Transport Studies of AlGaN/GaN Heterostructures of Different Al Mole Fractions With Variable $\hbox{SiN}_{x}$ Passivation Stress

The influence of passivation by silicon nitride (SiNx) of different stress states (compressive, neutral, and tensile) is presented as a function of varying Al mole fraction (x). All types of SiNx passivant induced, as expected, an increase in 2-D electron gas (2DEG) concentration. In addition, however, the 2DEG mobility increased after passivation for the low-x (0.15) sample, and the more tensile the film stress is, the greater the relative increase. This led to a very highly measured 2DEG mobility of 2360 cm2V-1s-1 at 300 K. In higher x samples, however, mobility was decreased after passivation, increasingly so as x increased, and to a varying extent with different stresses. It is apparent from the results that there is a complex relationship between the stress in the SiNx layer, the mole fraction, and the transport properties of the 2DEG. Thus, tailoring of the passivant deposition conditions, and not simply passivant dielectric choice, to optimize transport properties, is critical for a given passivant, deposition tool, and Al mole fraction, to maximize device performance.

[1]  F. Ren,et al.  Effect of plasma enhanced chemical vapor deposition of SiNx on n-GaN Schottky rectifiers , 2002 .

[2]  J. Dell,et al.  Long-term environmental stability of residual stress of SiNx, SiOx, and Ge thin films prepared at low temperatures , 2009 .

[3]  Takashi Jimbo,et al.  Surface passivation effects on AlGaN/GaN high-electron-mobility transistors with SiO2, Si3N4, and silicon oxynitride , 2004 .

[4]  B. Nag,et al.  Electron transport in compound semiconductors , 1980 .

[5]  B. T. McDermott,et al.  Influence of surface processing and passivation on carrier concentrations and transport properties in AlGaN/GaN heterostructures , 2001 .

[6]  T. Fisher,et al.  Scattering mechanisms limiting two-dimensional electron gas mobility in Al0.25Ga0.75N/GaN modulation-doped field-effect transistors , 2000 .

[7]  L. Faraone,et al.  Environmental stability and cryogenic thermal cycling of low-temperature plasma-deposited silicon nitride thin films , 2006 .

[8]  R. Airey,et al.  Influence of dual-frequency plasma-enhanced chemical-vapor deposition Si3N4 passivation on the electrical characteristics of AlGaN/GaN heterostructure field-effect transistors , 2004 .

[9]  Peter A. Houston,et al.  Comparison of different surface passivation dielectrics in AlGaN/GaN heterostructure field-effect transistors , 2002 .

[10]  J. Kim,et al.  AlGaN/GaN metal–oxide–semiconductor high electron mobility transistors using Sc2O3 as the gate oxide and surface passivation , 2003 .

[11]  K. P. Pande,et al.  Passivation of GaAs FET's with PECVD silicon nitride films of different stress states , 1988 .

[12]  Lester F. Eastman,et al.  Slow transients observed in AlGaN/GaN HFETs: effects of SiN/sub x/ passivation and UV illumination , 2003 .

[13]  B. Ridley,et al.  Passivation of AlGaN/GaN heterostructures with silicon nitride for insulated gate transistors , 2000, Proceedings 2000 IEEE/ Cornell Conference on High Performance Devices (Cat. No.00CH37122).

[14]  Takashi Jimbo,et al.  Characterization of different-Al-content AlxGa1−xN/GaN heterostructures and high-electron-mobility transistors on sapphire , 2003 .

[15]  Hiroyasu Ishikawa,et al.  Current collapse-free i-GaN /AlGaN/GaN high-electron-mobility transistors with and without surface passivation , 2004 .

[16]  S. Kolluri,et al.  RF Performance of N-Polar AlGaN/GaN MIS-HEMTs Grown by MOCVD on Sapphire Substrate , 2009, IEEE Electron Device Letters.

[17]  F. Schwierz,et al.  Intrinsically limited mobility of the two-dimensional electron gas in gated AlGaN/GaN and AlGaN/AlN/GaN heterostructures , 2009 .

[18]  M. Higashiwaki,et al.  Cat-CVD SiN-passivated AlGaN-GaN HFETs with thin and high Al composition barrier Layers , 2005, IEEE Electron Device Letters.

[19]  Joseph Salzman,et al.  Electron mobility in an AlGaN/GaN two-dimensional electron gas. I. Carrier concentration dependent mobility , 2003 .

[20]  G. Stoney.  The Tension of Metallic Films Deposited by Electrolysis , 1909 .

[21]  Jerry R. Meyer,et al.  Improved quantitative mobility spectrum analysis for Hall characterization , 1998 .

[22]  Walter Kruppa,et al.  Trapping effects and microwave power performance in AlGaN/GaN HEMTs , 2001 .

[23]  P. Kordos,et al.  Conductivity and Hall effect measurements on intentionally undoped and doped AlGaN/GaN heterostructures before and after passivation , 2003 .

[24]  Yutaka Ohno,et al.  Current Collapse in AlGaN/GaN HEMTs Investigated by Electrical and Optical Characterizations , 2002 .

[25]  U. Mishra,et al.  30-W/mm GaN HEMTs by field plate optimization , 2004, IEEE Electron Device Letters.

[26]  A. Chini,et al.  High breakdown voltage AlGaN-GaN HEMTs achieved by multiple field plates , 2004, IEEE Electron Device Letters.