Downstream processing and purification of eicosapentaenoic (20:5n-3) and arachidonic acids (20:4n-6) from the microalga Porphyridium cruentum

Eicosapentaenoic acid (FPA, 20:5n-3) and arachidonic acid (AA, 20:4n-3)were obtained from the microalga Porphyridium cruentum by a three-stepprocess: fatty acid extraction by direct saponification of biomass,polyunsaturated fatty acid (PUFA) concentration by urea inclusion complexingand EPA isolation by high-performance liquid chromatography (HPLC). Twosolvents were tested for direct saponification of lipids in biomass. Themost efficient solvent, ethanol (96% v/v), extracted 75% ofthe fatty acids. PUFAs concentration by urea inclusion employed a urea/fattyacid ratio of 4:1 wt/wt at the crystallization temperatures of 4°C and28°C. Concentration factors were similar at both temperatures, but theEPA and AA recoveries were higher at 28°C (67.7% and 61.8%for the two acids, respectively). EPA and AA were purified from this PUFAconcentrate using analytical scale HPLC and the best results of thisseparation were scaled up to preparative level (4.7 i. d. × 30 cmcompression radial cartridge). A 94.3% pure EPA fraction and a81.4% pure AA fraction were obtained. Suitability of severalmicroalgae (Porphyridium cruentum, Phaeodactylum tricornutum and Isochrysisgalbana) and cod liver oil as sources of highly pure PUFAs, mainly EPA, wascompared.

[1]  Joint Fao.  Dietary fats and oils in human nutrition : report of an expert consultation , 1978 .

[2]  J. Dyerberg.  Linolenate-derived polyunsaturated fatty acids and prevention of atherosclerosis. , 2009, Nutrition reviews.

[3]  S. Innis.  Essential fatty acids in growth and development. , 1991, Progress in lipid research.

[4]  E. Molina Grima,et al.  Comparison between extraction of lipids and fatty acids from microalgal biomass , 1994 .

[5]  V. Ziboh.  Omega 3 polyunsaturated fatty acid constituents of fish oil and the management of skin inflammatory and scaly disorders. , 1991, World review of nutrition and dietetics.

[6]  O. Ward,et al.  Screening of algae for potential alternative sources of eicosapentaenoic acid , 1991 .

[7]  R. Chandra,et al.  Biochemical and cellular effects of fish and fish oils. , 1988, Progress in food & nutrition science.

[8]  Z. Cohen,et al.  Preparation of eicosapentaenoic acid (EPA) concentrate fromPorphyridium cruentum , 1991 .

[9]  B. Richardson,et al.  Effects of nitrogen limitation on the growth and composition of unicellular algae in continuous culture. , 1969, Applied microbiology.

[10]  J. G. Sanchez,et al.  Cuantificación de ácidos grasos a partir de biomasa microalgal , 1993 .

[11]  E. Grima,et al.  Eicosapentaenoic acid (20∶5n-3) from the marine microalgaPhaeodactylum tricornutum , 1996 .

[12]  S. Katoh,et al.  Arachidonic acid production by the red alga Porphyridium cruentum , 1983, Biotechnology and bioengineering.

[13]  B. Casetta,et al.  Atmospheric-pressure ionization mass-spectrometric analysis of new anionic surfactants: The alkylpolyglucoside esters , 1995 .

[14]  A. Sournia.  Atlas du phytoplancton marin , 1986 .

[15]  G. Lepage,et al.  Improved recovery of fatty acid through direct transesterification without prior extraction or purification. , 1984, Journal of lipid research.

[16]  E. Grima,et al.  Concentration and purification of stearidonic, eicosapentaenoic, and docosahexaenoic acids from cod liver oil and the marine microalgaIsochrysis galbana , 1995 .

[17]  R. Appleby,et al.  The distribution and biosynthesis of arachidonic acid in algae , 1969 .

[18]  E. M. Grima,et al.  Obtención de concentrados de ácidos grasos poliinsaturados por el método de los compuestos de inclusión de urea , 1995 .

[19]  A. Simopoulos.  Omega-3 fatty acids in health and disease and in growth and development. , 1991, The American journal of clinical nutrition.

[20]  J. Ramus.  THE PRODUCTION OF EXTRACELLULAR POLYSACCHARIDE BY THE UNICELLULAR RED ALGA PORPHYRIDIUM AERUGINEUM 1, 2 , 1972 .