Numerical study of natural convection loss from open cavities

Abstract In this paper, the natural convection occurring from open cavities is analysed. Three different cavity shapes are studied namely cubical, spherical and hemispherical geometries having equal heat transfer area. The numerical analysis is performed on three dimensional (3-D) cavity models using the Fluent CFD software. The studies are performed for cavities having isothermal wall temperatures of 100 °C, 200 °C and 300 °C. The effect of opening ratios ( d / D or a / H ) of 1, 0.5 and 0.25 on the convective loss is studied for the cubical and hemispherical cavity shapes while the spherical cavity is analysed for opening ratios of 0.5 and 0.25. The effect of inclination of the cavity on the natural convection is studied for five inclinations; 0° (aperture facing sideways), 30°, 45°, 60° and 90° (aperture facing vertically downwards). The natural convection loss is found to increase with an increase in opening ratio. The increase in natural convection loss for different inclinations is found to vary between 30% and 80% when the opening ratio is increased from 0.25 to 0.5 for all cavity shapes. A similar increase in natural convection loss is observed when the opening ratio is increased from 0.5 to 1 for the cubical and hemispherical cavities. The natural convection loss increases with increase in cavity wall temperature. A decrease in loss is observed with increase in cavity inclination; the highest convective loss being at 0° inclination and the lowest at 90°. For all the cavity shapes analysed with opening ratios of 0.5 and 0.25, it is observed that the hemispherical open cavity has the highest natural convection loss when compared to cubical and spherical cavities. The hemispherical cavity has higher convective loss than the cubical cavity for an opening ratio of 1. A Nusselt number correlation involving the effect of cavity shape, Rayleigh number, inclination angle and the opening ratio has been developed from this study.

[1]  Walid Chakroun.  Effect of Boundary Wall Conditions on Heat Transfer for Fully Opened Tilted Cavity , 2004 .

[2]  Sendhil Kumar Natarajan,et al.  Numerical investigation of natural convection heat loss in modified cavity receiver for fuzzy focal solar dish concentrator , 2007 .

[3]  C. F. Hess,et al.  Experimental Investigation of Natural Convection Losses From Open Cavities , 1984 .

[4]  Frans T. M. Nieuwstadt,et al.  Numerical study of transient and steady laminar buoyancy-driven flows and heat transfer in a square open cavity , 1992 .

[5]  D. Gray,et al.  The validity of the boussinesq approximation for liquids and gases , 1976 .

[6]  Patrick Le Quere,et al.  NUMERICAL CALCULATION OF THERMALLY DRIVEN TWO-DIMENSIONAL UNSTEADY LAMINAR FLOW IN CAVITIES OF RECTANGULAR CROSS SECTION , 1981 .

[7]  T. Newell,et al.  Localized Heat Transfer in Buoyancy Driven Convection in Open Cavities , 2007 .

[8]  F. Penot,et al.  NUMERICAL CALCULATION OF TWO-DIMENSIONAL NATURAL CONVECTION IN ISOTHERMAL OPEN CAVITIES , 1982 .

[9]  C. G. McDonald.  Heat loss from an open cavity , 1995 .

[10]  Shireesh B. Kedare,et al.  Investigations on heat losses from a solar cavity receiver , 2009 .

[11]  E. Bilgen,et al.  Conjugate heat transfer in inclined open shallow cavities , 2003 .

[12]  F. S. Sherman,et al.  Free and mixed convective flow of air in a heated cavity of variable rectangular cross section and orientation , 1985, Philosophical Transactions of the Royal Society of London. Series A, Mathematical and Physical Sciences.

[13]  C. Tien,et al.  a Numerical Study of Two-Dimensional Natural Convection in Square Open Cavities , 1985 .

[14]  Shireesh B. Kedare,et al.  Determination of stagnation and convective zones in a solar cavity receiver , 2010 .

[15]  R. Shah,et al.  Handbook of single-phase convective heat transfer , 1987 .

[16]  Sawat Paitoonsurikarn,et al.  A New Correlation for Predicting the Free Convection Loss from Solar Dish Concentrating Receivers , 2006 .

[17]  C. L. Tien,et al.  A numerical study of two-dimensional laminar natural convection in shallow open cavities , 1985 .

[18]  C. L. Tien,et al.  Laminar Natural Convection in Shallow Open Cavities , 1986 .

[19]  Walid Chakroun,et al.  Experimental Measurements of Heat Transfer Coefficient in a Partially/Fully Opened Tilted Cavity , 1997 .

[20]  Sendhil Kumar Natarajan,et al.  Combined laminar natural convection and surface radiation heat transfer in a modified cavity receiver of solar parabolic dish , 2008 .

[21]  A. M. Clausing,et al.  Natural Convection From Isothermal Cubical Cavities With a Variety of Side-Facing Apertures , 1987 .

[22]  U. Leibfried,et al.  Convective Heat Loss from Upward and Downward-Facing Cavity Solar Receivers: Measurements and Calculations , 1995 .

[23]  L. L. Eyler.  Predictions of convective losses from a solar cavity receiver , 1979 .

[25]  C. P. Kothandaraman,et al.  Heat and mass transfer data book , 1977 .

[26]  Sawat Paitoonsurikarn,et al.  Experimental Investigation of Natural Convection Heat Loss From a Model Solar Concentrator Cavity Receiver , 2004 .

[27]  Richard J Goldstein,et al.  TWO-DIMENSIONAL LAMINAR NATURAL CONVECTION HEAT TRANSFER FROM A FULLY OR PARTIALLY OPEN SQUARE CAVITY , 1989 .

[28]  A. M. Clausing,et al.  Convective losses from cavity solar receivers--Comparisons between analytical predictions and experimental results , 1983 .

[29]  G. Cortella,et al.  Natural Convection In Rectangular Open Cavities , 1970 .

[30]  Sendhil Kumar Natarajan,et al.  Comparison of receivers for solar dish collector system , 2008 .

[31]  Walid Chakroun,et al.  Effect of aperture geometry on heat transfer in tilted partially open cavities , 1999 .

[32]  Wai Ming To,et al.  Numerical simulation of buoyant, turbulent flow—II. Free and mixed convection in a heated cavity , 1986 .

[33]  R. G. Schwind,et al.  Experimental, Variable Properties Natural Convection From a Large, Vertical, Flat Surface , 1985 .

[34]  S. Ramadhyani,et al.  Natural convection in a side-facing open cavity , 1991 .