Measurement of trunk muscle fatigue during dynamic lifting and lowering as recovery time changes

The purpose of this study was to identify the relationship between the cumulative fatigue of trunk muscles and the recovery time during dynamic lifting and lowering in symmetric and asymmetric postures. Ten subjects participated in the experiment. Recovery times of 1, 2, 3, 4, or 5 min were applied, respectively, during a 9 min period of lifting and lowering. The lifting weight was set equal to 25% of the individual’s maximum voluntary condition (MVC); a lifting frequency of 4 lifts/min was used. Electromyography (EMG) signals from 10 trunk muscles were collected and analyzed in terms of mean power frequency (MPF) before and after the lifting/lowering tasks. Fatigue level was analyzed by using analysis of variance (ANOVA). As a result, a partial recovery was observed from 3 min recovery time during symmetric lifting. In 4 min, 70% of subjects experienced a recovery of at least two trunk muscles in symmetric lifting and 10% in asymmetric lifting. In 5 min recovery time, 90% of the subjects showed a recovery of at least two trunk muscles in symmetric lifting, and 50% in asymmetric lifting. It should be noted that not all subjects were recovered in 5 min. In conclusion, proper work/rest ratios based upon the level of individual muscle fatigue may be used as an early intervention to prevent muscle fatigue in the workplace. In addition, designing an ergonomic workplace would require incorporating data from this study with other factors. Relevance to industry

[1]  Jeong-Ryong Kim.  A Study of Trunk Muscle Fatigue and Recovery Time during Isometric Extension Tasks , 2002 .

[2]  J. Cram,et al.  Introduction to Surface Electromyography , 1998 .

[3]  Moshe Solomonow,et al.  Work to rest durations ratios exceeding unity are a risk factor for low back disorder; a feline model. , 2007, Journal of electromyography and kinesiology : official journal of the International Society of Electrophysiological Kinesiology.

[4]  W S Marras,et al.  The effects of mats on back and leg fatigue. , 1994, Applied ergonomics.

[5]  W S Marras,et al.  Biomechanical risk factors for occupationally related low back disorders. , 1995, Ergonomics.

[6]  R. Kadefors,et al.  An electromyographic index for localized muscle fatigue. , 1977, Journal of applied physiology: respiratory, environmental and exercise physiology.

[7]  J. H. van Dieen,et al.  Towards an optimal sampling strategy of EMG and EMG spectral parameters, when using test contractions to monitor muscle fatigue , 1996 .

[8]  Sang-Do Lee,et al.  A Study on Physical Work Capacity and Rest Allowance for Korean , 2001 .

[9]  W Rohmert,et al.  Problems of determination of rest allowances Part 2: determining rest allowances in different human tasks. , 1973, Applied ergonomics.

[10]  W S Marras,et al.  A Comprehensive Evaluation of Trunk Response to Asymmetric Trunk Motion , 1992, Spine.

[11]  K F Murrell,et al.  An Industrial Experiment in Organized Rest Pauses , 1969, Human factors.

[12]  S. McGill,et al.  Measured and modelled static and dynamic axial trunk torsion during twisting in males and females. , 1990, Journal of biomedical engineering.

[13]  A. Schultz,et al.  Analysis of Loads on the Lumbar Spine , 1981, Spine.

[14]  Tae-Yong Lee,et al.  Analysis of Trunk Muscle Fatigue as the Frequency of Lifting/Lowering and Recovery Time Change , 2006 .

[15]  A. R. Lind,et al.  The influence of temperature on the amplitude and frequency components of the EMG during brief and sustained isometric contractions , 2004, European Journal of Applied Physiology and Occupational Physiology.

[16]  A Garg,et al.  Revised NIOSH equation for the design and evaluation of manual lifting tasks. , 1993, Ergonomics.

[17]  Recovery of electromyograph median frequency after lumbar muscle fatigue analysed using an exponential time dependence model , 2002, European Journal of Applied Physiology.

[18]  M K Chung,et al.  Effects of posture, weight and frequency on trunk muscular activity and fatigue during repetitive lifting tasks. , 1995, Ergonomics.

[19]  J Winkel,et al.  Can occupational guidelines for work-rest schedules be based on endurance time data? , 1992, Ergonomics.

[20]  H. Kwatny,et al.  An application of signal processing techniques to the study of myoelectric signals. , 1970, IEEE transactions on bio-medical engineering.

[21]  W Rohmert,et al.  Problems in determining rest allowances Part 1: use of modern methods to evaluate stress and strain in static muscular work. , 1973, Applied ergonomics.

[22]  Myung‐Chul Jung,et al.  The sensitivity of autoregressive model coefficient in quantification of trunk muscle fatigue during a sustained isometric contraction , 2005 .