Experimental study of a humidification-dehumidification solar technique by natural and forced air circulation

An experimental investigation of a desalination system based on the HDH (humidification and dehumidification) of air is studied. The experiments were carried out in the premises of an open roof (six floors) of a Faculty of Engineering, Kafrelsheikh University, Egypt which lies at latitude 31.07°N and longitude 30.57°E.The evaporator (humidifier) unit is based on a cellulose paper as packing materials substratum through which water flows, and has a large area of favor evaporation. Cellulose papers with different wet surface area are used and studied. A modified design of condenser (dehumidifier) is proposed in HDH process to evaluate the performance of the unit. The condenser unit is a liquid–gas heat exchanger, where water vapor is condensed. The working principle of the set-up is based on the idea of open-water and closed-air cycles. An evacuated solar water heater is integrated with the desalination unit. The air is circulated either by natural or forced circulation. The effect of three types of forced circulating air (up, down and up-down) on the unit performance is considered. Also, the influence of inlet water temperature and inlet water mass flow rate to the humidifier on the performance HDH unit is studied. In addition the optimal ratio of cold water at condenser inlet to hot water at evaporator inlet (C/H) is obtained. The results show that the maximum productivity is obtained when C/H is twice. Also it is found that forced down air circulation gives higher performance than that obtained for forced up, forced up-down and natural air circulation. At C/H = 2, inlet water mass flow rate to the humidifier is 4 kg/min and forced down air circulation the unit productivity is about 23.6 kg/h with water temperature 90 °C at humidifier inlet. Results of the proposed design are compared with that for conventional type and the comparison shows that the propped design gives a higher performance. Hence, the modified condenser design increases the condenser effectiveness to be about 0.71 while, for conventional type of 0.49.

[1]  Hisham Ettouney,et al.  Low temperature humidification dehumidification desalination process , 2006 .

[2]  Lin Lu,et al.  Thermal performance of an open thermosyphon using nanofluids for high-temperature evacuated tubular solar collectors: Part 1: Indoor experiment , 2011 .

[3]  E. H. Amer,et al.  Theoretical and experimental investigation of humidification–dehumidification desalination unit , 2009 .

[4]  S. J. Kline,et al.  Describing Uncertainties in Single-Sample Experiments , 1953 .

[5]  Mohammed M. Farid,et al.  Solar desalination with a humidification-dehumidification cycle: performance of the unit , 1998 .

[6]  A. E. Kabeel,et al.  Water Desalination Using a Humidification-Dehumidification Technique—A Detailed Review , 2013 .

[7]  Fawzi Banat,et al.  Solar thermal desalination technologies , 2008 .

[8]  John H. Lienhard,et al.  The potential of solar-driven humidification–dehumidification desalination for small-scale decentralized water production , 2009 .

[9]  Camilo A. Arancibia-Bulnes,et al.  Water desalination by air humidification: Mathematical model and experimental study , 2012 .

[10]  Hassan E.S. Fath,et al.  Solar desalination using humidification dehumidification processes. Part I. A numerical investigation , 2004 .

[11]  Yong Chan Kim,et al.  Heat transfer characteristics of flat plate finned-tube heat exchangers with large fin pitch , 2005 .

[12]  H. Ben Bacha,et al.  Modeling and experimental validation of a humidification–dehumidification desalination unit solar part , 2011 .

[13]  Gongnan Xie,et al.  Parametric study and multiple correlations on air-side heat transfer and friction characteristics of fin-and-tube heat exchangers with large number of large-diameter tube rows , 2009 .

[14]  Yang Deng,et al.  Solar power-driven humidification–dehumidification (HDH) process for desalination of brackish water , 2012 .

[15]  Mohammed M. Farid,et al.  Solar desalination based on humidification process—II. Computer simulation , 1999 .

[16]  Mehmet Esen.  Thermal performance of a solar cooker integrated vacuum-tube collector with heat pipes containing different refrigerants , 2004 .

[17]  Matheus Poletto,et al.  Structural Characteristics and Thermal Properties of Native Cellulose , 2013 .

[18]  Simon Song,et al.  Fin spacing optimization of a fin-tube heat exchanger under frosting conditions , 2006 .

[19]  Amin Behzadmehr,et al.  Analysis of a solar desalination unit with humidification–dehumidification cycle using DoE method , 2011 .

[20]  Mehmet Esen,et al.  Experimental investigation of a two-phase closed thermosyphon solar water heater , 2005 .

[21]  S. A. El-Agouz,et al.  A new process of desalination by air passing through seawater based on humidification–dehumidification process , 2010 .

[22]  Majid Amidpour,et al.  Experimental validation of an optimized solar humidification-dehumidification desalination unit , 2009 .

[23]  J. R. Selman,et al.  Solar desalination with a humidification-dehumidification cycle: mathematical modeling of the unit , 2003 .

[24]  M. A. Darwish,et al.  Experimental and theoretical study of a humidification-dehumidification desalting system , 1993 .

[25]  A. El-sebaii,et al.  Effect of selective coating on thermal performance of flat plate solar air heaters , 2010 .

[26]  Guofeng Yuan,et al.  Mathematical modeling of a closed circulation solar desalination unit with humidification-dehumidification , 2007 .