Insight into segregation sites for oxygen impurities at grain boundaries in silicon

The three-dimensional distribution of oxygen atoms segregated at Σ9{114} grain boundaries (GBs) in Czochralski-grown silicon ingots is analyzed within a high spatial resolution of less than 0.5 nm by atom probe tomography combined with a focused ion beam (FIB) operated at −150 °C. The analysis reveals a segregation of oxygen atoms within a range of 2.5 nm across the GB plane, which is much narrower in comparison with the previous reports obtained using a conventional FIB. The oxygen concentration profile accurately reflects the distribution of the segregation sites, which exist at bond-centered sites under tensile stresses above 2 GPa, as calculated by ab initio local stress calculations.

[1]  Y. Shiihara,et al.  Ab Initio Local-Energy and Local-Stress Calculations for Materials Science and Engineering , 2020, MATERIALS TRANSACTIONS.

[2]  Y. Ohno,et al.  Origin of recombination activity of non-coherent Σ3{111} grain boundaries with a positive deviation in the tilt angle in cast-grown silicon ingots , 2020, Applied Physics Express.

[3]  Y. Ohno,et al.  Chemical bonding at room temperature via surface activation to fabricate low-resistance GaAs/Si heterointerfaces , 2020 .

[4]  Y. Ohno,et al.  Generation of dislocation clusters at triple junctions of random angle grain boundaries during cast growth of silicon ingots , 2020, Applied Physics Express.

[5]  P. Krenckel,et al.  Atom Probe Tomography Study of Gettering in High-Performance Multicrystalline Silicon , 2020, IEEE Journal of Photovoltaics.

[6]  M. Sabatino,et al.  Interfacial atomic structure and electrical activity of nano-facetted CSL grain boundaries in high-performance multi-crystalline silicon , 2020 .

[7]  Y. Noda,et al.  Neural-network interatomic potential for grain boundary structures and their energetics in silicon , 2020 .

[8]  Y. Ohno,et al.  Impact of focused ion beam on structural and compositional analysis of interfaces fabricated by surface activated bonding , 2019, Japanese Journal of Applied Physics.

[9]  Dierk Raabe,et al.  Strain-Induced Asymmetric Line Segregation at Faceted Si Grain Boundaries. , 2018, Physical review letters.

[10]  Y. Ohno,et al.  Interaction of sodium atoms with stacking faults in silicon with different Fermi levels , 2018 .

[11]  Y. Ohno,et al.  Nanoscopic analysis of oxygen segregation at tilt boundaries in silicon ingots using atom probe tomography combined with TEM and ab initio calculations , 2017, Journal of microscopy.

[12]  Yanjun Li,et al.  Lattice distortion induced site dependent carbon gettering at twin boundaries in silicon , 2017 .

[13]  Y. Ohno,et al.  Impact of local atomic stress on oxygen segregation at tilt boundaries in silicon , 2017 .

[14]  J. Baruchel,et al.  Formation mechanism and properties of twinned structures in (111) seeded directionally solidified solar grade silicon , 2016 .

[15]  Y. Ohno,et al.  Recombination activity of nickel, copper, and oxygen atoms segregating at grain boundaries in mono-like silicon crystals , 2016 .

[16]  J. Baruchel,et al.  In situ investigation of the structural defect generation and evolution during the directional solidification of 〈110〉 seeded growth Si , 2016 .

[17]  D. Raabe,et al.  Complex Nanotwin Substructure of an Asymmetric Σ9 Tilt Grain Boundary in a Silicon Polycrystal. , 2015, Physical review letters.

[18]  D. Raabe,et al.  Grain boundary segregation in multicrystalline silicon: correlative characterization by EBSD, EBIC, and atom probe tomography , 2015 .

[19]  T. Sinno,et al.  A mechanistic study of impurity segregation at silicon grain boundaries , 2015 .

[20]  Y. Ohno,et al.  Three-dimensional evaluation of gettering ability for oxygen atoms at small-angle tilt boundaries in Czochralski-grown silicon crystals , 2015 .

[21]  P. Gumbsch,et al.  Interstitial iron impurities at grain boundaries in silicon: A first-principles study , 2015 .

[22]  Y. Ohno,et al.  First principles calculations of solution energies of dopants around stacking faults in Si crystal , 2014 .

[23]  K. Bothe,et al.  Minority carrier lifetime in silicon photovoltaics: The effect of oxygen precipitation , 2014 .

[24]  G. Hahn,et al.  Crystal defects and their impact on ribbon growth on substrate (RGS) silicon solar cells , 2013 .

[25]  Y. Ohno,et al.  Three-dimensional evaluation of gettering ability of Σ3{111} grain boundaries in silicon by atom probe tomography combined with transmission electron microscopy , 2013 .

[26]  Y. Shiihara,et al.  Ab initio local energy and local stress: application to tilt and twist grain boundaries in Cu and Al , 2013, Journal of physics. Condensed matter : an Institute of Physics journal.

[27]  Michael K Miller,et al.  Atom Probe Tomography: Analysis at the Atomic Level , 2012 .

[28]  T. Sekiguchi,et al.  Deep-level photoluminescence due to dislocations and oxygen precipitates in multicrystalline Si , 2012 .

[29]  Deren Yang,et al.  Effect of oxygen precipitation on the performance of Czochralski silicon solar cells , 2011 .

[30]  S. Rein,et al.  Detecting efficiency‐limiting defects in Czochralski‐grown silicon wafers in solar cell production using photoluminescence imaging , 2011 .

[31]  B Gault,et al.  Advances in the reconstruction of atom probe tomography data. , 2011, Ultramicroscopy.

[32]  M. Sabatino,et al.  Oxygen distribution on a multicrystalline silicon ingot grown from upgraded metallurgical silicon , 2011 .

[33]  Y. Shiihara,et al.  Ab initio local stress and its application to Al (111) surfaces , 2010 .

[34]  Otwin Breitenstein,et al.  Luminescence emission from forward- and reverse-biased multicrystalline silicon solar cells , 2009 .

[35]  V. Voronkov,et al.  Rapid Thermal Processing and the Control of Oxygen Precipitation Behaviour in Silicon Wafers , 2008 .

[36]  T. Tamura,et al.  Ab initiocalculations of electric-field-induced stress profiles for diamond/c−BN(110) superlattices , 2007 .

[37]  N. Sakaguchi,et al.  Atomic Structure of Faceted Σ3 CSL Grain Boundary in Silicon: HRTEM and Ab-initio Calculation , 2007 .

[38]  M. Kohyama.  TOPICAL REVIEW: Computational studies of grain boundaries in covalent materials , 2002 .

[39]  M. Uematsu.  Transient Enhanced Diffusion and Deactivation of High-Dose Implanted Arsenic in Silicon , 2000 .

[40]  James D. Plummer,et al.  Arsenic deactivation enhanced diffusion: A time, temperature, and concentration study , 1998 .

[41]  A. Istratov,et al.  Gettering of iron by oxygen precipitates , 1998 .

[42]  E. Weber,et al.  Gettering of metallic impurities in photovoltaic silicon , 1997 .

[43]  David N. Seidman,et al.  Atomic scale studies of solute-atom segregation at grain boundaries: Experiments and simulations☆ , 1994 .

[44]  Arias,et al.  Electron trapping and impurity segregation without defects: Ab initio study of perfectly rebonded grain boundaries. , 1994, Physical review. B, Condensed matter.

[45]  Michael K Miller,et al.  Local magnification effects in the atom probe , 1990 .

[46]  A. Becke.  A multicenter numerical integration scheme for polyatomic molecules , 1988 .

[47]  R. Yamamoto,et al.  Structures and Energies of Symmetrical 〈001〉 Tilt Grain Boundaries in Silicon , 1986 .

[48]  M. Vaudin,et al.  The structure of second and third order twin boundaries in silicon , 1983 .

[49]  G. D. Watkins,et al.  Recombination-enhanced migration of interstitial aluminum in silicon , 1979 .