Plasma-assisted catalysis for volatile organic compounds abatement

A dielectric barrier discharge (DBD) combined with Mn-based phosphate catalysts placed downstream of the plasma reactor was investigated experimentally for total oxidation of toluene in air. The discharge was initiated by high voltage pulses of 18 kV amplitude and 1213 ns rise time. The pulse frequency increased from 14 to 80 Hz, for applied voltages in the range 18-28 kV. Discharge currents up to 100 A and approximately 50 ns duration were obtained. No other hydrocarbons except toluene were detected in the effluent gas. The yield of carbon dioxide formed in the discharge was up to 24%. As catalysts, MnPO4, Mn-APO-5 and Mn-SAPO-11 were tested, for temperatures up to 400 degrees C. Under purely catalytic conditions, the best behavior for toluene total oxidation was found for Mn-SAPO-11, with a CO2 yield up to 33%, at 400 degrees C. The combined application of plasma and catalysis showed a remarkable synergetic effect, even at low temperature, up to 100 degrees C, where the catalysts alone are not active. In this range, the CO2 yield increased up to 41%, for the Mn-SAPO catalyst. At 400 degrees C the highest CO2 yield was obtained for MnPO4, reaching 68%. The synergetic effect observed for the plasma-catalyst combination is attributed to ozone radicals formed in the discharge, which decompose on the catalyst surface, greatly contributing to toluene total oxidation. (c) 2005 Elsevier B.V. All rights reserved.

[1]  M. Hartmann,et al.  Transition-metal ions in aluminophosphate and silicoaluminophosphate molecular sieves: location, interaction with adsorbates and catalytic properties. , 1999, Chemical reviews.

[2]  K. Francke,et al.  Cleaning of Air Streams from Organic Pollutants by Plasma–Catalytic Oxidation , 2000 .

[3]  N. Hayashi,et al.  Treatment of Volatile Organic Compound by Positive Streamer Corona Using a Series Gap , 2001 .

[4]  M. Šimek,et al.  Time and space resolved analysis of N 2 (C 3 Π u ) vibrational distributions in pulsed positive corona discharge , 2002 .

[5]  P. T. Crisp,et al.  Application of X-ray photoelectron spectroscopy to the analysis of stainless-steel welding aerosols , 1985 .

[6]  V. Veldhuizen,et al.  Pulsed positive corona streamer propagation and branching , 2002 .

[7]  R. Bandyopadhyay,et al.  Catalytic performance of silicoaluminophosphate (SAPO) molecular sieves in the isopropylation of biphenyl , 2002 .

[8]  R. Rudolph,et al.  Concentration Dependence of VOC Decomposition by Dielectric Barrier Discharges , 2002 .

[9]  M. Labaki,et al.  Total oxidation of propene and toluene in the presence of zirconia doped by copper and yttrium , 2003 .

[10]  Toshikazu Ohkubo,et al.  Decomposition of toluene by streamer corona discharge with catalyst , 2002 .

[11]  W. H. Baur,et al.  Group behaviour of SAPO-11 molecular sieves containing various metals (Mg, Zn, Mn or Cd, Ni, Cr) , 1994 .

[12]  G. Busca,et al.  A study of anatase-supported Mn oxide as catalysts for 2-propanol oxidation , 1999 .

[13]  Wflm Wilfred Hoeben,et al.  Pulsed corona-induced degradation of organic materials in water , 2000 .

[14]  Shigeru Futamura,et al.  Performance evaluation of a hybrid system comprising silent discharge plasma and manganese oxide catalysts for benzene decomposition , 2001 .

[15]  Shigeru Futamura,et al.  Involvement of catalyst materials in nonthermal plasma chemical processing of hazardous air pollutants , 2002 .

[16]  Frank Holzer,et al.  Improved oxidation of air pollutants in a non-thermal plasma , 2002 .

[17]  Ulrich Kogelschatz,et al.  Nonequilibrium volume plasma chemical processing , 1991 .

[18]  S. Ciampi,et al.  XPS study of the growth and reactivity of Fe/MnO thin films , 1995 .

[19]  K. Klabunde,et al.  XPS studies of solvated metal atom dispersed (SMAD) catalysts. Evidence for layered cobalt-manganese particles on alumina and silica , 1991 .

[20]  J. O. Chae,et al.  Toluene and butyl acetate removal from air by plasma-catalytic system , 2003 .

[21]  B. Eliasson,et al.  Modeling and applications of silent discharge plasmas , 1991 .

[22]  H. Franzen,et al.  XPS spectra of some transition metal and alkaline earth monochalcogenides , 1976 .

[23]  D. Goldfarb,et al.  ESR and electron spin-echo studies of MnAlPO5 , 1991 .

[24]  Tetsuji Oda,et al.  Non-thermal plasma processing for environmental protection: decomposition of dilute VOCs in air , 2003 .

[25]  S. Kaliaguine,et al.  New evidences for the fluoride contribution in synthesis of gallium phosphates , 2002 .

[26]  D. Goldfarb.  MAS n.m.r. and e.s.r. studies of MnAlPO5 , 1989 .

[27]  S. Harris,et al.  A study of a number of mixed transition metal oxide spinels using X-ray photoelectron spectroscopy , 1989 .

[28]  B. Langlais,et al.  Guideline for Measurement of Ozone Concentration in the Process Gas From an Ozone Generator , 1996 .

[29]  G. Busca,et al.  Catalytic combustion of C3 hydrocarbons and oxygenates over Mn3O4 , 1998 .

[30]  F. Tochikubo,et al.  Optical Emission from a Pulsed Corona Discharge and Its Associated Reactions , 2000 .

[31]  G. J. McCarthy,et al.  JCPDS-International Centre for Diffraction Data , 1981 .

[32]  M. A. Zanjanchi,et al.  Structural charge transfer in the aluminophosphate molecular sieves by diffuse reflectance spectroscopy , 1999 .