Comparative environmental behavior of bus engine operating on blends of diesel fuel with four straight vegetable oils of Greek origin: Sunflower, cottonseed, corn and olive

Abstract An experimental study is conducted to evaluate the use of sunflower, cottonseed, corn and olive straight vegetable oils (SVO) of Greek origin, in blends with diesel fuel at proportions of 10 vol.% and 20 vol.%, in a fully instrumented, six-cylinder, turbocharged and after-cooled, heavy duty (HD), direct injection (DI), ‘Mercedes-Benz’, mini-bus engine installed at the authors’ laboratory. The series of tests are conducted using each of the above blends, with the engine working at two speeds and three loads. Fuel consumption, exhaust smokiness and exhaust regulated gas emissions such as nitrogen oxides (NO x ), carbon monoxide (CO) and total unburned hydrocarbons (HC) are measured. With reference to the corresponding neat diesel fuel operation, the vegetable oil blends show reduction of emitted smoke with slight increase of NO x and effectively unaffected thermal efficiency. Theoretical aspects of diesel engine combustion, combined with the very widely differing physical and chemical properties of the vegetable oils against those for the diesel fuel, aid to the correct interpretation of the observed engine behavior.

[1]  Yiannis A. Levendis,et al.  Control of Diesel Soot, Hydrocarbon and NOx Emissions with a Particulate Trap and EGR , 1994 .

[2]  Meinrad Signer,et al.  The Influence of Fuel Properties and Injection Timing on the Exhaust Emissions and Fuel Consumption of an Iveco Heavy-Duty Diesel Engine , 1997 .

[3]  D. J. Rickeard,et al.  A Review of the Potential for Bio-Fuels as Transportation Fuels , 1993 .

[4]  José Rodríguez-Fernández,et al.  Performance, combustion and emissions of a diesel engine operated with reformed EGR. Comparison of diesel and GTL fuelling , 2009 .

[5]  C. Lee,et al.  Characteristics of Biofuels and Renewable Fuel Standards , 2010 .

[6]  C. E. Goering,et al.  Diesel Engine Combustion of Sunflower Oil Fuels , 1984 .

[7]  Dimitrios C. Rakopoulos,et al.  Investigation of the combustion of neat cottonseed oil or its neat bio-diesel in a HSDI diesel engine by experimental heat release and statistical analyses , 2010 .

[8]  C. D. Rakopoulos,et al.  Investigation of the performance and emissions of bus engine operating on butanol/diesel fuel blends , 2010 .

[9]  Dimitrios C. Rakopoulos,et al.  Comparative performance and emissions study of a direct injection Diesel engine using blends of Diesel fuel with vegetable oils or bio-diesels of various origins , 2006 .

[10]  Avinash Kumar Agarwal,et al.  Performance and emissions characteristics of Jatropha oil (preheated and blends) in a direct injection compression ignition engine , 2007 .

[11]  S. K. Haldar,et al.  Studies on the comparison of performance and emission characteristics of a diesel engine using three degummed non-edible vegetable oils , 2009 .

[12]  Mustafa Canakci,et al.  Performance and exhaust emissions of a biodiesel engine , 2006 .

[13]  L. M. Das,et al.  Feasibility of blending karanja vegetable oil in petro-diesel and utilization in a direct injection diesel engine , 2009 .

[14]  Robert L. McCormick,et al.  Combustion of fat and vegetable oil derived fuels in diesel engines , 1998 .

[15]  Qin Zhang,et al.  Ethanol-diesel fuel blends -- a review. , 2005, Bioresource technology.

[16]  Dimitrios C. Rakopoulos,et al.  Multi-zone modeling of combustion and emissions formation in DI diesel engine operating on ethanol–diesel fuel blends , 2008 .

[17]  J. Agudelo,et al.  Effect of altitude and palm oil biodiesel fuelling on the performance and combustion characteristics of a HSDI diesel engine , 2009 .

[18]  M. J. Jacobus,et al.  SINGLE-CYLINDER DIESEL ENGINE STUDY OF FOUR VEGETABLE OILS , 1983 .

[19]  A. Demirbas,et al.  Biodiesel fuels from vegetable oils via catalytic and non-catalytic supercritical alcohol transesterifications and other methods: a survey , 2003 .

[20]  Dimitrios C. Rakopoulos,et al.  Multi-zone modeling of Diesel engine fuel spray development with vegetable oil, bio-diesel or Diesel fuels , 2006 .

[21]  P. N. Blumberg,et al.  Evaluation of Cottonseed Oils as Diesel Fuel , 1982 .

[22]  Emmanuel Kakaras,et al.  Characteristics of the performance and emissions of a HSDI diesel engine running with cottonseed oil or its methyl ester and their blends with diesel fuel , 2007 .

[23]  Dimitrios C. Kyritsis,et al.  An experimental comparison of non-premixed bio-butanol flames with the corresponding flames of ethanol and methane , 2011 .

[24]  C. D. Rakopoulos,et al.  Performance and emissions of bus engine using blends of diesel fuel with bio-diesel of sunflower or cottonseed oils derived from Greek feedstock , 2008 .

[25]  Abollé Abollé,et al.  The viscosity of diesel oil and mixtures with straight vegetable oils: palm, cabbage palm, cotton, groundnut, copra and sunflower. , 2009 .

[26]  R. Barlow,et al.  Scalar profiles and NO formation in laminar opposed-flow partially premixed methane/air flames , 2001 .

[27]  C. N. Michos,et al.  Studying the effects of hydrogen addition on the second-law balance of a biogas-fuelled spark ignition engine by use of a quasi-dimensional multi-zone combustion model , 2008 .

[28]  A. Shaheed,et al.  Combustion analysis of coconut oil and its methyl esters in a diesel engine , 1999 .

[29]  Ram Prasad,et al.  TRIGLYCERIDES-BASED DIESEL FUELS , 2000 .

[30]  C. D. Rakopoulos,et al.  Comparative performance and emission studies when using olive oil as a fuel supplement in DI and IDI diesel engines , 1992 .

[31]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[32]  A. Humke,et al.  Performance and Emissions Characteristics of a Naturally Aspirated Diesel Engine with Vegetable Oil Fuels-(Part 2) , 1981 .

[33]  Robert S. Barlow,et al.  Piloted jet flames of CH4/H2/air: Experiments on localized extinction in the near field at high Reynolds numbers , 2009 .

[34]  H. Pitsch,et al.  Structural group analysis for soot reduction tendency of oxygenated fuels , 2008 .

[35]  C. A. Larsen,et al.  An Optimization Study on the Control of NOx and Particulate Emissions from Diesel Engines , 1996 .

[36]  George Kosmadakis,et al.  Evaluation of a combustion model for the simulation of hydrogen spark-ignition engines using a CFD code , 2010 .

[37]  José Antonio Velásquez,et al.  Heat release and engine performance effects of soybean oil ethyl ester blending into diesel fuel , 2011 .

[38]  N Miyamoto,et al.  Approaches to extremely low emissions and efficient diesel combustion with oxygenated fuels , 2000 .

[39]  Evangelos G. Giakoumis,et al.  Second-law analyses applied to internal combustion engines operation , 2006 .

[40]  Dimitrios C. Rakopoulos,et al.  Experimental heat release analysis and emissions of a HSDI diesel engine fueled with ethanol–diesel fuel blends , 2007 .

[41]  K. S. Varde.  Bulk modulus of vegetable oil-diesel fuel blends , 1984 .

[42]  Dimitrios C. Rakopoulos,et al.  Development and application of multi-zone model for combustion and pollutants formation in direct injection diesel engine running with vegetable oil or its bio-diesel , 2007 .

[43]  Alain A. Vertès,et al.  Biomass to Biofuels: Strategies for Global Industries , 2011 .

[44]  Constantine D. Rakopoulos,et al.  Numerical Investigation into the Formation of CO and Oxygenated and Nonoxygenated Hydrocarbon Emissions from Isooctane- and Ethanol-Fueled HCCI Engines , 2010 .

[45]  Dimitrios C. Rakopoulos,et al.  Effects of ethanol-diesel fuel blends on the performance and exhaust emissions of heavy duty DI diesel engine , 2008 .