Single crystal silicon nano-wire piezoresistors for mechanical sensors

A p-type silicon (Si) nano-wire piezoresistor, whose minimum cross-sectional area is 53 nm/spl times/53 nm, was fabricated by combination of thermal diffusion, EB (electron beam) direct writing and RIE (reactive ion etching). The maximum value of longitudinal piezoresistance coefficient /spl pi//sub l[011]/ of the Si nano-wire piezoresistor was found to be 48/spl times/10/sup -5/ (1/MPa) at surface impurity concentration of 5/spl times/10/sup 19/ (cm/sup -3/) and it has enough sensitivity for mechanical sensor applications. The longitudinal piezoresistance coefficient /spl pi//sub l[011]/ of the Si nano-wire piezoresistor increased up to 60% with a decrease in the cross sectional area, while transverse piezoresistance coefficient /spl pi//sub t[011]/ decreased with a increase in the aspect ratio of the cross section. These phenomena were briefly investigated based on a hole energy consideration and FEM (finite element method) stress analysis.

[1]  O. N. Tufte,et al.  Piezoresistive Properties of Silicon Diffused Layers , 1963 .

[2]  G. Feher,et al.  Cyclotron Resonance Experiments in Uniaxially Stressed Silicon: Valence Band Inverse Mass Parameters and Deformation Potentials , 1963 .

[3]  G. E. Pikus,et al.  Symmetry and strain-induced effects in semiconductors , 1974 .

[4]  J.D. Meindl,et al.  Modeling and optimization of monolithic polycrystalline silicon resistors , 1981, IEEE Transactions on Electron Devices.

[5]  J. Wortman,et al.  Young's Modulus, Shear Modulus, and Poisson's Ratio in Silicon and Germanium , 1965 .

[6]  Robert Plana,et al.  Formation of ultra-shallow p + /n junctions using BF 2 implantation for the fabrication of improved piezoresistive cantilevers , 2001 .

[7]  E. F. Schubert,et al.  Doping in III-V Semiconductors , 1993 .

[8]  Bruce D. Terris,et al.  5 MHz, 2 N/m piezoresistive cantilevers with INCISIVE tips , 1997, Proceedings of International Solid State Sensors and Actuators Conference (Transducers '97).

[9]  J. Thaysen,et al.  Environmental sensors based on micromachined cantilevers with integrated read-out , 2000, Ultramicroscopy.

[10]  P. Y. Yu,et al.  Fundamentals of Semiconductors , 1995 .

[11]  M. Roukes.  Nanoelectromechanical Systems , 2000, cond-mat/0008187.

[12]  S. Sugiyama,et al.  Characteristics of silicon nano wire as piezoresistor for nano electro mechanical systems , 2001, Technical Digest. MEMS 2001. 14th IEEE International Conference on Micro Electro Mechanical Systems (Cat. No.01CH37090).

[13]  Nanometric Sensing and Processing with Micromachined Functional Probe , 2001 .

[14]  T. Kenny,et al.  1/f noise considerations for the design and process optimization of piezoresistive cantilevers , 2000, Journal of Microelectromechanical Systems.

[15]  J. Seto.  The electrical properties of polycrystalline silicon films , 1975 .

[16]  A. Boisen,et al.  Cantilever-based bio-chemical sensor integrated in a microliquid handling system , 2001, Technical Digest. MEMS 2001. 14th IEEE International Conference on Micro Electro Mechanical Systems (Cat. No.01CH37090).

[17]  W. Häberle,et al.  The “Millipede”—More than 1000 Tips for Parallel and Dense Data Storage , 2001 .

[18]  Chuang,et al.  Spin-orbit-coupling effects on the valence-band structure of strained semiconductor quantum wells. , 1992, Physical review. B, Condensed matter.

[19]  Yozo Kanda,et al.  Piezoresistance effect of silicon , 1991 .

[20]  A. S. Grove.  Physics and Technology of Semiconductor Devices , 1967 .

[21]  S. Timoshenko,et al.  THEORY OF PLATES AND SHELLS , 1959 .