Heat transfer enhancement of nanofluids flow in microtube with constant heat flux

Abstract In this paper, laminar convective heat transfer in a two-dimensional microtube (MT) with 50 μm diameter and 250 μm length with constant heat flux is numerically investigated. The governing (continuity, momentum and energy) equations were solved using the finite volume method (FVM) with the aid of SIMPLE algorithm. Different types of nanofluids Al2O3, CuO, SiO2 and ZnO, with different nanoparticle size 25, 45, 65 and 80 nm, and different volume fractions ranged from 1% to 4% using ethylene glycol as a base fluid were used. This investigation covers Reynolds number in the range of 10 to 1500. The results have shown that SiO2–EG nanofluid has the highest Nusselt number, followed by ZnO–EG, CuO–EG, Al2O3–EG, and lastly pure EG. The Nusselt number for all cases increases with the volume fraction but it decreases with the rise in the diameter of nanoparticles. In all configurations, the Nusselt number increases with Reynolds number.

[1]  J. Koo,et al.  Viscous dissipation effects in microtubes and microchannels , 2004 .

[2]  Y. Wang,et al.  Influence of three-dimensional wall roughness on the laminar flow in microtube , 2007 .

[3]  Haisheng Chen,et al.  Predicting thermal conductivity of liquid suspensions of nanoparticles (nanofluids) based on rheology , 2009 .

[4]  Peng Zhang,et al.  Two-phase flow characteristics of liquid nitrogen in vertically upward 0.5 and 1.0 mm micro-tubes: Visualization studies ☆ , 2009 .

[5]  S. McPhail,et al.  Experimental study on compressible flow in microtubes , 2007 .

[6]  Dongqing Li,et al.  Flow characteristics of water in microtubes , 1999 .

[7]  Chien-Yuh Yang,et al.  Heat transfer characteristics of water flow in microtubes , 2007 .

[8]  S. Kakaç,et al.  Enhanced thermal conductivity of nanofluids: a state-of-the-art review , 2010 .

[9]  Jl L. Xu,et al.  Flow and heat transfer in microchannels with rough wall surface , 2006 .

[10]  Zhipeng Guo,et al.  Compressibility effect on the gas flow and heat transfer in a microtube , 1997 .

[11]  M. Corcione.  Heat transfer features of buoyancy-driven nanofluids inside rectangular enclosures differentially heated at the sidewalls , 2010 .

[12]  O. N. Şara,et al.  Experimental study of laminar forced convective mass transfer and pressure drop in microtubes , 2009 .

[13]  Rahman Saidur,et al.  Heat transfer and fluid flow characteristics in microchannels heat exchanger using nanofluids: A review , 2011 .

[14]  A. Cioabla,et al.  The viscous dissipation effect on heat transfer and fluid flow in micro-tubes , 2010 .

[15]  Yulong Ding,et al.  Experimental investigation into convective heat transfer of nanofluids at the entrance region under laminar flow conditions , 2004 .

[16]  F. He,et al.  Transitional and turbulent flow in a circular microtube , 2007 .

[17]  G. Croce,et al.  Numerical analysis of roughness effect on microtube heat transfer , 2004 .

[18]  A. Satapathy.  Slip flow heat transfer in an infinite microtube with axial conduction , 2010 .

[19]  W. Tao,et al.  Experimental and numerical studies of liquid flow and heat transfer in microtubes , 2007 .

[20]  M. Takei,et al.  Experimental study on forced convective heat transfer characteristics in quartz microtube , 2007 .

[21]  D. Das,et al.  Experimental determination of thermal conductivity of three nanofluids and development of new correlations , 2009 .

[22]  Rahman Saidur,et al.  Convective heat transfer and fluid flow study over a step using nanofluids: A review , 2011 .

[23]  A. Aziz,et al.  Thermally developing microtube gas flow with axial conduction and viscous dissipation , 2011 .

[24]  D. Lelea.  Effects of temperature dependent thermal conductivity on Nu number behavior in micro-tubes , 2010 .

[25]  Heat transfer characteristics of gaseous flows in microtube with constant heat flux , 2008 .

[26]  W. Tao,et al.  Numerical studies of simultaneously developing laminar flow and heat transfer in microtubes with thick wall and constant outside wall temperature , 2010 .

[27]  Yanhui Yuan,et al.  The effect of particle size on the thermal conductivity of alumina nanofluids , 2009 .

[28]  T. Ameel,et al.  Microtube Gas Flows With Second-Order Slip Flow and Temperature Jump Boundary Conditions , 2009 .

[29]  Ruzhu Wang,et al.  Flow boiling of liquid nitrogen in micro-tubes: Part II – Heat transfer characteristics and critical heat flux , 2007 .

[30]  Gian Piero Celata,et al.  Microtube liquid single-phase heat transfer in laminar flow , 2006 .

[31]  L. Xu,et al.  Flow boiling of liquid nitrogen in micro-tubes: Part I – The onset of nucleate boiling, two-phase flow instability and two-phase flow pressure drop , 2007 .

[32]  Saiied M. Aminossadati,et al.  Brownian motion of nanoparticles in a triangular enclosure with natural convection , 2010 .

[33]  Wenhua Yu,et al.  Review and Comparison of Nanofluid Thermal Conductivity and Heat Transfer Enhancements , 2008 .