Mechanism of Li2S formation and dissolution in Lithium-Sulphur batteries

Insufficient understanding of the mechanism that reversibly converts sulphur into lithium sulphide (Li2S) via soluble polysulphides (PS) hampers the realization of high performance lithium-sulphur cells. Typically Li2S formation is explained by direct electroreduction of a PS to Li2S; however, this is not consistent with the size of the insulating Li2S deposits. Here, we use in situ small and wide angle X-ray scattering (SAXS/WAXS) to track the growth and dissolution of crystalline and amorphous deposits from atomic to sub-micron scales during charge and discharge. Stochastic modelling based on the SAXS data allows quantification of the chemical phase evolution during discharge and charge. We show that Li2S deposits predominantly via disproportionation of transient, solid Li2S2 to form primary Li2S crystallites and solid Li2S4 particles. We further demonstrate that this process happens in reverse during charge. These findings show that the discharge capacity and rate capability in Li-S battery cathodes are therefore limited by mass transport through the increasingly tortuous network of Li2S / Li2S4 / carbon pores rather than electron transport through a passivating surface film.

[1]  H. Amenitsch,et al.  In situ small-angle X-ray scattering reveals solution phase discharge of Li–O2 batteries with weakly solvating electrolytes , 2020, Proceedings of the National Academy of Sciences.

[2]  Tongchao Liu,et al.  Activating Li2S as the Lithium-Containing Cathode in Lithium–Sulfur Batteries , 2020 .

[3]  V. Presser,et al.  Persistent and reversible solid iodine electrodeposition in nanoporous carbons , 2020, Nature Communications.

[4]  V. Presser,et al.  Comparing pore structure models of nanoporous carbons obtained from small angle X-ray scattering and gas adsorption , 2019, Carbon.

[5]  R. Dominko,et al.  Which Process Limits the Operation of a Li–S System? , 2019, Chemistry of Materials.

[6]  Hong‐Jie Peng,et al.  Current-density dependence of Li2S/Li2S2 growth in lithium–sulfur batteries , 2019, Energy & Environmental Science.

[7]  Yi Cui,et al.  Elaboration of Aggregated Polysulfide Phases: from Molecules to Large Clusters and Solid Phases. , 2019, Nano letters.

[8]  S. Risse,et al.  Operando Analysis of a Lithium/Sulfur Battery by Small Angle Neutron Scattering. , 2019, ACS nano.

[9]  T. Zhao,et al.  Critical Role of Anion Donicity in Li2S Deposition and Sulfur Utilization in Li-S Batteries. , 2019, ACS applied materials & interfaces.

[10]  YunKyoung Kim,et al.  Achieving three-dimensional lithium sulfide growth in lithium-sulfur batteries using high-donor-number anions , 2019, Nature Communications.

[11]  K. Virwani,et al.  Ion Pairing Limits Crystal Growth in Metal–Oxygen Batteries , 2018, ACS Energy Letters.

[12]  Cédric Gommes,et al.  Stochastic models of disordered mesoporous materials for small-angle scattering analysis and more , 2018 .

[13]  Kathleen A. Schwarz,et al.  Direct visualization of sulfur cathodes: new insights into Li-S batteries via operando X-ray based methods. , 2018, Energy & environmental science.

[14]  M. Marinescu,et al.  What Limits the Rate Capability of Li-S Batteries during Discharge: Charge Transfer or Mass Transfer? , 2018 .

[15]  M. Fichtner,et al.  Polysulfides Formation in Different Electrolytes from the Perspective of X-ray Absorption Spectroscopy , 2018 .

[16]  P. Johansson,et al.  Fluorinated Ether Based Electrolyte for High-Energy Lithium–Sulfur Batteries: Li+ Solvation Role Behind Reduced Polysulfide Solubility , 2017 .

[17]  V. Presser,et al.  A carbon nanopore model to quantify structure and kinetics of ion electrosorption with in situ small-angle X-ray scattering. , 2017, Physical chemistry chemical physics : PCCP.

[18]  M. Di Michiel,et al.  Multiscale characterization of a lithium/sulfur battery by coupling operando X-ray tomography and spatially-resolved diffraction , 2017, Scientific Reports.

[19]  C. Villevieille,et al.  Direct observation of lithium polysulfides in lithium–sulfur batteries using operando X-ray diffraction , 2017, Nature Energy.

[20]  V. Presser,et al.  Quantification of ion confinement and desolvation in nanoporous carbon supercapacitors with modelling and in situ X-ray scattering , 2017, Nature Energy.

[21]  Yu‐Guo Guo,et al.  Insight into the Interfacial Process and Mechanism in Lithium-Sulfur Batteries: An In Situ AFM Study. , 2016, Angewandte Chemie.

[22]  M. Marinescu,et al.  Modelling transport-limited discharge capacity of lithium-sulfur cells , 2016 .

[23]  Linda F. Nazar,et al.  Advances in lithium–sulfur batteries based on multifunctional cathodes and electrolytes , 2016, Nature Energy.

[24]  M. Armand,et al.  Transient existence of crystalline lithium disulfide Li2S2 in a lithium-sulfur battery , 2016 .

[25]  M. Armand,et al.  In operando scanning electron microscopy and ultraviolet–visible spectroscopy studies of lithium/sulfur cells using all solid-state polymer electrolyte , 2016 .

[26]  M. Oschatz,et al.  Carbon Materials for Lithium Sulfur Batteries-Ten Critical Questions. , 2016, Chemistry.

[27]  Doron Aurbach,et al.  Promise and reality of post-lithium-ion batteries with high energy densities , 2016 .

[28]  Lilin He,et al.  SANS investigations of CO2 adsorption in microporous carbon , 2015 .

[29]  Mark Wild,et al.  Lithium sulfur batteries, a mechanistic review , 2015 .

[30]  Pouya Partovi-Azar,et al.  Evidence for the existence of Li2S2 clusters in lithium-sulfur batteries: ab initio Raman spectroscopy simulation. , 2015, Physical chemistry chemical physics : PCCP.

[31]  Petr Novák,et al.  Progress Towards Commercially Viable Li–S Battery Cells , 2015 .

[32]  Jun Lu,et al.  Progress in Mechanistic Understanding and Characterization Techniques of Li‐S Batteries , 2015 .

[33]  Nguyen T. K. Thanh,et al.  Mechanisms of nucleation and growth of nanoparticles in solution. , 2014, Chemical reviews.

[34]  T. Narayanan.  Small‐Angle Scattering , 2014 .

[35]  Lennart Bergström,et al.  Pre-nucleation clusters as solute precursors in crystallisation. , 2014, Chemical Society reviews.

[36]  H. Gasteiger,et al.  Probing the Lithium−Sulfur Redox Reactions: A Rotating-Ring Disk Electrode Study , 2014 .

[37]  J. Cabana,et al.  Fingerprinting Lithium-Sulfur Battery Reaction Products by X-ray Absorption Spectroscopy , 2014 .

[38]  Bruno Scrosati,et al.  Recent progress and remaining challenges in sulfur-based lithium secondary batteries--a review. , 2013, Chemical communications.

[39]  Robert Dominko,et al.  Li-S battery analyzed by UV/Vis in operando mode. , 2013, ChemSusChem.

[40]  Sébastien Patoux,et al.  Lithium/sulfur cell discharge mechanism: an original approach for intermediate species identification. , 2012, Analytical chemistry.

[41]  C. Gommes,et al.  Structure development of resorcinol-formaldehyde gels: microphase separation or colloid aggregation. , 2008, Physical review. E, Statistical, nonlinear, and soft matter physics.

[42]  H. Amenitsch,et al.  First performance assessment of the small-angle X-ray scattering beamline at ELETTRA. , 1998, Journal of synchrotron radiation.

[43]  A. Roberts.  Statistical reconstruction of three-dimensional porous media from two-dimensional images , 1997, cond-mat/9902023.

[44]  Berk Nf,et al.  Scattering properties of the leveled-wave model of random morphologies. , 1991 .

[45]  Berk.  Scattering properties of the leveled-wave model of random morphologies. , 1991, Physical review. A, Atomic, molecular, and optical physics.

[46]  O. Glatter,et al.  19 – Small-Angle X-ray Scattering , 1973 .

[47]  G. Squires.  Neutron Scattering , 1970, Nature.

[48]  W. Ehrenberg,et al.  Small-Angle X-Ray Scattering , 1952, Nature.