Combustion of waste trap grease oil in gas turbine generator

Abstract The possibility of using waste trap grease in electric power generation is explored in this study. The performance and emissions of both diesel and waste trap grease oils were tested in a gas turbine generator at comparable operating conditions. The fuel system of the gas turbine was modified for dual fuel capability with a diversion valve and a heat exchanger with exhaust for elevating the temperature of trap grease. The viscosity of trap grease was measured as a function of temperature and it was determined that the trap grease oil should be heated up to nearly 80 °C in order to approach the viscosity of diesel fuel such that satisfactory injector atomization can be achieved. The heating values of the diesel and trap grease were measured using an oxygen bomb calorimeter to facilitate the calculations of engine performance on an energy input basis. The results showed that the trap grease exhibits less NO x emission for high generator loads compared to diesel, whereas CO and CO 2 emissions are slightly to significantly higher than those of diesel as load decreases. The results of the performance and emissions testing indicate that trap grease can be satisfactorily used for power generation.

[1]  David Chiaramonti,et al.  Power generation using fast pyrolysis liquids from biomass , 2007 .

[2]  R. Howard-Hildige,et al.  The effect of steam treating waste cooking oil on the yield of methyl ester , 2002 .

[3]  T. Nussbaumer.  Combustion and Co-combustion of Biomass: Fundamentals, Technologies, and Primary Measures for Emission Reduction† , 2003 .

[4]  Zhen Huang,et al.  Experimental Study on the Combustion Characteristics and Emissions of Biodiesel Fueled Compression Ignition Engines with Premixed Dimethoxymethane , 2007 .

[5]  Alan Shihadeh,et al.  Diesel Engine Combustion of Biomass Pyrolysis Oils , 2000 .

[6]  C. Ejim,et al.  Analytical study for atomization of biodiesels and their blends in a typical injector: Surface tension and viscosity effects , 2007 .

[7]  S. Fernando,et al.  NOx Reduction from Biodiesel Fuels , 2006 .

[8]  M. P. Dorado,et al.  Testing Waste Olive Oil Methyl Ester as a Fuel in a Diesel Engine , 2003 .

[9]  Lilian L. N. Guarieiro,et al.  The Role of Additives for Diesel and Diesel Blended (Ethanol or Biodiesel) Fuels: A Review , 2007 .

[10]  A. Bridgwater,et al.  Overview of Applications of Biomass Fast Pyrolysis Oil , 2004 .

[11]  M. G. Kulkarni,et al.  WASTE COOKING OIL – AN ECONOMICAL SOURCE FOR BIODIESEL: A REVIEW , 2006 .

[12]  Filiz Karaosmanoglu,et al.  A New Application Area for Used Cooking Oil Originated Biodiesel: Generators , 2005 .

[13]  Anja Oasmaa,et al.  Fuel oil quality of biomass pyrolysis oils-state of the art for the end users , 1999 .

[14]  Chunde Yao,et al.  Emissions Characteristics of a Diesel Engine Fueled with Biodiesel and Fumigation Methanol , 2008 .

[15]  Nicholas A. Zafiropoulos,et al.  Efficient Two-Step Synthesis of Biodiesel from Greases† , 2008 .

[16]  N. Clark,et al.  Emissions from nine heavy trucks fueled by diesel and biodiesel blend without engine modification , 2000 .

[17]  Manuel Garcia-Perez,et al.  Production and fuel properties of pine chip bio-oil/biodiesel blends , 2007 .

[18]  Michael P. Harold,et al.  Combining Biodiesel and Exhaust Gas Recirculation for Reduction in NOx and Particulate Emissions , 2008 .

[19]  S. Voutetakis,et al.  Hydrogen Production via Steam Reforming of the Aqueous Phase of Bio-Oil in a Fixed Bed Reactor , 2006 .