Biofuels, vehicle emissions, and urban air quality.

Increased biofuel content in automotive fuels impacts vehicle tailpipe emissions via two mechanisms: fuel chemistry and engine calibration. Fuel chemistry effects are generally well recognized, while engine calibration effects are not. It is important that investigations of the impact of biofuels on vehicle emissions consider the impact of engine calibration effects and are conducted using vehicles designed to operate using such fuels. We report the results of emission measurements from a Ford F-350 fueled with either fossil diesel or a biodiesel surrogate (butyl nonanoate) and demonstrate the critical influence of engine calibration on NOx emissions. Using the production calibration the emissions of NOx were higher with the biodiesel fuel. Using an adjusted calibration (maintaining equivalent exhaust oxygen concentration to that of the fossil diesel at the same conditions by adjusting injected fuel quantities) the emissions of NOx were unchanged, or lower, with biodiesel fuel. For ethanol, a review of the literature data addressing the impact of ethanol blend levels (E0-E85) on emissions from gasoline light-duty vehicles in the U.S. is presented. The available data suggest that emissions of NOx, non-methane hydrocarbons, particulate matter (PM), and mobile source air toxics (compounds known, or suspected, to cause serious health impacts) from modern gasoline and diesel vehicles are not adversely affected by increased biofuel content over the range for which the vehicles are designed to operate. Future increases in biofuel content when accomplished in concert with changes in engine design and calibration for new vehicles should not result in problematic increases in emissions impacting urban air quality and may in fact facilitate future required emissions reductions. A systems perspective (fuel and vehicle) is needed to fully understand, and optimize, the benefits of biofuels when blended into gasoline and diesel.

[1]  Thomas C. Long,et al.  Effects of Cold Temperature and Ethanol Content on VOC Emissions from Light-Duty Gasoline Vehicles. , 2015, Environmental science & technology.

[2]  Aron D. Butler,et al.  Influence of Fuel PM Index and Ethanol Content on Particulate Emissions from Light-Duty Gasoline Vehicles , 2015 .

[3]  R. Suarez-Bertoa,et al.  Impact of ethanol containing gasoline blends on emissions from a flex-fuel vehicle tested over the Worldwide Harmonized Light duty Test Cycle (WLTC) , 2015 .

[4]  Kent C. Johnson,et al.  Assessing the impacts of ethanol and isobutanol on gaseous and particulate emissions from flexible fuel vehicles. , 2014, Environmental science & technology.

[5]  Mark A. Villela,et al.  Evaluating the regulated emissions, air toxics, ultrafine particles, and black carbon from SI-PFI and SI-DI vehicles operating on different ethanol and iso-butanol blends , 2014 .

[6]  Carl T. Lira,et al.  Cold flow properties for blends of biofuels with diesel and jet fuels , 2014 .

[7]  Robert Albert Stein,et al.  An Overview of the Effects of Ethanol-Gasoline Blends on SI Engine Performance, Fuel Efficiency, and Emissions , 2013 .

[8]  Michael Howard Shelby,et al.  Fuel Economy and CO 2 Emissions of Ethanol-Gasoline Blends in a Turbocharged DI Engine , 2013 .

[9]  Charles E. Newman,et al.  Effect of Ethanol on Part Load Thermal Efficiency and CO 2 Emissions of SI Engines , 2013 .

[10]  J. Yanowitz,et al.  Impact of adaptation on flex-fuel vehicle emissions when fueled with E40. , 2013, Environmental science & technology.

[11]  James E. Anderson,et al.  A Comparison of Combustion and Emissions of Diesel Fuels and Oxygenated Fuels in a Modern DI Diesel Engine , 2012 .

[12]  Thomas G. Leone,et al.  High octane number ethanol–gasoline blends: Quantifying the potential benefits in the United States , 2012 .

[13]  Michael Howard Shelby,et al.  Effect of Heat of Vaporization, Chemical Octane, and Sensitivity on Knock Limit for Ethanol - Gasoline Blends , 2012 .

[14]  M. Yassine,et al.  Impact of Ethanol Fuels on Regulated Tailpipe Emissions , 2012 .

[15]  Thomas D. Durbin,et al.  Impacts of ethanol fuel level on emissions of regulated and unregulated pollutants from a fleet of gasoline light-duty vehicles , 2012 .

[16]  M. Maricq,et al.  The Impact of Ethanol Fuel Blends on PM Emissions from a Light-Duty GDI Vehicle , 2012 .

[17]  C H Hall,et al.  Control-variable-based accommodation of biodiesel blends , 2011 .

[18]  John T. Tester,et al.  The Impacts of Mid-level Biofuel Content in Gasoline on SIDI Engine-out and Tailpipe Particulate Matter Emissions , 2010 .

[19]  Koichiro Aikawa,et al.  Development of a Predictive Model for Gasoline Vehicle Particulate Matter Emissions , 2010 .

[20]  John M. E. Storey,et al.  Ethanol Blend Effects On Direct Injection Spark-Ignition Gasoline Vehicle Particulate Matter Emissions , 2010 .

[21]  Ole John Nielsen,et al.  Vapor Pressures of Alcohol−Gasoline Blends , 2010 .

[22]  Ole John Nielsen,et al.  Distillation Curves for Alcohol−Gasoline Blends , 2010 .

[23]  Timothy J. Wallington,et al.  Implications of the Energy Independence and Security Act of 2007 for the US Light-Duty Vehicle Fleet , 2009 .

[24]  Lisa Graham,et al.  Emissions from light duty gasoline vehicles operating on low blend ethanol gasoline and E85 , 2008 .

[25]  Leon A. LaPointe,et al.  Effects of Methyl Ester Biodiesel Blends on NOx Emissions , 2008 .

[26]  W. Carter.  Development of Ozone Reactivity Scales for Volatile Organic Compounds , 1994 .

[27]  James E. Anderson,et al.  Ethanol and air quality: influence of fuel ethanol content on emissions and fuel economy of flexible fuel vehicles. , 2014, Environmental science & technology.

[28]  J. Gaffney,et al.  The impacts of combustion emissions on air quality and climate - From coal to biofuels and beyond , 2009 .

[29]  T. W. Ryan,et al.  Exhaust Emissions of Biodiesel, Petrodiesel, Neat Methyl Esters, and Alkanes in a New Technology Engine† , 2006 .