Scale reduction and cleaning techniques during direct contact membrane distillation of seawater reverse osmosis brine

Abstract Scale reduction and cleaning techniques were investigated for direct contact membrane distillation (DCMD) during processing of seawater reverse osmosis (SWRO) brine at feed and distillate temperature of 50 °C and 25 °C, respectively. The results showed that MD achieved distillate electrical conductivity (EC) of less than 5 μS/cm and good flux (above 20 L/m2/h) prior to rapid flux reduction at a brine feed EC of approximately 160 mS/cm. Analysis by inductively coupled plasma (ICP) and scanning electron microscopy coupled with an energy dispersive spectroscopy (SEM–EDS) revealed that flux reduction was primarily caused by precipitation of CaCO3 and CaSO4. Titration results showed that concentrating brine feed water pH was linked to distillate flux, and further revealed the precipitation process of CaCO3. Implementation of a 0.45 μm cartridge filter at the brine feed inlet extended water recovery from 45% to 60% due to the removal of precipitating salts. Simple chemical free membrane cleaning regime involving distillate flushing restored MD initial flux to 98%. Periodic raw SWRO brine feed flushing also restored membrane initial flux to 84% over 133 h of operation. Results also showed that possible organic fouling developed over long-term MD operation with constant EC of SWRO brine at feed.

[1]  Marek Gryta,et al.  Polyphosphates used for membrane scaling inhibition during water desalination by membrane distillation , 2012 .

[2]  Marek Gryta,et al.  Fouling in direct contact membrane distillation process , 2008 .

[3]  Abel Riaza,et al.  Comparative study of brine management technologies for desalination plants , 2014 .

[4]  Ludovic F. Dumée,et al.  Advances in Membrane Distillation for Water Desalination and Purification Applications , 2013 .

[5]  M. Gryta.  Alkaline scaling in the membrane distillation process , 2008 .

[6]  Enrico Drioli,et al.  Membrane distillation of concentrated brines—Role of water activities in the evaluation of driving force , 2006 .

[7]  Mohamed Khayet,et al.  Direct contact membrane distillation of humic acid solutions , 2004 .

[8]  Tai-Shung Chung,et al.  Development of hollow fiber membranes for water and salt recovery from highly concentrated brine via direct contact membrane distillation and crystallization , 2012 .

[9]  J. Lienhard,et al.  Erratum to Thermophysical properties of seawater: A review of existing correlations and data , 2010 .

[10]  Mikel Duke,et al.  Performance assessment of membrane distillation for skim milk and whey processing. , 2014, Journal of dairy science.

[11]  D. A. Roberts,et al.  Impacts of desalination plant discharges on the marine environment: A critical review of published studies. , 2010, Water research.

[12]  Enrico Drioli,et al.  Membrane distillation-crystallization of seawater reverse osmosis brines , 2010 .

[13]  Jun-de Li,et al.  Identification of material and physical features of membrane distillation membranes for high performance desalination , 2010 .

[14]  F. Baraud,et al.  Efficiency of five scale inhibitors on calcium carbonate precipitation from hard water: Effect of temperature and concentration , 2009 .

[15]  Nicholas Milne,et al.  Economic analysis of desalination technologies in the context of carbon pricing, and opportunities for membrane distillation , 2013 .

[16]  T. Melin,et al.  Physical aspects of membrane scaling , 2008 .

[17]  G. Falini,et al.  Calcium Carbonate Morphology and Structure in the Presence of Seawater Ions and Humic Acids , 2009 .

[18]  Tzahi Y. Cath,et al.  A scaling mitigation approach during direct contact membrane distillation , 2011 .

[19]  K. Sirkar,et al.  Studies on scaling of membranes in desalination by direct contact membrane distillation: CaCO3 and mixed CaCO3/CaSO4 systems , 2009 .

[20]  Enrico Drioli,et al.  Membrane distillation operated at high seawater concentration factors: Role of the membrane on CaCO3 scaling in presence of humic acid , 2010 .

[21]  Corinne Cabassud,et al.  Vacuum membrane distillation of seawater reverse osmosis brines. , 2010, Water research.

[22]  Jun-de Li,et al.  Modelling heat and mass transfers in DCMD using compressible membranes , 2012 .

[23]  Anthony G. Fane,et al.  Membrane distillation crystallization of concentrated salts—flux and crystal formation , 2005 .

[24]  Tzahi Y. Cath,et al.  High recovery of concentrated RO brines using forward osmosis and membrane distillation , 2009 .

[25]  J. V. Del Bene,et al.  Ocean brine disposal , 1994 .

[26]  Stephen R Gray,et al.  Fouling mechanisms of dairy streams during membrane distillation , 2013 .

[27]  Marek Gryta,et al.  Influence of polypropylene membrane surface porosity on the performance of membrane distillation process , 2007 .

[28]  William D. McCain,et al.  The properties of petroleum fluids , 1973 .

[29]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[30]  E. Drioli,et al.  Potential of membrane distillation in seawater desalination: Thermal efficiency, sensitivity study and cost estimation , 2008 .

[31]  K. Sirkar,et al.  Effects of antiscalants to mitigate membrane scaling by direct contact membrane distillation , 2009 .

[32]  Stephen R Gray,et al.  Fouling of dairy components on hydrophobic polytetrafluoroethylene (PTFE) membranes for membrane distillation , 2013 .

[33]  Jun-de Li,et al.  Predicting the influence of operating conditions on DCMD flux and thermal efficiency for incompressible and compressible membrane systems , 2013 .

[34]  K. Sirkar,et al.  Potential for scaling by sparingly soluble salts in crossflow DCMD , 2008 .