Experimental identification of rotating instability of an axial fan with shrouded rotor

The rotating instability phenomenon is investigated experimentally on a laboratory low-speed axial fan. Unsteady pressure measurements are performed close to the rotor leading edge, in the far-field in the upstream-duct section, and within the rotating frame by using Kulite sensors near the blade tip. As reference, the occurrence of rotating instability is proven for a rotor configuration with large clearance size. Existing explanations assume that rotating instability is induced by the tip clearance vortex. Following these models, the characteristic spectral and modal signatures of rotating instability are generated by the circumferentially coupled unsteady vortex systems within the individual blade passages. However, some early findings on a shrouded rotor setup and a study on an annular cascade without clearance have raised questions about the validity of the existing theories. To answer these questions, a second configuration is investigated using the identical rotor in a shrouded version. Here, a shrouding band covers the blade tips over the whole circumference. By using a comprehensive sensor arrangement in a wide variation of operating conditions, the existence of spectral and modal rotating instability signatures is proven on the shrouded-rotor configuration, as well. In this case, the tip clearance vortex system and, respectively, the leakage flow are suppressed. The present study underlines that novel explanations are required to describe the physical mechanism that generates rotating instability.

[1]  W. Neise,et al.  Active flow control to reduce the tip clearance noise and improve the aerodynamic performance of axial turbomachines , 2003 .

[2]  M. Baumgartner,et al.  Non-Engine Order Blade Vibration in a High Pressure Compressor , 1995 .

[3]  T. Fukano,et al.  The effects of tip clearance on the noise of low pressure axial and mixed flow fans , 1986 .

[4]  Konrad Vogeler,et al.  Rotating Instabilities in an Axial Compressor Originating From the Fluctuating Blade Tip Vortex , 2000 .

[5]  Dennis K. McLaughlin,et al.  Experiments on the unsteady flow field and noise generation in a centrifugal pump impeller , 2003 .

[6]  Ulf Tapken,et al.  Time-resolved rotating Instability Waves in an annular Cascade , 2012 .

[7]  Ulf Tapken,et al.  Experiments on an Axial Fan Stage: Time-Resolved Analysis of Rotating Instability Modes , 2014 .

[8]  Wolfgang Neise,et al.  Sound Generation in Centrifugal Compressors , 2008 .

[9]  Ulf Tapken,et al.  Technique to Analyze Characteristics of Turbomachinery Broadband Noise Sources , 2010 .

[10]  Chunill Hah,et al.  An Experimental and Numerical Investigation Into the Mechanisms of Rotating Instability , 2001 .

[11]  W. Neise,et al.  ROTATING BLADE FLOW INSTABILITY AS A SOURCE OF NOISE IN AXIAL TURBOMACHINES , 1997 .

[12]  Ulf Tapken,et al.  Rotating Instability in an Annular Cascade: Detailed Analysis of the Instationary Flow Phenomena , 2014 .

[13]  Frank Truckenmüller.  Untersuchungen zur aerodynamisch induzierten Schwingungsanregung von Niederdruck-Laufschaufeln bei extremer Teillast , 2003 .

[14]  Li He,et al.  A Numerical Investigation of Rotating Instability in Steam Turbine Last Stage , 2011 .

[15]  B. D. Mugridge.  The measurement of spinning acoustic modes generated in an axial flow fan , 1969 .

[16]  L. Enghardt B. Pardowitz,et al.  Influence of the Clearance Size on Rotating Instability in an Axial Compressor Stator , 2013 .

[17]  W. Neise,et al.  ON THE AZIMUTHAL MODE STRUCTURE OF ROTATING BLADE FLOW INSTABILITIES IN AXIAL TURBOMACHINES , 1996 .

[18]  Carsten Haukap.  Zur Korrelation von Schaufelschwingungen und rotierenden Strömungsphänomenen in Axialverdichtern , 2006 .

[19]  Aiaa Paper.  In-Duct and Far-Field Mode Detection Techniques for Engine Exhaust Noise Measurements , 2007 .

[20]  W. Neise,et al.  Experimental Study of Tip Clearance Losses and Noise in Axial Turbomachines , 1997 .

[21]  Josef Ballmann,et al.  Topologie und Entstehung von Blattspitzenwirbeln in transsonischen Verdichterrotoren und ihr Einfluss auf die Stabilitätsgrenze , 2006 .