Comprehensive model of microalgae photosynthesis rate as a function of culture conditions in photobioreactors

In this paper, the influence of culture conditions (irradiance, temperature, pH, and dissolved oxygen) on the photosynthesis rate of Scenedesmus almeriensis cultures is analyzed. Short-run experiments were performed to study cell response to variations in culture conditions, which take place in changing environments such as outdoor photobioreactors. Experiments were performed by subjecting diluted samples of cells to different levels of irradiance, temperature, pH, and dissolved oxygen concentration. Results demonstrate the existence of photoinhibition phenomena at irradiances higher than 1,000 μE/m2 s; in addition to reduced photosynthesis rates at inadequate temperatures or pH—the optimal values being 35 °C and 8, respectively. Moreover, photosynthesis rate reduction at dissolved oxygen concentrations above 20 mg/l is demonstrated. Data have been used to develop an integrated model based on considering the simultaneous influence of irradiance, temperature, pH, and dissolved oxygen. The model fits the experimental results in the range of culture conditions tested, and it was validated using data obtained by the simultaneous variation of two of the modified variables. Furthermore, the model fits experimental results obtained from an outdoor culture of S. almeriensis performed in an open raceway reactor. Results demonstrate that photosynthetic efficiency is modified as a function of culture conditions, and can be used to determine the proximity of culture conditions to optimal values. Optimal conditions found (T = 35 °C, pH = 8, dissolved oxygen concentration <20 mg/l) allows to maximize the use of light by the cells. The developed model is a powerful tool for the optimal design and management of microalgae-based processes, especially outdoors, where the cultures are subject to daily culture condition variations.

[1]  D. Arnon,et al.  Studies on Nitrogen‐fixing Blue‐green Algae , 1955 .

[2]  D. Arnon,et al.  Studies on Nitrogen-Fixing Blue-Green Algae. I. Growth and Nitrogen Fixation by Anabaena Cylindrica Lemm. , 1955, Plant physiology.

[3]  T. G. Owens,et al.  Effects of light intensity on photosynthesis and dark respiration in six species of marine phytoplankton , 1978 .

[4]  J. C. Goldman,et al.  The effect of pH in intensive microalgal cultures. II. Species competition , 1982 .

[5]  J. C. Goldman,et al.  The effect of pH in intensive microalgal cultures. I. Biomass regulation , 1982 .

[6]  A. Richmond,et al.  Production of spirulina biomass: Effects of environmental factors and population density , 1982 .

[7]  J. Peeters,et al.  A model for the relationship between light intensity and the rate of photosynthesis in phytoplankton , 1988 .

[8]  J. Weissman,et al.  Photobioreactor design: Mixing, carbon utilization, and oxygen accumulation , 1988, Biotechnology and bioengineering.

[9]  J. Sevilla,et al.  A study on simultaneous photolimitation and photoinhibition in dense microalgal cultures taking into account incident and averaged irradiances , 1996 .

[10]  P. Gros,et al.  Quantifying the short-term temperature effect on light-saturated photosynthesis of intertidal microphytobenthos , 1996 .

[11]  Growth yield determination in a chemostat culture of the marine microalgaIsochrysis galbana , 1996 .

[12]  J. Sevilla,et al.  Modeling of biomass productivity in tubular photobioreactors for microalgal cultures: effects of dilution rate, tube diameter, and solar irradiance , 1998, Biotechnology and bioengineering.

[13]  E. Grima,et al.  Prediction of dissolved oxygen and carbon dioxide concentration profiles in tubular photobioreactors for microalgal culture , 1999, Biotechnology and bioengineering.

[14]  Y. Chisti,et al.  Photobioreactors: light regime, mass transfer, and scaleup , 1999 .

[15]  S. Ruuska,et al.  Electron flow to oxygen in higher plants and algae: rates and control of direct photoreduction (Mehler reaction) and rubisco oxygenase. , 2000, Philosophical transactions of the Royal Society of London. Series B, Biological sciences.

[16]  Carbon dioxide uptake efficiency by outdoor microalgal cultures in tubular airlift photobioreactors. , 2000, Biotechnology and bioengineering.

[17]  B. Han,et al.  Photosynthesis-irradiance response at physiological level: a mechanistic model. , 2001, Journal of theoretical biology.

[18]  T. Moisan,et al.  Modelling the effect of temperature on the maximum growth rates of phytoplankton populations , 2002 .

[19]  Hugh L. MacIntyre,et al.  PHOTOACCLIMATION OF PHOTOSYNTHESIS IRRADIANCE RESPONSE CURVES AND PHOTOSYNTHETIC PIGMENTS IN MICROALGAE AND CYANOBACTERIA 1 , 2002 .

[20]  Yeoung-Sang Yun,et al.  Kinetic modeling of the light-dependent photosynthetic activity of the green microalga Chlorella vulgaris. , 2003, Biotechnology and bioengineering.

[21]  Carlos Jiménez,et al.  Relationship between physicochemical variables and productivity in open ponds for the production of Spirulina: a predictive model of algal yield , 2003 .

[22]  F. G. Acién Fernández,et al.  Minimization of carbon losses in pilot‐scale outdoor photobioreactors by model‐based predictive control , 2003, Biotechnology and bioengineering.

[23]  Y. Chisti,et al.  A mechanistic model of photosynthesis in microalgae. , 2003, Biotechnology and bioengineering.

[24]  S. Heaney,et al.  Diversity in the influence of temperature on the growth rates of freshwater algae, and its ecological relevance , 2004 .

[25]  O. Pulz,et al.  Valuable products from biotechnology of microalgae , 2004, Applied Microbiology and Biotechnology.

[26]  Ladislav Nedbal,et al.  Microscopic green algae and cyanobacteria in high-frequency intermittent light , 1996, Journal of Applied Phycology.

[27]  F. Marquez,et al.  Inhibitory effect of oxygen accumulation on the growth of Spirulina platensis , 1995, Biotechnology Letters.

[28]  D. Singh,et al.  Photooxidative damage to the cyanobacterium Spirulina platensis mediated by singlet oxygen , 1995, Current Microbiology.

[29]  Manuel Berenguel,et al.  Model predictive control of pH in tubular photobioreactors , 2004 .

[30]  Effect of CO2 enhancement in an outdoor algal production system usingTetraselmis , 2004, Journal of Applied Phycology.

[31]  K. Lika,et al.  A cell-based model for the photoacclimation and CO(2)-acclimation of the photosynthetic apparatus. , 2005, Biochimica et biophysica acta.

[32]  Oxygen evolution rate of photosynthetic microalga Haematococcus pluvialis depending on light intensity and quality , 2006 .

[33]  Jeffrey M. Gordon,et al.  Ultrahigh bioproductivity from algae , 2007, Applied Microbiology and Biotechnology.

[34]  P. Falkowski,et al.  Mix and match: how climate selects phytoplankton , 2007, Nature Reviews Microbiology.

[35]  F. G. Acién,et al.  Biomass and lutein productivity of Scenedesmus almeriensis: influence of irradiance, dilution rate and temperature , 2008, Applied Microbiology and Biotechnology.

[36]  I. Caro Pina,et al.  Kinetic model for growth of Phaeodactylum tricornutum in intensive culture photobioreactor , 2008 .

[37]  Clemens Posten,et al.  Design principles of photo‐bioreactors for cultivation of microalgae , 2009 .

[38]  John R. Benemann,et al.  Microalgal Biomass for Greenhouse Gas Reductions: Potential for Replacement of Fossil Fuels and Animal Feeds , 2009 .

[39]  R. Muñoz,et al.  Biofilm photobioreactors for the treatment of industrial wastewaters. , 2009, Journal of hazardous materials.

[40]  René H. Wijffels,et al.  Maximum Photosynthetic Yield of Green Microalgae in Photobioreactors , 2010, Marine Biotechnology.

[41]  Y. Chisti.  A bioeconomy vision of sustainability… , 2010 .

[42]  José M. Baptista,et al.  Light requirements in microalgal photobioreactors: an overview of biophotonic aspects , 2010, Applied Microbiology and Biotechnology.

[43]  F. G. Acién,et al.  The oxygen evolution methodology affects photosynthetic rate measurements of microalgae in well‐defined light regimes , 2010, Biotechnology and bioengineering.

[44]  Jean-François Cornet,et al.  Experimental and theoretical assessment of maximum productivities for the microalgae Chlamydomonas reinhardtii in two different geometries of photobioreactors , 2009, Biotechnology progress.

[45]  Mathieu Streefland,et al.  Photosynthetic efficiency of Chlamydomonas reinhardtii in flashing light , 2011, Biotechnology and bioengineering.

[46]  J. M. Fernández-Sevilla,et al.  Analysis of light regime in continuous light distributions in photobioreactors. , 2011, Bioresource technology.

[47]  O. Bernard.  Hurdles and challenges for modelling and control of microalgae for CO2 mitigation and biofuel production , 2011 .

[48]  Benoit Guieysse,et al.  Universal temperature model for shallow algal ponds provides improved accuracy. , 2011, Environmental science & technology.

[49]  Andre M. Coleman,et al.  National microalgae biofuel production potential and resource demand , 2011 .

[50]  Thomas H. Bradley,et al.  Geographical Assessment of Microalgae Biofuels Potential Incorporating Resource Availability , 2013, BioEnergy Research.

[51]  F. G. Acién,et al.  Dynamic model of microalgal production in tubular photobioreactors. , 2012, Bioresource technology.

[52]  R. Wijffels,et al.  Growth of the microalgae Neochloris oleoabundans at high partial oxygen pressures and sub-saturating light intensity. , 2012, Bioresource technology.

[53]  E. Molina Grima,et al.  Conversion of CO2 into biomass by microalgae: how realistic a contribution may it be to significant CO2 removal? , 2012, Applied Microbiology and Biotechnology.

[54]  Olivier Bernard,et al.  Validation of a simple model accounting for light and temperature effect on microalgal growth. , 2012, Bioresource technology.

[55]  F. G. Acién,et al.  Oxygen transfer and evolution in microalgal culture in open raceways. , 2013, Bioresource technology.

[56]  A.J.B. van Boxtel,et al.  Scenario analysis of large scale algae production in tubular photobioreactors , 2013 .

[57]  E. Molina Grima,et al.  Photobioreactors for the production of microalgae , 2013, Reviews in Environmental Science and Bio/Technology.