Numerical Techniques Applied to Hydraulic Turbines: A Perspective Review

Applications of computational fluid dynamic (CFD) techniques to hydropower have increased rapidly in the last three decades. The majority of the experimental investigations of hydraulic turbines were supported by numerical studies and this has become a standard practice. In the paper, applied numerical techniques and flow modeling approaches to simulate the hydraulic turbines are discussed. Both steady-state and transient operating conditions of the turbines are considered for the review. The steady-state conditions include the best efficiency point (BEP), high load (HL), and part load (PL). The transient conditions include load variation, startup, shutdown, and total load rejection. The performance of the applied numerical models and turbulence modeling with respect to the operating conditions are discussed. The recently developed numerical technique (transient blade row modeling) using the Fourier transformation (FT) method is discussed. This technique allows guide vane and blade passages to be modeled with the pitch ratio other than unity. Numerical modeling and simulation of hydraulic turbines during the transient operating conditions is one of the most challenging tasks because guide vanes' angular movement is time-dependent and mesh should be dynamic/moving. Different approaches applied to simulate the transient conditions and their limitations are discussed. Overall, this review summarizes the role of numerical techniques, advantages, limitations, and upcoming challenges within hydropower.

[1]  Bhupendra K. Gandhi,et al.  Effect of transients on Francis turbine runner life: a review , 2013 .

[2]  Rikard Gebart,et al.  Estimation of numerical accuracy for the flow field in a draft tube , 1999 .

[3]  Yongyao Luo,et al.  Investigation on fluid added mass effect in the modal response of a pump-turbine runner , 2013 .

[4]  Chirag Trivedi,et al.  Experimental investigations of transient pressure variations in a high head model Francis turbine during start-up and shutdown , 2014 .

[5]  Georgiana Dunca,et al.  Experimental vibration level analysis of a Francis turbine , 2012 .

[6]  Franz Nestmann,et al.  An optimization routine on a prediction and selection model for the turbine operation of centrifugal pumps , 2010 .

[7]  J Nicolle,et al.  Prediction of dynamic blade loading of the Francis-99 turbine , 2015 .

[8]  Bernd Nennemann,et al.  TWO-WAY FLUID-STRUCTURE COUPLING IN VIBRATION AND DAMPING ANALYSIS OF AN OSCILLATING HYDROFOIL , 2014 .

[9]  Santiago Laín,et al.  CFD Numerical simulations of Francis turbines , 2010 .

[10]  X. M. Wang,et al.  An Experimental Study on Fins, Their Role in Control of the Draft Tube Surging , 1996 .

[11]  Gabriel Dan Ciocan,et al.  Experimental analysis of the swirling flow in a Francis turbine draft tube: Focus on radial velocity component determination , 2010 .

[12]  Håkan Nilsson,et al.  INFLUENCE OF INLET BOUNDARY CONDITIONS IN THE PREDICTION OF ROTOR DYNAMIC FORCES AND MOMENTS FOR A HYDRAULIC TURBINE USING CFD , 2008 .

[13]  F. Avellan,et al.  Experimental Study and Numerical Simulation of the Flindt Draft Tube Rotating Vortex , 2007 .

[14]  M Eichhorn,et al.  Numerical investigation of a high head Francis turbine under steady operating conditions using foam-extend , 2015 .

[15]  Ole Gunnar Dahlhaug,et al.  Experimental and Numerical Studies for a High Head Francis Turbine at Several Operating Points , 2013 .

[16]  Håkan Nilsson,et al.  An Adaptive Turbulence Model for Swirling Flow , 2006 .

[17]  Guy Dumas,et al.  Numerical investigation of the flow behavior into a Francis runner during load rejection , 2014 .

[18]  O. Nilsson,et al.  Hydro unit start-up costs and their impact on the short term scheduling strategies of Swedish power producers , 1997 .

[19]  D Čelič,et al.  The influence of disc friction losses and labyrinth losses on efficiency of high head Francis turbine , 2015 .

[20]  C Deschênes,et al.  Inter-blade flow analysis of a propeller turbine runner using stereoscopic PIV , 2013 .

[21]  Hans-Jörg Huth,et al.  Fatigue Design of Hydraulic Turbine Runners , 2005 .

[22]  François Avellan,et al.  High-speed flow visualization in a pump-turbine under off-design operating conditions , 2010 .

[23]  S. Pejovic,et al.  Guidelines for transients are in need of revision , 2014 .

[24]  Kong Fanyu,et al.  Effects of Blade Wrap Angle Influencing a Pump as Turbine , 2012 .

[25]  Ole Gunnar Dahlhaug,et al.  Empirical modelling of sediment erosion in Francis turbines , 2012 .

[26]  François Avellan,et al.  Identification and Modeling of Pressure Fluctuations of a Francis Turbine Scale Model at Part Load Operation , 2004 .

[27]  M Melot,et al.  Draft tube pressure pulsation predictions in Francis turbines with transient Computational Fluid Dynamics methodology , 2014 .

[28]  Mirjam Sick,et al.  Thirty years of numerical flow simulation in hydraulic turbomachines , 2008 .

[29]  Bernd Nennemann,et al.  Challenges in Dynamic Pressure and Stress Predictions at No-Load Operation in Hydraulic Turbines , 2014 .

[30]  François Avellan,et al.  Werlé–Legendre Separation in a Hydraulic Machine Draft Tube , 2004 .

[31]  John M. Cimbala,et al.  Investigation of distributor vane jets to decrease the unsteady load on hydro turbine runner blades , 2012 .

[32]  F. Avellan,et al.  Experimental Evidence of Hydroacoustic Pressure Waves in a Francis Turbine Elbow Draft Tube for Low Discharge Conditions , 2009 .

[33]  P. K. Doerfler,et al.  A statistical method for draft tube pressure pulsation analysis , 2012 .

[34]  Guillaume Balarac,et al.  Large-eddy simulation of draft tube flow and validation from experimental measurements , 2009 .

[35]  T Aschenbrenner,et al.  Model test and CFD calculation of a cavitating bulb turbine , 2010 .

[36]  D. V. Platonov,et al.  Numerical modeling of flow in the Francis-99 turbine with Reynolds stress model and detached eddy simulation method , 2015 .

[37]  Shraman Goswami,et al.  Study of Steady State and Transient Blade Row CFD Methods in a Moderately Loaded NASA Transonic High-Speed Axial Compressor Stage , 2013 .

[38]  Christophe Devals,et al.  CFD methodology for desynchronized guide vane torque prediction and validation with experimental data , 2012 .

[39]  Ole Gunnar Dahlhaug,et al.  LDA measurements in the Francis-99 draft tube cone , 2014 .

[40]  P. Spalart,et al.  A hybrid RANS-LES approach with delayed-DES and wall-modelled LES capabilities , 2008 .

[41]  Mohamed Farhat,et al.  Pump-Turbine Rotor-Stator Interactions in Generating Mode: Pressure Fluctuation in Distributor Channel , 2006 .

[42]  Håkon Hjort Francke.  Increasing Hydro Turbine Operation Range and Efficiencies Using Water Injection in Draft Tubes , 2010 .

[43]  H. Foroutan,et al.  A partially-averaged Navier–Stokes model for the simulation of turbulent swirling flow with vortex breakdown , 2014 .

[44]  Johan Meyers,et al.  Quality and Reliability of Large-Eddy Simulations , 2008 .

[45]  Yoshinobu Tsujimoto,et al.  One-Dimensional Analysis of Full Load Draft Tube Surge , 2007 .

[46]  Robert Long Daugherty.  Hydraulic Turbines, with a Chapter on Centrifugal Pumps , 2007 .

[47]  Mitja Morgut,et al.  Numerical simulation of flow in a high head Francis turbine with prediction of efficiency, rotor stator interaction and vortex structures in the draft tube , 2015 .

[48]  Jay Doering,et al.  An improved model for predicting the efficiency of hydraulic propeller turbines , 2005 .

[49]  Lingjiu Zhou,et al.  Simulations and Measurements of Pressure Oscillations Caused by Vortex Ropes , 2006 .

[50]  C Deschênes,et al.  Experimental Investigation of Runner Outlet Flow in Axial Turbine with LDV and Stereoscopic PIV , 2008 .

[51]  Luca Mangani,et al.  Predicting the performance of a high head Francis turbine using a fully implicit mixing plane , 2015 .

[52]  Eduard Egusquiza,et al.  Dynamic Analysis of Francis Runners - Experiment and Numerical Simulation , 2009 .

[53]  Hermod Brekke.  Analysis of Losses in Hydraulic Turbines , 1996 .

[54]  P. Sagaut.  BOOK REVIEW: Large Eddy Simulation for Incompressible Flows. An Introduction , 2001 .

[55]  Mohammed Asid Zullah,et al.  CFD validation of performance improvement of a 500 kW Francis turbine , 2011 .

[56]  Robert C. Dean.  On the Necessity of Unsteady Flow in Fluid Machines , 1959 .

[57]  Alin Bosioc,et al.  Unsteady Pressure Analysis of a Swirling Flow With Vortex Rope and Axial Water Injection in a Discharge Cone , 2012 .

[58]  B. D. Marjavaara,et al.  Parallel CFD simulations of an original and redesigned hydraulic turbine draft tube , 2007, Adv. Eng. Softw..

[59]  E Flores,et al.  Design of large Francis turbine using optimal methods , 2012 .

[60]  L. He,et al.  Method of Simulating Unsteady Turbomachinery Flows with Multiple Perturbations , 1992 .

[61]  Wang Zhengwei,et al.  Experimental and numerical analysis of blade channel vortices in a Francis turbine runner , 2011 .

[62]  Michel Cervantes,et al.  Comparison of numerical and experimental results of the flow in the U9 Kaplan turbine model , 2010 .

[63]  Marcelo Vinicius Magnoli,et al.  Numerical simulation of pressure oscillations in large Francis turbines at partial and full load operating conditions and their effects on the runner structural behaviour and fatigue life , 2014 .

[64]  A A Fay.  Analysis of low-frequency pulsations in Francis turbines , 2010 .

[65]  Thong-See Lee,et al.  Air Influence on Similarity of Hydraulic Transients and Vibrations , 1996 .

[66]  Michel Cervantes.  Counter rotating runner cone in a Kaplan elbow draft tube for increased efficiency , 2009 .

[67]  X Q Luo,et al.  Investigation on pressure fluctuation in a Francis turbine with improvement measures , 2014 .

[68]  Dezhong Wang,et al.  Effects of water compressibility on the pressure fluctuation prediction in pump turbine , 2012 .

[69]  Li He,et al.  Fourier methods for turbomachinery applications , 2010 .

[70]  P K Dörfler,et al.  Francis full-load surge mechanism identified by unsteady 2-phase CFD , 2010 .

[71]  M J Cervantes,et al.  Turbine-99 unsteady simulations - Validation , 2010 .

[72]  U Seidel,et al.  Evaluation of RSI-induced stresses in Francis runners , 2012 .

[73]  François Guibault,et al.  Multi-fidelity design optimization of Francis turbine runner blades , 2014 .

[74]  Thor Bjørkvoll,et al.  CALCULATING THE START-UP COSTS OF HYDROPOWER GENERATORS , 2002 .

[75]  H. Foroutan,et al.  Flow in the Simplified Draft Tube of a Francis Turbine Operating at Partial Load—Part I: Simulation of the Vortex Rope , 2014 .

[76]  Peter Dörfler,et al.  Flow-Induced Pulsation and Vibration in Hydroelectric Machinery: Engineer’s Guidebook for Planning, Design and Troubleshooting , 2012 .

[77]  Z. Qian,et al.  Numerical Simulation and Analysis of Pressure Pulsation in Francis Hydraulic Turbine with Air Admission , 2007 .

[78]  François Avellan,et al.  Experimental Evidence of Rotating Stall in a Pump-Turbine at Off-Design Conditions in Generating Mode , 2011 .

[79]  Vlad Hasmatuchi,et al.  Hydrodynamics of a Pump-Turbine Operating at Off-Design Conditions in Generating Mode: Experimental Investigation , 2011 .

[80]  J. Erdos,et al.  Numerical Solution of Periodic Transonic Flow through a Fan Stage , 1977 .

[81]  Kaveh Amiri,et al.  An experimental investigation of flow in a Kaplan runner : steady-state and transient , 2014 .

[82]  Shengcai Li,et al.  Pressure Fluctuation Prediction of a Model Kaplan Turbine by Unsteady Turbulent Flow Simulation , 2009 .

[83]  Ole Gunnar Dahlhaug,et al.  Experimental investigations of a model Francis turbine during shutdown at synchronous speed , 2015 .

[84]  K. Shingai,et al.  Long-Period Pressure Pulsation Estimated in Numerical Simulations for Excessive Flow Rate Condition of Francis Turbine , 2014 .

[85]  Eduard Egusquiza,et al.  Cavitation Influence on von Kármán Vortex Shedding and Induced Hydrofoil Vibrations , 2007 .

[86]  Zhengwei Wang,et al.  Study on the Pressure Pulsation inside Runner with Splitter Blades in Ultra-High Head Turbine , 2014 .

[87]  Ole Gunnar Dahlhaug,et al.  Transient Pressure Measurements on a High Head Model Francis Turbine During Emergency Shutdown, Total Load Rejection, and Runaway , 2014 .

[88]  Anton Bergant,et al.  Simulation of unsteady flow and runner rotation during shut-down of an axial water turbine , 2006 .

[89]  Alexander Jung,et al.  Investigation of different simulation approaches on a high-head Francis turbine and comparison with model test data: Francis-99 , 2015 .

[90]  Berhanu Mulu,et al.  An experimental and numerical investigation of a Kaplan turbine model , 2012 .

[91]  Laith Zori,et al.  A Comparison of Advanced Numerical Techniques to Model Transient Flow in Turbomachinery Blade Rows , 2011 .

[92]  R. P. Saini,et al.  A review on silt erosion in hydro turbines , 2008 .

[93]  Alexander Jung,et al.  Evaluation of a Francis turbine draft tube flow at part load using hybrid RANS-LES turbulence modelling , 2012 .

[94]  Peter Dörfler,et al.  Errata to: Flow-Induced Pulsation and Vibration in Hydroelectric Machinery , 2013 .

[95]  Yasuyuki Enomoto,et al.  Design optimization method for Francis turbine , 2014 .

[96]  J D Buron,et al.  Application of the non-linear harmonic method to study the rotor-stator interaction in Francis-99 test case , 2015 .

[97]  Yakun Guo,et al.  Large-Eddy Simulation of Turbulent Flow Considering Inflow Wakes in a Francis Turbine Blade Passage , 2007 .

[98]  Joachim Raabe,et al.  Hydro power: The design, use, and function of hydromechanical, hydraulic, and electrical equipment , 1985 .

[99]  Jörg Osterwalder.  EFFICIENCY SCALE-UP FOR HYDRAULIC TURBO-MACHINES WITH DUE CONSIDERATION OF SURFACE ROUGHNESS , 1978 .

[100]  M Gagnon,et al.  Optimization of turbine startup: Some experimental results from a propeller runner , 2014 .

[101]  François Avellan,et al.  SURFACE ROUGHNESS IMPACT ON FRANCIS TURBINE PERFORMANCES AND PREDICTION OF EFFICIENCY STEP UP , 2008 .

[102]  H. Imamura,et al.  Effect of J-Groove on the Suppression of Swirl Flow in a Conical Diffuser , 2010 .

[103]  H Brekke.  Performance and safety of hydraulic turbines , 2010 .

[104]  Hossein Hosseinimanesh,et al.  A steady-state simulation methodology for predicting runaway speed in Francis turbines , 2014 .

[105]  Shuhong Liu,et al.  Cavitating Turbulent Flow Simulation in a Francis Turbine Based on Mixture Model , 2009 .

[106]  F. Hamba.  A hybrid RANS/LES simulation of high-Reynolds-number channel flow using additional filtering at the interface , 2006 .

[107]  J Nicolle,et al.  Transient CFD simulation of a Francis turbine startup , 2012 .

[108]  Xiao Ming,et al.  Numerical analysis of unsteady flow under high‐head operating conditions in Francis turbine , 2010 .

[109]  Rudolf Schilling,et al.  Optimization of Hydraulic Machinery Bladings by Multilevel CFD Techniques , 2005 .

[110]  Yongyao Luo,et al.  Vibration and fatigue caused by pressure pulsations originating in the vaneless space for a Kaplan turbine with high head , 2013 .

[111]  H Wallimann,et al.  Numerical Study of a High Head Francis Turbine with Measurements from the Francis-99 Project , 2015 .

[112]  Jean Eustache Prenat,et al.  Evaluation sur modèle réduit pour une prédiction de la stabilité de fonctionnemnt des turbines Francis , 1993 .

[113]  Kong Fanyu,et al.  Numerical Research on Effects of Splitter Blades to the Influence of Pump as Turbine , 2012 .

[114]  Ulrich Seidel,et al.  Dynamic loads in Francis runners and their impact on fatigue life , 2014 .

[115]  Feng-Chen Li,et al.  Large eddy simulation of pressure fluctuations at off-design condition in a Francis turbine based on cavitation model , 2013 .

[116]  Yuekun Sun,et al.  Pressure fluctuations in the vaneless space of High-head pump-turbines—A review , 2015 .

[117]  Kiyohito Tani,et al.  CFD-Based Design Optimization for Hydro Turbines , 2007 .

[118]  Ch. Hirsch,et al.  Unsteady Flow Modeling Across the Rotor/Stator Interface Using the Nonlinear Harmonic Method , 2006 .

[119]  Hua-Shu Dou,et al.  Vibration of Hydraulic Machinery , 2013 .

[120]  H L Bi,et al.  Numerical study of similarity in prototype and model pumped turbines , 2014 .

[121]  R Z Gong,et al.  Numerical simulation of pressure fluctuation in 1000MW Francis turbine under small opening condition , 2012 .

[122]  R. P. Saini,et al.  Study of cavitation in hydro turbines—A review , 2010 .

[123]  Håkan Nilsson,et al.  Steady and unsteady numerical simulations of the flow in the Tokke Francis turbine model, at three operating conditions , 2015 .

[124]  P Kerschberger,et al.  Hydraulic development of high specific-speed pump-turbines by means of an inverse design method, numerical flow-simulation (CFD) and model testing , 2010 .

[125]  Hua-Shu Dou,et al.  Numerical prediction and similarity study of pressure fluctuation in a prototype Kaplan turbine and the model turbine , 2012 .

[126]  François Avellan,et al.  Turbulence modeling for Francis turbine water passages simulation , 2010 .

[127]  Diana Maria Bucur,et al.  Simultaneous transient operation of a high head hydro power plant and a storage pumping station in the same hydraulic scheme , 2014 .

[128]  M Sick,et al.  Recent developments in the dynamic analysis of water turbines , 2009 .

[129]  J L Gordon.  Hydraulic turbine efficiency , 2001 .

[130]  Zhang Jin,et al.  Experimental and numerical analysis of pressure pulses characteristics in a Francis turbine with partial load , 2010 .

[131]  Yasuyuki Enomoto,et al.  Design optimization of a high specific speed Francis turbine runner , 2012 .

[132]  Fotis Sotiropoulos,et al.  Numerical Simulation of Swirling Flow in Complex Hydroturbine Draft Tube Using Unsteady Statistical Turbulence Models , 2005 .

[133]  Øyvind Antonsen,et al.  Unsteady flow in wicket gate and runner with focus on static and dynamic load on runner , 2007 .

[134]  M V Magnoli,et al.  Influence of Hydraulic Design on Stability and on Pressure Pulsations in Francis Turbines at Overload, Part Load and Deep Part Load based on Numerical Simulations and Experimental Model Test Results , 2014 .

[135]  Chirag Trivedi.  Investigations of Transient Pressure Loading on a High Head Francis Turbine , 2015 .

[136]  Laith Zori,et al.  Investigation of Transient CFD Methods Applied to a Transonic Compressor Stage , 2011 .

[137]  J Nicolle,et al.  CFD configurations for hydraulic turbine startup , 2014 .

[138]  Bryan W. Karney,et al.  A selected literature review of efficiency improvements in hydraulic turbines , 2015 .

[139]  Philippe Godin,et al.  Unsteady CFD Methods in a Commercial Solver for Turbomachinery Applications , 2010 .

[140]  Hua-Shu Dou,et al.  Turbulent flow computation through a model Francis turbine and its performance prediction , 2010 .