Design optimization and comparison of large direct-drive permanent magnet wind generator systems

The objective of this paper is to investigate the most cost-effective individual direct-drive permanent magnet (PM) wind generator systems by using the system design optimization method. Firstly, the analytical models of a three-phase radial-flux PM generator with a back to back power converter are presented. The design optimization is developed with a genetic algorithm for the minimum generator system cost. In order to demonstrate the electromagnetic designs and the optimization models, the design results of a 500-kW direct-drive PM generator are compared. Then, the optimal design approach is further employed for a range of power ratings from 750-kW up to 10-MW. The optimization results of the investigated generator systems are obtained. The criteria used for comparisons are considered, based on not only the generator design indexes, but also the annual energy production (AEP) per cost at the typical wind climates, respectively. Finally, the suitable ranges of the most cost-effective PM wind generator systems are also discussed.

[1]  N. Bianchi,et al.  Permanent magnet generators for wind power industry: an overall comparison with traditional generators , 1996 .

[2]  Anders Grauers,et al.  Design of Direct-driven Permanent-magnet Generators for Wind Turbines , 1996 .

[3]  R. Poore,et al.  Alternative Design Study Report: WindPACT Advanced Wind Turbine Drive Train Designs Study; November 1, 2000 -- February 28, 2002 , 2003 .

[4]  Birgitte Bak-Jensen,et al.  Conceptual survey of Generators and Power Electronics for Wind Turbines , 2001 .

[5]  Zbigniew Michalewicz,et al.  Handbook of Evolutionary Computation , 1997 .

[6]  Li Han,et al.  OPTIMIZATION FOR INDUCTION MOTOR DESIGN BY IMPROVED GENETIC ALGORITHM , 2004 .

[7]  Marian Kazmierkowski.  The Electric Generators Handbook Volume I: Synchronous Generators and Volume IIii: variable speed generators (Boldea, I.; 2006) - [Book Review] , 2007, IEEE Industrial Electronics Magazine.

[8]  Design of the Zephyros Z 72 wind turbine with emphasis on the direct drive PM generator , 2004 .

[9]  H. Polinder,et al.  Comparison of direct-drive and geared generator concepts for wind turbines , 2005, IEEE International Conference on Electric Machines and Drives, 2005..

[10]  Asko Parviainen,et al.  Design of axial-flux permanent-magnet low-speed machines and performance comparison between radial-flux and axial-flux machines , 2005 .

[11]  Han Li,et al.  Application research based on improved genetic algorithm for optimum design of power transformers , 2001, ICEMS'2001. Proceedings of the Fifth International Conference on Electrical Machines and Systems (IEEE Cat. No.01EX501).

[12]  Stefan Lundberg.  Performance comparison of wind park configurations , 2003 .

[13]  Maxime R. Dubois,et al.  Optimized Permanent Magnet Generator Topologies for Direct-Drive Wind Turbines , 2004 .