Examination of the expander leaving loss in variable organic Rankine cycle operation

Abstract The organic Rankine cycle (ORC) favorably operates at low temperature. It differs significantly from the steam Rankine cycle in fluid enthalpy drop during expansion and reaction to change in condensation temperature. In current method for ORC-based energy conversion the expander leaving loss is generally neglected. Shortcomings of this method are outlined in this paper. Theoretical analysis of the expander leaving loss varying with the condensation temperature, evaporation temperature, and inlet pressure is first performed. Experimental test is subsequently carried out. The results indicate that unlike in the steam Rankine cycle, the leaving loss in the ORC on using R123 or R245fa increases by about 10 times as the condensation temperature changes from 30 to 0 °C, and is comparable with the enthalpy drop. With an inlet temperature of about 97 °C and a deviation of about 20 °C from the design condensation temperature, the ratio of the leaving loss to the enthalpy drop is about 10.4%. Besides, variation in the leaving loss may lead to expansion wave or shock wave inside the expander. The leaving loss becomes an important factor and should be included to determine the ORC year-round performance.

[1]  M. M. Prieto,et al.  Thermodynamic analysis of high-temperature regenerative organic Rankine cycles using siloxanes as working fluids , 2011 .

[2]  Na Zhang,et al.  General characteristics of single shaft microturbine set at variable speed operation and its optimization , 2004 .

[3]  Yan Shi,et al.  Aerodynamic Design and Numerical Investigation on Overall Performance of a Microradial Turbine With Millimeter-Scale , 2010 .

[4]  Li Zhao,et al.  Experimental investigation on the low-temperature solar Rankine cycle system using R245fa , 2011 .

[5]  Takahisa Yamamoto,et al.  Design and testing of the Organic Rankine Cycle , 2001 .

[6]  Vincent Lemort,et al.  Testing and modeling a scroll expander integrated into an Organic Rankine Cycle , 2009 .

[7]  O. Pin,et al.  Temperature measurements by CARS and intrusive probe in an air-hydrogen supersonic combustion , 1998 .

[8]  J. Laverre,et al.  The recovery factor of thermocouples placed in a subsonic flow , 1976 .

[9]  Chia-Chin Chuang,et al.  Performance effects of combined cycle power plant with variable condenser pressure and loading , 2005 .

[10]  S. L. Dixon,et al.  Fluid mechanics, thermodynamics of turbomachinery , 1966 .

[11]  Jie Ji,et al.  Energetic and exergetic investigation of an organic Rankine cycle at different heat source temperatures , 2012 .

[12]  Javier Royo,et al.  Assessment of high temperature organic Rankine cycle engine for polygeneration with MED desalination: A preliminary approach , 2012 .

[13]  Richard N. Christensen,et al.  EXPERIMENTAL TESTING OF GEROTOR AND SCROLL EXPANDERS USED IN, AND ENERGETIC AND EXERGETIC MODELING OF, AN ORGANIC RANKINE CYCLE , 2009 .

[14]  George Papadakis,et al.  Experimental evaluation of an autonomous low-temperature solar Rankine cycle system for reverse osmosis desalination , 2007 .

[15]  Jie Ji,et al.  Evaluation of external heat loss from a small-scale expander used in organic Rankine cycle , 2011 .

[16]  Ulli Drescher,et al.  Fluid selection for the Organic Rankine Cycle (ORC) in biomass power and heat plants , 2007 .

[17]  M. J. Moran,et al.  Fundamentals of Engineering Thermodynamics , 2014 .

[18]  Mathieu Sellier,et al.  An iterative method for modelling the air‐cooled organic Rankine cycle geothermal power plant , 2011 .

[19]  Alan H. Epstein,et al.  Millimeter-Scale, MEMS Gas Turbine Engines , 2003 .

[20]  Alan H. Epstein,et al.  Millimeter-Scale, Micro-Electro-Mechanical Systems Gas Turbine Engines , 2004 .

[21]  Tao Guo,et al.  Selection of working fluids for a novel low-temperature geothermally-powered ORC based cogeneration system , 2011 .

[22]  Mathieu Sellier,et al.  Efficiency improvement for geothermal power generation to meet summer peak demand , 2009 .

[23]  George Kosmadakis,et al.  Identification of behaviour and evaluation of performance of small scale, low-temperature Organic Rankine Cycle system coupled with a RO desalination unit , 2009 .

[24]  Baudoin Philippon.  Design of a film cooled MEMS micro turbine , 2001 .

[25]  Vincent Lemort,et al.  Experimental study and modeling of an Organic Rankine Cycle using scroll expander , 2010 .

[26]  Jie Ji,et al.  Construction and dynamic test of a small-scale organic rankine cycle , 2011 .

[27]  T. Hung.  Waste heat recovery of organic Rankine cycle using dry fluids , 2001 .

[28]  Lourdes García-Rodríguez,et al.  Analysis and optimization of the low-temperature solar organic Rankine cycle (ORC) , 2010 .

[30]  Stefano Rebay,et al.  Real-gas effects in Organic Rankine Cycle turbine nozzles , 2008 .

[31]  Lourdes García-Rodríguez,et al.  Preliminary design of seawater and brackish water reverse osmosis desalination systems driven by low-temperature solar organic Rankine cycles (ORC). , 2010 .

[32]  Isabell M. Welpe,et al.  Fundamental experiment of pumpless Rankine-type cycle for low-temperature heat recovery , 2011 .

[33]  Jiang Wang,et al.  Performance evaluation of a low-temperature solar Rankine cycle system utilizing R245fa , 2010 .

[34]  Costante Mario Invernizzi,et al.  The potential role of organic bottoming Rankine cycles in steam power stations , 1999 .