Effect of growth temperature on defects in epitaxial GaN film grown by plasma assisted molecular beam epitaxy

We report the effect of growth temperature on defect states of GaN epitaxial layers grown on 3.5 μm thick GaN epi-layer on sapphire (0001) substrates using plasma assisted molecular beam epitaxy. The GaN samples grown at three different substrate temperatures at 730, 740 and 750 °C were characterized using atomic force microscopy and photoluminescence spectroscopy. The atomic force microscopy images of these samples show the presence of small surface and large hexagonal pits on the GaN film surfaces. The surface defect density of high temperature grown sample is smaller (4.0 × 108 cm−2 at 750 °C) than that of the low temperature grown sample (1.1 × 109 cm−2 at 730 °C). A correlation between growth temperature and concentration of deep centre defect states from photoluminescence spectra is also presented. The GaN film grown at 750 °C exhibits the lowest defect concentration which confirms that the growth temperature strongly influences the surface morphology and affects the optical properties of the GaN ep...

[1]  Shunro Fuke,et al.  Selective etching of GaN polar surface in potassium hydroxide solution studied by x-ray photoelectron spectroscopy , 2001 .

[2]  B. Monemar,et al.  On the lattice parameters of GaN , 2007 .

[3]  Structural and optical properties of GaN thin films grown on Al2O3 substrates by MOCVD at different reactor pressures , 2011 .

[4]  T. Seong,et al.  Growth of high-quality GaN on Si(111) substrate by ultrahigh vacuum chemical vapor deposition , 2001 .

[5]  D. Sarma,et al.  Ultranarrow and widely tunable Mn2+-Induced photoluminescence from single Mn-doped nanocrystals of ZnS-CdS alloys. , 2013, Physical review letters.

[6]  S. Nakamura,et al.  Excitonic emissions from hexagonal GaN epitaxial layers , 1996 .

[7]  S. Denbaars,et al.  Homoepitaxial growth of GaN under Ga-stable and N-stable conditions by plasma-assisted molecular beam epitaxy , 1997 .

[8]  J. Speck,et al.  In situ GaN decomposition analysis by quadrupole mass spectrometry and reflection high-energy electron diffraction , 2008, 2401.17339.

[9]  P. Larsen,et al.  Statistical photoluminescence of dislocations and associated defects in heteroepitaxial GaN grown by metal organic chemical vapor deposition , 2005 .

[10]  Colin J. Humphreys,et al.  On the origin of threading dislocations in GaN films , 2009 .

[11]  Tai-Yuan Lin,et al.  Nature of the 2.8-eV photoluminescence band in Si-doped GaN , 2000 .

[12]  A. Gupta,et al.  Temperature-dependent studies of defect-assisted light emission and excitation processes in crystalline ZnO nanowire phosphors , 2010 .

[13]  Nita Dilawar Sharma,et al.  Highly c-axis oriented growth of GaN film on sapphire (0001) by laser molecular beam epitaxy using HVPE grown GaN bulk target , 2013 .

[14]  M. Khan,et al.  Neutral‐donor‐bound exciton recombination dynamics in GaN grown by metalorganic chemical vapor deposition , 1995 .

[15]  Robert F. Karlicek,et al.  Competition between band gap and yellow luminescence in GaN and its relevance for optoelectronic devices , 1996 .

[16]  Christoph Adelmann,et al.  Dynamically stable gallium surface coverages during plasma-assisted molecular-beam epitaxy of (0001) GaN , 2002 .

[17]  Lester F. Eastman,et al.  The role of dislocation scattering in n-type GaN films , 1998 .

[18]  Structural Characterization and Ultraviolet Photoresponse of GaN Nanodots Grown by Molecular Beam Epitaxy , 2012 .

[19]  J. Speck,et al.  Influence of Ga/N ratio on morphology, vacancies, and electrical transport in GaN grown by molecular beam epitaxy at high temperature , 2010 .

[20]  R. Street.  Recombination in a-Si:H: Direct luminescence , 1980 .

[21]  H. Furuya,et al.  Successful natural stress-induced separation of hydride vapor phase epitaxy-grown GaN layers on sapphire substrates , 2012 .

[22]  R. Korotkov,et al.  Analysis of the temperature and excitation intensity dependencies of photoluminescence in undoped GaN films , 2001 .

[23]  D. Demchenko,et al.  Yellow luminescence of gallium nitride generated by carbon defect complexes. , 2013, Physical review letters.

[24]  Kovalev,et al.  Properties of the yellow luminescence in undoped GaN epitaxial layers. , 1995, Physical review. B, Condensed matter.

[25]  Christiane Poblenz,et al.  Optimization of the surface morphologies and electron mobilities in GaN grown by plasma-assisted molecular beam epitaxy , 2000 .

[26]  Dimitris Pavlidis,et al.  Photoluminescence properties of GaN grown on compliant silicon-on-insulator substrates , 1997 .

[27]  James S. Speck,et al.  Dislocation mediated surface morphology of GaN , 1999 .

[28]  James S. Speck,et al.  Structural evolution in epitaxial metalorganic chemical vapor deposition grown GaN films on sapphire , 1995 .

[29]  Pierre Gibart,et al.  TEMPERATURE QUENCHING OF PHOTOLUMINESCENCE INTENSITIES IN UNDOPED AND DOPED GAN , 1999 .

[30]  E. Yu,et al.  Low defect-mediated reverse-bias leakage in (0001) GaN via high-temperature molecular beam epitaxy , 2010 .

[31]  Krüger,et al.  Strain-related phenomena in GaN thin films. , 1996, Physical review. B, Condensed matter.

[32]  M. Khan,et al.  Growth of epitaxial GaN films by pulsed laser deposition , 1997 .