Effect of coiling treatment on microstructural development and precipitate strengthening of a strip cast steel

The effect of a simulated coiling treatment on a strip cast Nb-containing steel has been investigated. A lath ferritic supersaturated microstructure was observed in the as-cast condition with no coiling. The microstructure remained lath like during coiling at high temperature (850 °C) and the formation of chemically complex Nb-rich precipitates containing C, N, Si and S was observed. Coiling at an intermediate temperature (700 °C) caused the formation of polygonal ferrite with a dendritic morphology due to chemical micro-segregation. The polygonal ferrite contained Nb(C,N) precipitates. The microstructure remained lath like at the lowest coiling temperature (600 °C). In the latter case the precipitation of Nb-rich clusters was observed, and atom probe tomography revealed them to be ∼85% Fe. Small angle neutron scattering and transmission electron microscopy were used to quantify precipitation kinetics during coiling and the mechanical properties were evaluated with a shear punch apparatus. A yield strength model was developed to describe the observed mechanical behaviour, and this showed that the two largest contributors to strength were the bainitic microstructure and the Nb-rich precipitates. Strategies to further strengthen these materials are suggested.

[1]  L. T. Shiang,et al.  The microstructures of strip-cast low-carbon steels and their response to thermal processing , 1989 .

[2]  Nikolai Zapuskalov,et al.  Comparison of Continuous Strip Casting with Conventional Technology , 2003 .

[3]  S. Shanmugam,et al.  Microstructure and high strength–toughness combination of a new 700 MPa Nb-microalloyed pipeline steel , 2008 .

[4]  G. Fournet,et al.  Small‐Angle Scattering of X‐Rays , 1956 .

[5]  S. Ringer,et al.  Effect of Nb Microalloying and Hot Rolling on Microstructure and Properties of Ultrathin Cast Strip Steels Produced by the CASTRIP® Process , 2011 .

[6]  C. M. Sellars,et al.  Precipitation of NbC in a model austenitic steel , 2002 .

[7]  Simon P. Ringer,et al.  A quantitative atom probe study of the Nb excess at prior austenite grain boundaries in a Nb microalloyed strip-cast steel , 2012 .

[8]  Peter Hodgson,et al.  Quantitative examination of carbide and sulphide precipitates in chemically complex steels processed by direct strip casting , 2016 .

[9]  A. Deschamps,et al.  Precipitation behavior and its effect on strengthening of an HSLA-Nb/Ti steel , 2001 .

[10]  M. Ferry,et al.  Microstructural control by secondary processing of strip cast low carbon steel , 2001 .

[11]  A. Deschamps,et al.  Influence of predeformation and agEing of an Al–Zn–Mg alloy—II. Modeling of precipitation kinetics and yield stress , 1998 .

[12]  M. Ferry,et al.  Direct strip casting of metals and alloys , 2006 .

[13]  Reiner Kopp,et al.  Some current development trends in metal-forming technology , 1996 .

[14]  S. S. Campos,et al.  Role of interphase precipitation in microalloyed hot strip steels , 2006 .

[15]  T. Dorin,et al.  Effect of Cooling Rate on Phase Transformations in a High-Strength Low-Alloy Steel Studied from the Liquid Phase , 2015, Metallurgical and Materials Transactions A.

[16]  M. K. Miller,et al.  Atom-Probe Tomography: The Local Electrode Atom Probe , 2014 .

[17]  H. Kestenbach.  Dispersion hardening by niobium carbonitride precipitation in ferrite , 1997 .

[18]  Harold R Kaul,et al.  Cluster strengthening of Nb-microalloyed ultra-thin cast strip steels produced by the CASTRIP® process , 2013 .

[19]  A. Deschamps,et al.  A small‐angle neutron scattering study of fine‐scale NbC precipitation kinetics in the α‐Fe–Nb–C system , 2006 .

[20]  Joe Herbertson,et al.  Experimental Studies of Interfacial Heat Transfer and Initial Solidification Pertinent to Strip Casting , 1998 .

[21]  P. Hodgson,et al.  Correlation of tensile test properties with those predicted by the shear punch test , 2013 .

[22]  K. Cardoso,et al.  Quantitative study of carbonitride precipitation in niobium and titanium microalloyed hot strip steel , 1997 .

[23]  Baptiste Gault,et al.  Atom Probe Microscopy , 2012 .

[24]  M. Béreš,et al.  TEM Investigations of Fine Niobium Precipitates in HSLA Steel , 2004 .

[25]  P. Hodgson,et al.  Static recrystallization of strip cast alloys in the presence of complex nano-sulfide and nitride precipitates , 2013 .

[26]  Terry Noakes,et al.  ‘Quokka’—the small-angle neutron scattering instrument at OPAL , 2006 .

[27]  G. L’espérance,et al.  Microstructure and Mechanical Properties of Strip Cast 1008 Steel after Simulated Coiling, Cold Rolling and Batch Annealing , 1996 .

[28]  Rama Ballav Mahapatra,et al.  Development of low carbon thin strip production capability at project 'M' , 2000 .