Evolution of coal self-heating processes in longwall gob areas

Abstract Understanding the evolution of coal self-heating in longwall mining gob areas is important for the mitigation of underground mine fires. The coal self-heating involves a chain of complex interactions between compositional gas and solid coal. These interactions are normally regulated by the dynamic gob configuration due to the extraction of coal. In this study, a fully coupled transient model of compositional gas flow and transport, and the heat transfer between solid coal and gas is developed to quantify the evolution of coal self-heating processes under the in-situ gob configuration. The modelled results were matched reasonably well with the field measurements of air temperatures and oxygen concentrations for a Chinese coal mine. The verified model was applied to conduct sensitivity studies of (1) ventilation flux; (2) ventilation resistance; and (3) advance rate of face. The main results of the sensitivity study reveal that (i) the high temperature zones are mainly distributed near the intake airway of gob; (ii) the higher ventilation flux or ventilation resistance leads to the higher self-heating temperature and the larger oxidation self-heating zone. Moreover, the self-heating zone migrates towards the much deeper gob area. Whereas, the higher advance rate of face results in the lower self-heating temperature and smaller self-heating zone. The simulated results can provide some suggestions for the prevention of coal spontaneous combustion in gobs.

[1]  Bo Tan,et al.  Numerical investigation and theoretical prediction of self-ignition characteristics of coarse coal stockpiles , 2013 .

[2]  Boleslav Taraba,et al.  DEVELOPMENT OF OXIDATION HEAT OF THE COAL LEFT IN THE MINED-OUT AREA OF A LONGWALL FACE - MODELLING USING THE FLUENT SOFTWARE , 2008 .

[3]  Milada Kozubková,et al.  CFD simulations of the effect of wind on the spontaneous heating of coal stockpiles , 2014 .

[4]  L. Yuan.  Effects of ventilation and gob characteristics on spontaneous heating in longwall gob areas , 2008 .

[5]  Johannes Bruining,et al.  Modeling of gas flow and temperature fields in underground coal fires , 2001 .

[6]  Zhou Fubao,et al.  A comprehensive hazard evaluation system for spontaneous combustion of coal in underground mining , 2010 .

[7]  V. Tsihrintzis,et al.  Determination of Forchheimer equation coefficients a and b , 2007 .

[8]  E. Petit,et al.  An approach to the modelling of spontaneous combustion in the goaf , 2002 .

[9]  L. Yuan,et al.  Effect of longwall face advance on spontaneous heating in longwall gob area , 2010 .

[10]  David Glasser,et al.  Spontaneous combustion of carbonaceous stockpiles. Part II. Factors affecting the rate of the low-temperature oxidation reaction , 2005 .

[11]  P. Nordon,et al.  A model for the self-heating reaction of coal and char , 1979 .

[12]  K. Vafai,et al.  Analysis of Variants Within the Porous Media Transport Models , 2000 .

[13]  Liming Yuan,et al.  Numerical study on effects of coal properties on spontaneous heating in longwall gob areas , 2008 .

[14]  David J. Williams,et al.  Greenhouse gas emissions from low-temperature oxidation and spontaneous combustion at open-cut coal mines in Australia , 2009 .

[15]  S. S. Mahapatra,et al.  Prediction of spontaneous heating susceptibility of Indian coals using fuzzy logic and artificial neural network models , 2011, Expert Syst. Appl..

[16]  W. Kessels,et al.  Investigating dynamic underground coal fires by means of numerical simulation , 2008 .

[17]  Bogdan Z. Dlugogorski,et al.  Coal Oxidation at Low Temperatures: Oxygen Consumption, Oxidation Products, Reaction Mechanism and Kinetic Modeling , 2004 .

[18]  Zdenek Dostál,et al.  Mathematical modeling of bituminous coal seams burning contemporaneously with the formation of a variegated beds body , 2004 .

[19]  Boleslav Taraba,et al.  Effect of longwall face advance rate on spontaneous heating process in the gob area – CFD modelling , 2011 .

[20]  Fehmi Akgün,et al.  Self-ignition characteristics of coal stockpiles: theoretical prediction from a two-dimensional unsteady-state model , 2001 .

[21]  Liming Yuan,et al.  CFD modeling of spontaneous heating in a large-scale coal chamber , 2009 .

[22]  Bogdan Z. Dlugogorski,et al.  Coal oxidation at low temperatures: oxygen consumption, oxidation products, reaction mechanism and kinetic modelling , 2003 .

[23]  Chae Hoon Sohn,et al.  A novel method to suppress spontaneous ignition of coal stockpiles in a coal storage yard , 2012 .

[24]  John Carras,et al.  Self-heating of coal and related materials: Models, application and test methods , 1994 .

[25]  Kamel Hooman,et al.  Numerical modelling of the self-heating process of a wet porous medium , 2011 .

[26]  J. Bear.  Hydraulics of Groundwater , 1979 .

[27]  C. Karacan,et al.  Monte Carlo Simulation and Well Testing Applied in Evaluating Reservoir Properties in a Deforming Longwall Overburden , 2011 .

[28]  J. Duyzer,et al.  A model for the spontaneous heating of coal , 1985 .

[29]  Tongqiang Xia,et al.  A fully coupled hydro-thermo-mechanical model for the spontaneous combustion of underground coal seams , 2014 .

[30]  C. Kuenzer,et al.  Numerical modeling for analyzing thermal surface anomalies induced by underground coal fires , 2008 .