Corrosion propagation of prestressing steel strands in concrete subject to chloride attack

Abstract A review of research literature suggests that steel corrosion in concrete can accelerate if the corroding steel is under high levels of stress but this important phenomenon has not been investigated thoroughly. Both laboratory tests and field surveys indicate that the effects of corrosion on structural behaviour in reinforced and prestressed concrete structures are different, with the latter having less concrete cracking but more serious structural collapses. The intention of this paper is to investigate the corrosion propagation of prestressing steel strands in chloride-laden environment. A long term experimental program is presented in which the corrosion of twelve prestressing steel strands embedded in concrete was examined. The effects of the level of stresses in the steel and type of steels on corrosion rate are studied. It is found that the corrosion rate of prestressing steel strands in concrete increases with the increase of the level of stresses applied and that the pitting corrosion is the main form of prestressing steel corrosion in chloride-laden environment. The paper concludes that the corrosion of prestressing steel in concrete structures poses higher risk to the structure than that of reinforcing steel in terms of structural collapse.

[1]  C. L. Page,et al.  Investigations of reinforcement corrosion. 2. Electrochemical monitoring of steel in chloride-contaminated concrete , 1991 .

[2]  Walter Podolny,et al.  CORROSION OF PRESTRESSING STEELS AND ITS MITIGATION , 1992 .

[3]  C. Hansson,et al.  Macrocell and Microcell Corrosion of Steel in Ordinary Portland Cement and High Performance Concretes , 2006 .

[4]  M. S. Darmawan,et al.  Spatial time-dependent reliability analysis of corroding pretensioned prestressed concrete bridge girders , 2007 .

[5]  R. Melchers,et al.  Phenomenological Modeling of Reinforcement Corrosion in Marine Environments , 2006 .

[6]  Z. Bažant.  Closure of "Physical Model for Steel Corrosion in Concrete Sea Structures—Application" , 1980 .

[7]  Richard E. Weyers,et al.  CONCRETE BRIDGE PROTECTION AND REHABILITATION: CHEMICAL AND PHYSICAL TECHNIQUES. SERVICE LIFE ESTIMATES , 1993 .

[8]  Yingshu Yuan,et al.  Modeling corroded section configuration of steel bar in concrete structure , 2009 .

[9]  J. Toribio,et al.  Microstructure-based modelling of localized anodic dissolution in pearlitic steels , 2001 .

[10]  A. Valiente.  Stress corrosion failure of large diameter pressure pipelines of prestressed concrete , 2001 .

[11]  Shamsad Ahmad.  Reinforcement corrosion in concrete structures, its monitoring and service life prediction - A review , 2003 .

[12]  Cj Burgoyne,et al.  DISCUSSION. COLLAPSE OF YNYS-Y-GWAS BRIDGE, WEST GLAMORGAN. , 1988 .

[13]  Brian Cherry,et al.  Pitting, crevice and stress corrosion cracking studies of cold drawn eutectoid steels , 1980 .

[14]  Chun-Qing Li,et al.  Prediction of reinforcement corrosion in concrete and its effects on concrete cracking and strength reduction , 2008 .

[15]  O. A. Kayyali,et al.  THE C1-/OH- RATIO IN CHLORIDE-CONTAMINATED CONCRETE - A MOST IMPORTANT CRITERION , 1995 .

[16]  Chun Qing Li,et al.  Corrosion Initiation of Reinforcing Steel in Concrete under Natural Salt Spray and Service Loading—Results and Analysis , 2000 .

[17]  K. Tuutti.  Corrosion of steel in concrete , 1982 .

[18]  N. R. Short,et al.  Factors affecting the corrosion rate of steel in carbonated mortars , 1991 .

[19]  Xila Liu,et al.  Experimental Research on Corrosion of Reinforcement in Concrete through Cathode-to-Anode Area Ratio , 2000 .

[20]  Morris Schupack,et al.  Some Recent Corrosion Embrittlement Failures of Prestressing Systems in the United States , 1982 .

[21]  Nenad Bićanić,et al.  The influence of w/c ratio, concrete cover thickness and degree of water saturation on the corrosion rate of reinforcing steel in concrete , 1996 .