Field-scale multi-phase LNAPL remediation: Validating a new computational framework against sequential field pilot trials.

Remediation of subsurface systems, including groundwater, soil and soil gas, contaminated with light non-aqueous phase liquids (LNAPLs) is challenging. Field-scale pilot trials of multi-phase remediation were undertaken at a site to determine the effectiveness of recovery options. Sequential LNAPL skimming and vacuum-enhanced skimming, with and without water table drawdown were trialled over 78days; in total extracting over 5m3 of LNAPL. For the first time, a multi-component simulation framework (including the multi-phase multi-component code TMVOC-MP and processing codes) was developed and applied to simulate the broad range of multi-phase remediation and recovery methods used in the field trials. This framework was validated against the sequential pilot trials by comparing predicted and measured LNAPL mass removal rates and compositional changes. The framework was tested on both a Cray supercomputer and a cluster. Simulations mimicked trends in LNAPL recovery rates (from 0.14 to 3mL/s) across all remediation techniques each operating over periods of 4-14days over the 78day trial. The code also approximated order of magnitude compositional changes of hazardous chemical concentrations in extracted gas during vacuum-enhanced recovery. The verified framework enables longer term prediction of the effectiveness of remediation approaches allowing better determination of remediation endpoints and long-term risks.

[1]  M. Kamon,et al.  Modelling of benzene distribution in the subsurface of an abandoned gas plant site after a long term of groundwater table fluctuation , 2012 .

[2]  B. Hobbs,et al.  Theoretical analyses of nonaqueous phase liquid dissolution‐induced instability in two‐dimensional fluid‐saturated porous media , 2010 .

[3]  C. Johnston,et al.  Evaluating the reliability of equilibrium dissolution assumption from residual gasoline in contact with water saturated sands. , 2017, Journal of contaminant hydrology.

[4]  B. Patterson,et al.  Integrating spatial and temporal oxygen data to improve the quantification of in situ petroleum biodegradation rates. , 2013, Journal of environmental management.

[5]  R. Carsel,et al.  Developing joint probability distributions of soil water retention characteristics , 1988 .

[6]  J. Rayner,et al.  A computational assessment of representative sampling of soil gas using existing groundwater monitoring wells screened across the water table. , 2017, Journal of hazardous materials.

[7]  Jack C. Parker,et al.  A parametric model for constitutive properties governing multiphase flow in porous media , 1987 .

[8]  C. Johnston,et al.  Effectiveness of in situ air sparging for removing NAPL gasoline from a sandy aquifer near Perth, Western Australia. , 2002, Journal of contaminant hydrology.

[9]  B. Patterson,et al.  Measurement and Modeling of Temporal Variations in Hydrocarbon Vapor Behavior in a Layered Soil Profile , 2005 .

[10]  C. Johnston,et al.  Dissolution of multi-component LNAPL gasolines: the effects of weathering and composition. , 2014, Journal of contaminant hydrology.

[11]  M. Trefry,et al.  Characteristics of light nonaqueous phase liquid recovery in the presence of fine‐scale soil layering , 2009 .

[12]  B. Kueper,et al.  Modeling Plume Responses To Source Treatment , 2014 .

[13]  K. Lari,et al.  Gasoline Multiphase and Multicomponent Partitioning in the Vadose Zone: Dynamics and Risk Longevity , 2016 .

[14]  Karsten Pruess,et al.  TMVOC-MP: a parallel numerical simulator for Three-Phase Non-isothermal Flows of Multicomponent Hydrocarbon Mixtures in porous/fractured media , 2008 .

[15]  B. Hobbs,et al.  Theoretical analyses of chemical dissolution‐front instability in fluid‐saturated porous media under non‐isothermal conditions , 2015 .

[16]  W. Shiu,et al.  Handbook of Physical-Chemical Properties and Environmental Fate for Organic Chemicals , 2006 .

[17]  D. A. Barry,et al.  Numerical modelling for design and evaluation of groundwater remediation schemes. , 2000 .

[18]  B. Patterson,et al.  Evidence for Instantaneous Oxygen‐Limited Biodegradation of Petroleum Hydrocarbon Vapors in the Subsurface , 2009 .

[19]  Maria Claudia Barbosa,et al.  Simulation of Subsurface Multiphase Contaminant Extraction Using a Bioslurping Well Model , 2016, Transport in Porous Media.

[20]  M. Cardiff,et al.  Estimating Unsaturated Hydraulic Functions for Coarse Sediment from a Field‐Scale Infiltration Experiment , 2014 .

[21]  B. Hobbs,et al.  Effects of medium and pore‐fluid compressibility on chemical‐dissolution front instability in fluid‐saturated porous media , 2012 .

[22]  J. McGarry.  Correlation and prediction of the vapor pressures of pure liquids over large pressure ranges , 1983 .

[23]  G. Suresh Kumar,et al.  Effect of compositional heterogeneity on dissolution of non-ideal LNAPL mixtures. , 2016, Journal of contaminant hydrology.

[24]  Tahir Husain,et al.  An overview and analysis of site remediation technologies. , 2004, Journal of environmental management.

[25]  M. Rivett,et al.  Review of unsaturated-zone transport and attenuation of volatile organic compound (VOC) plumes leached from shallow source zones. , 2011, Journal of contaminant hydrology.

[26]  K. Lari,et al.  Incorporating hysteresis in a multi-phase multi-component NAPL modelling framework; a multi-component LNAPL gasoline example , 2016 .

[27]  Alison Ord,et al.  Fundamentals of Computational Geoscience: Numerical Methods and Algorithms , 2009 .

[29]  Carl L. Yaws,et al.  Transport properties of chemicals and hydrocarbons : viscosity, thermal conductivity, and diffusivity of C1 to C100 organics and Ac to Zr inorganics , 2014 .

[30]  C. D. Johnston,et al.  Removal of petroleum hydrocarbons from the vadose zone during multi-phase extraction at a contaminated industrial site , 2002 .

[31]  B. Patterson,et al.  Volatilisation and biodegradation during air sparging of dissolved BTEX-contaminated groundwater , 1998 .

[32]  B. Hobbs,et al.  Computational simulation of chemical dissolution‐front instability in fluid‐saturated porous media under non‐isothermal conditions , 2015 .

[33]  C. Johnston,et al.  Polar Compounds from the Dissolution of Weathered Diesel , 2009 .

[34]  C. Johnston,et al.  Interfacial Mass Transport in Porous Media Augmented with Bulk Reactions: Analytical and Numerical Solutions , 2014, Transport in Porous Media.

[35]  B. Patterson,et al.  Estimation of Biodegradation Rates Using Respiration Tests During In Situ Bioremediation of Weathered Diesel NAPL , 1998 .

[36]  K. Pruess,et al.  TMVOC, a numerical simulator for three-phase non-isothermal flows of multicomponent hydrocarbon mixtures in saturated-unsaturated heterogeneous media , 2005 .