Enhanced lipid production of Chlorella vulgaris by adjustment of cultivation conditions.

To increase the lipid productivity and thus to reduce the production cost of microalgal biodiesel, effects of cultivation conditions including KNO(3)-level, CO(2) concentration and irradiance on the cell growth, chlorophyll a content and lipid accumulation of Chlorella vulgaris were systematically investigated in a membrane sparged photobioreactor. The biochemical compositions including carbohydrates, proteins and lipids were analyzed simultaneously by the FT-IR spectroscopy. The results showed that the largest biomass productivity and the highest lipid content were obtained at different cultivation conditions. The algae should be harvested at a point that optimized the biomass productivity and lipid content. When the cultivation conditions were controlled at 1.0mM KNO(3), 1.0% CO(2) and 60 micromol photons m(-2)s(-1) at 25 degrees C, the highest lipid productivity obtained was 40 mg L(-1)d(-1), which was about 2.5-fold that had been reported by Illman et al. (2000). The influences of cultivation conditions on the cell growth, lipid accumulation, and other biochemical compositions of cells were further discussed and illustrated by a schematic which was also useful for other microalgal species.

[1]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[2]  Lin Zhang,et al.  Evaluation of a membrane-sparged helical tubular photobioreactor for carbon dioxide biofixation by Chlorella vulgaris , 2008 .

[3]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[4]  Qingyu Wu,et al.  High-density fermentation of microalga Chlorella protothecoides in bioreactor for microbio-diesel production , 2008, Applied Microbiology and Biotechnology.

[5]  Li-Hua Cheng,et al.  Carbon dioxide removal from air by microalgae cultured in a membrane-photobioreactor , 2006 .

[6]  J. Mouget,et al.  Change in light quality due to a blue-green pigment, marennine, released in oyster-ponds: effect on growth and photosynthesis in two diatoms, Haslea ostrearia and Skeletonema costatum , 2000, Journal of Applied Phycology.

[7]  E. Arnold,et al.  Standard methods for the examination of water and wastewater. 16th ed. , 1985 .

[8]  A. Wellburn.  The Spectral Determination of Chlorophylls a and b, as well as Total Carotenoids, Using Various Solvents with Spectrophotometers of Different Resolution* , 1994 .

[9]  C. Ugwu,et al.  Photobioreactors for mass cultivation of algae. , 2008, Bioresource technology.

[10]  L. Rodolfi,et al.  Microalgae for oil: Strain selection, induction of lipid synthesis and outdoor mass cultivation in a low‐cost photobioreactor , 2009, Biotechnology and bioengineering.

[11]  W. J. Li,et al.  Carbon bio-fixation by photosynthesis of Thermosynechococcus sp. CL-1 and Nannochloropsis oculta. , 2009, Journal of photochemistry and photobiology. B, Biology.

[12]  X. Miao,et al.  Biodiesel production from heterotrophic microalgal oil. , 2006, Bioresource technology.

[13]  M. Huntley,et al.  CO2 Mitigation and Renewable Oil from Photosynthetic Microbes: A New Appraisal , 2007 .

[14]  Y. Kitaya,et al.  Effects of temperature, CO2/O2 concentrations and light intensity on cellular multiplication of microalgae, Euglena gracilis. , 2005, Advances in space research : the official journal of the Committee on Space Research.

[15]  Chih-Sheng Lin,et al.  Reduction of CO2 by a high-density culture of Chlorella sp. in a semicontinuous photobioreactor. , 2008, Bioresource technology.

[16]  K. Gao,et al.  Optimization of growth and fatty acid composition of a unicellular marine picoplankton, Nannochloropsis sp., with enriched carbon sources , 2003, Biotechnology Letters.

[17]  C. Lan,et al.  Effects of nitrogen sources on cell growth and lipid accumulation of green alga Neochloris oleoabundans , 2008, Applied Microbiology and Biotechnology.

[18]  J. Benemann,et al.  Look Back at the U.S. Department of Energy's Aquatic Species Program: Biodiesel from Algae; Close-Out Report , 1998 .

[19]  F. Smith,et al.  COLORIMETRIC METHOD FOR DETER-MINATION OF SUGAR AND RELATED SUBSTANCE , 1956 .

[20]  S. Harrison,et al.  Lipid productivity as a key characteristic for choosing algal species for biodiesel production , 2009, Journal of Applied Phycology.

[21]  W. J. Dyer,et al.  A rapid method of total lipid extraction and purification. , 1959, Canadian journal of biochemistry and physiology.

[22]  T. Tornabene,et al.  Lipid composition of the nitrogen starved green alga Neochloris oleoabundans , 1983 .

[23]  Y. Yun,et al.  Enhancement of CO2 tolerance of Chlorella vulgaris by gradual increase of CO2 concentration. , 1996 .

[24]  W. J. DeGrip,et al.  Monitoring of biomass composition from microbiological sources by means of FT‐IR spectroscopy , 2009, Biotechnology and bioengineering.

[25]  Bai-cheng Zhou,et al.  Effect of iron on growth and lipid accumulation in Chlorella vulgaris. , 2008, Bioresource technology.

[26]  D. Grizeau,et al.  Eicosapentaenoic acid content of Skeletonema costatum as a function of growth and irradiance; relation with chlorophyll a content and photosynthetic capacity , 1996 .

[27]  A. Sukenik,et al.  Lipid synthesis and abundance of acetyl CoA carboxylase in isochrysis galbana (prymnesiophyceae) following nitrogen starvation , 1992 .

[28]  A. Richmond,et al.  EFFECT OF ENVIRONMENTAL CONDITIONS ON FATTY ACID COMPOSITION OF THE RED ALGA PORPHYRIDIUM CRUENTUM: CORRELATION TO GROWTH RATE 1 , 1988 .

[29]  R. Millán-Núñez,et al.  Protein, carbohydrate, lipid and chlorophyll a content in Isochrysis aff. galbana (clone T-Iso) cultured with a low cost alternative to the f/2 medium , 2002 .

[30]  Hee-Mock Oh,et al.  Selection of microalgae for lipid production under high levels carbon dioxide. , 2010, Bioresource technology.

[31]  Y. Sasaki,et al.  Plant Acetyl-CoA Carboxylase: Structure, Biosynthesis, Regulation, and Gene Manipulation for Plant Breeding , 2004, Bioscience, biotechnology, and biochemistry.

[32]  J. Ohlrogge,et al.  Lipid biosynthesis. , 1995, The Plant cell.

[33]  A. Sukenik,et al.  Variations in Lipid and Fatty Acid Content in Relation to Acetyl CoA Carboxylase in the Marine Prymnesiophyte Isochrysis galbana , 1991 .

[34]  M. M. Bradford.  A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. , 1976, Analytical biochemistry.

[35]  Li-Hua Cheng,et al.  Optimization of Carbon Dioxide Fixation by Chlorella vulgaris Cultivated in a Membrane-Photobioreactor , 2007 .

[36]  Gokare A. Ravishankar,et al.  Autotrophic cultivation of Botryococcus braunii for the production of hydrocarbons and exopolysaccharides in various media , 2007 .

[37]  Chiun-Hsun Chen,et al.  Lipid accumulation and CO2 utilization of Nannochloropsis oculata in response to CO2 aeration. , 2009, Bioresource technology.