A Wideband and Low-Loss Spatial Power Combining Module for mm-Wave High-Power Amplifiers

We present a low-loss power combiner, providing a highly integrated interface from an array of mm-wave power amplifiers (PAs) to a single standard rectangular waveguide (WG). The PAs are connected to an array of parallel and strongly coupled microstrip lines that excite a substrate integrated waveguide (SIW) based cavity. The spatially distributed modes then couple from the cavity to the rectangular WG mode through an etched aperture and two stepped ridges embedded in the WG flange. A new co-design procedure for the PA-integrated power combining module is presented that targets optimal system-level performance: output power, efficiency, linearity. A commercial SiGe quad-channel configurable transmitter and a standard gain horn antenna were interfaced to both ends of this module to experimentally demonstrate the proposed power combining concept. Since the combiner input ports are non-isolated, we have investigated the effects of mutual coupling on the transmitter performance by using a realistic PA model. This study has shown acceptable relative phase and amplitude differences between the PAs, $i.e$ . within ±15° and ±1 dB. The increase of generated output power with respect to a single PA at the 1-dB compression point remains virtually constant (5.5 dB) over a 42% bandwidth. The performed statistical active load variation indicates that the interaction between the PAs through the combiner has negligible effect on the overall linearity. Furthermore, the antenna pattern measured with this combiner shows negligible deformation due to non-identical PAs. This represents experimental prove-of-concept of the proposed spatial power combining module, which can be suitable for applications in MIMO array transmitters with potentially coupled array channels.

[1]  G.A.M. Hurkx,et al.  Unified electro-thermal stability criterion for bipolar transistors , 2005, Proceedings of the Bipolar/BiCMOS Circuits and Technology Meeting, 2005..

[2]  Meng-Ju Chiang,et al.  Ka-Band CMOS Hybrids Miniaturization Incorporating Multilayer Synthetic Quasi-TEM Transmission Lines , 2008, 2008 38th European Microwave Conference.

[3]  Gabriel M. Rebeiz,et al.  Miniature Four-Way and Two-Way 24 GHz Wilkinson Power Dividers in 0.13 $\mu$m CMOS , 2007, IEEE Microwave and Wireless Components Letters.

[4]  Zhenqiang Ma,et al.  On the operation configuration of SiGe HBTs based on power gain analysis , 2005, IEEE Transactions on Electron Devices.

[5]  Ockgoo Lee,et al.  Power-Combining Transformer Techniques for Fully-Integrated CMOS Power Amplifiers , 2008, IEEE Journal of Solid-State Circuits.

[6]  Y Yu Pei.  Silicon-based Ka-band reconfigurable phased-array transmitter , 2016 .

[7]  J. Melai,et al.  BiCMOS technology improvements for microwave application , 2008, 2008 IEEE Bipolar/BiCMOS Circuits and Technology Meeting.

[8]  Thomas Zwick,et al.  Active Multiple Feed On-Chip Antennas With Efficient In-Antenna Power Combining Operating at 200–320 GHz , 2017, IEEE Transactions on Antennas and Propagation.

[9]  S. Boumaiza,et al.  60-GHz Power Amplifier in 45-nm SOI-CMOS Using Stacked Transformer-Based Parallel Power Combiner , 2018, IEEE Microwave and Wireless Components Letters.

[10]  Q. J. Gu,et al.  Two-Way Current-Combining $W$-Band Power Amplifier in 65-nm CMOS , 2012, IEEE Transactions on Microwave Theory and Techniques.

[11]  Chao-Wei Wang,et al.  A miniaturized power combiner for compact design of CMOS phase shifter at K-Band , 2010, 2010 IEEE MTT-S International Microwave Symposium.

[12]  D. Harame,et al.  SiGe heterojunction bipolar transistors and circuits toward terahertz communication applications , 2004, IEEE Transactions on Microwave Theory and Techniques.

[13]  Cam Nguyen,et al.  A V-Band Power Amplifier With Integrated Wilkinson Power Dividers-Combiners and Transformers in 0.18- $\mu$ m SiGe BiCMOS , 2019, IEEE Transactions on Circuits and Systems II: Express Briefs.

[14]  Ali Hajimiri,et al.  Multi-Port Driven Radiators , 2013, IEEE Transactions on Microwave Theory and Techniques.

[15]  Telmo R. Cunha,et al.  Power, Linearity, and Efficiency Prediction for MIMO Arrays With Antenna Coupling , 2017, IEEE Transactions on Microwave Theory and Techniques.

[16]  Z. Ma,et al.  An omni-directional comparison between common-emitter and common-base SiGe HBTs , 2006, 2006 8th International Conference on Solid-State and Integrated Circuit Technology Proceedings.

[17]  M. Ivashina,et al.  Wideband mm-Wave Transition Between a Coupled Microstrip Line Array and SIW for High-Power Generation MMICs , 2018, IEEE Microwave and Wireless Components Letters.

[19]  Hua Wang,et al.  A Multifeed Antenna for High-Efficiency On-Antenna Power Combining , 2017, IEEE Transactions on Antennas and Propagation.

[20]  A. Katz,et al.  Linearization: reducing distortion in power amplifiers , 2001 .

[21]  Robert A. York,et al.  Quasi-optical and spatial power combining , 2002 .