-phase flow patterns in the gas channel of PEM fuel cells with tapered flow field design , 2014 .

[25]  Mehdi Mortazavi,et al.  In-Plane Microstructure of Gas Diffusion Layers With Different Properties for PEFC , 2013 .

[26]  Alexandra M.F.R. Pinto,et al.  Numerical simulations of two-phase flow in proton exchange membrane fuel cells using the volume of fluid method – A review , 2015 .

[27]  B. Sundén,et al.  Comparison of humidified hydrogen and partly pre-reformed natural gas as fuel for solid oxide fuel cells applying computational fluid dynamics , 2014 .

[28]  B. Sundén,et al.  Evaporative Annular Flow in Micro/Minichannels: A Simple Heat Transfer Model , 2013 .

[29]  Chaoyang Wang,et al.  Numerical modeling of liquid water motion in a polymer electrolyte fuel cell , 2014 .

[30]  Adam Z. Weber,et al.  Liquid-Water Interactions with Gas-Diffusion-Layer Surfaces , 2014 .

[31]  B. Sundén,et al.  SOFC Cell Design Optimization Using the Finite Element Method Based CFD Approach , 2014 .

[32]  Chao-Yang Wang,et al.  Visualization and quantification of cathode channel flooding in PEM fuel cells , 2009 .

[33]  W. Kim,et al.  Numerical simulation of water droplet dynamics in a right angle gas channel of a polymer electrolyte membrane fuel cell , 2015 .

[34]  Zidong Wei,et al.  A Review of Water Management in Polymer Electrolyte Membrane Fuel Cells , 2009 .

[35]  Janko Petrovčič,et al.  Detection of flooding and drying inside a PEM fuel cell stack , 2013 .

[36]  Hua Meng,et al.  Numerical modeling and simulation of PEM fuel cells: Progress and perspective , 2013 .

[37]  Min Xu,et al.  Modeling of an anode supported Solid Oxide Fuel Cell focusing on Thermal Stresses , 2016 .

[38]  Sassi Ben Nasrallah,et al.  Numerical simulation of droplet dynamics in a proton exchange membrane (PEMFC) fuel cell micro-channel , 2015 .

[39]  T. Baumhöfer,et al.  In-plane Neutron Radiography for Studying the Influence of Surface Treatment and Design of Cathode Flow Fields in Direct Methanol Fuel Cells , 2013 .

[40]  Göran Lindbergh,et al.  Flooding of Gas Diffusion Backing in PEFCs Physical and Electrochemical Characterization , 2004 .

[41]  Biao Zhou,et al.  A general model of proton exchange membrane fuel cell , 2008 .

[42]  Ahmet Kusoglu,et al.  A Critical Review of Modeling Transport Phenomena in Polymer-Electrolyte Fuel Cells , 2014 .

[43]  B. Sundén,et al.  Comparing through-plane diffusibility correlations in PEFC gas diffusion layers using the lattice Boltzmann method , 2017 .

[44]  Hong Wang,et al.  A fractal model for determining oxygen effective diffusivity of gas diffusion layer under the dry and wet conditions , 2011 .

[45]  B. Sundén,et al.  Grading the amount of electrochemcial active sites along the main flow direction of an SOFC , 2013 .

[46]  I. Kevrekidis,et al.  Water slug to drop and film transitions in gas-flow channels. , 2013, Langmuir : the ACS journal of surfaces and colloids.

[47]  C. Ponce de León,et al.  Highlights during the development of electrochemical engineering , 2013 .

[48]  Arunachala Mada Kannan,et al.  Nature inspired flow field designs for proton exchange membrane fuel cell , 2013 .

[49]  M. Andersson,et al.  A review of cell-scale multiphase flow modeling, including water management, in polymer electrolyte fuel cells , 2016 .

[50]  C. W. Hirt,et al.  Volume of fluid (VOF) method for the dynamics of free boundaries , 1981 .

[51]  M. Mench,et al.  FUEL CELLS – PROTON-EXCHANGE MEMBRANE FUEL CELLS | Water Management , 2009 .

[52]  Xueguan Song,et al.  Numerical analysis of the optimum membrane/ionomer water content of PEMFCs: The interaction of Nafion® ionomer content and cathode relative humidity , 2015 .