Design and control of a planar bipedal robot ERNIE with parallel knee compliance

This paper presents the development of the planar bipedal robot ERNIE as well as numerical and experimental studies of the influence of parallel knee joint compliance on the energetic efficiency of walking in ERNIE. ERNIE has 5 links—a torso, two femurs and two tibias—and is configured to walk on a treadmill so that it can walk indefinitely in a confined space. Springs can be attached across the knee joints in parallel with the knee actuators. The hybrid zero dynamics framework serves as the basis for control of ERNIE’s walking. In the investigation of the effects of compliance on the energetic efficiency of walking, four cases were studied: one without springs and three with springs of different stiffnesses and preloads. It was found that for low-speed walking, the addition of soft springs may be used to increase energetic efficiency, while stiffer springs decrease the energetic efficiency. For high-speed walking, the addition of either soft or stiff springs increases the energetic efficiency of walking, while stiffer springs improve the energetic efficiency more than do softer springs.

[1]  Friedrich Pfeiffer,et al.  Sensors and control concept of a biped robot , 2004, IEEE Transactions on Industrial Electronics.

[2]  Yannick Aoustin,et al.  Optimal reference trajectories for walking and running of a biped robot , 2001, Robotica.

[3]  Tad McGeer,et al.  Passive Dynamic Walking , 1990, Int. J. Robotics Res..

[4]  Russ Tedrake,et al.  Efficient Bipedal Robots Based on Passive-Dynamic Walkers , 2005, Science.

[5]  Marc H. Raibert,et al.  Legged Robots That Balance , 1986, IEEE Expert.

[6]  Garth Zeglin,et al.  Powered bipeds based on passive dynamic principles , 2005, 5th IEEE-RAS International Conference on Humanoid Robots, 2005..

[7]  Russell L. Tedrake,et al.  Applied optimal control for dynamically stable legged locomotion , 2004 .

[8]  Jerry E. Pratt,et al.  Intuitive control of a planar bipedal walking robot , 1998, Proceedings. 1998 IEEE International Conference on Robotics and Automation (Cat. No.98CH36146).

[9]  E. Westervelt,et al.  Feedback Control of Dynamic Bipedal Robot Locomotion , 2007 .

[10]  Guy Bessonnet,et al.  Generating globally optimised sagittal gait cycles of a biped robot , 2003, Robotica.

[11]  M. Coleman,et al.  An Uncontrolled Walking Toy That Cannot Stand Still , 1998 .

[12]  M. Günther,et al.  Synthesis of two-dimensional human walking: a test of the λ-model , 2003, Biological Cybernetics.

[13]  A. Ruina,et al.  Efficiency, speed, and scaling of two-dimensional passive-dynamic walking , 2000 .

[14]  Martin Buehler,et al.  The ARL monopod II running robot: control and energetics , 1999, Proceedings 1999 IEEE International Conference on Robotics and Automation (Cat. No.99CH36288C).

[15]  P. Willems,et al.  Effect of load and speed on the energetic cost of human walking , 2005, European Journal of Applied Physiology.

[16]  Frans C. T. van der Helm,et al.  How to keep from falling forward: elementary swing leg action for passive dynamic walkers , 2005, IEEE Transactions on Robotics.

[17]  H. Ralston.  Energy-speed relation and optimal speed during level walking , 1958, Internationale Zeitschrift für angewandte Physiologie einschließlich Arbeitsphysiologie.

[18]  Fumiya Iida,et al.  Toward a human-like biped robot with compliant legs , 2009, Robotics Auton. Syst..

[19]  Arend L. Schwab,et al.  A 3D passive dynamic biped with yaw and roll compensation , 2001, Robotica.

[20]  Christine Chevallereau,et al.  Energetic Effects of Adding Springs at the Passive Ankles of a Walking Biped Robot , 2007, Proceedings 2007 IEEE International Conference on Robotics and Automation.

[21]  D. Jacobson,et al.  Studies of human locomotion via optimal programming , 1971 .

[22]  I. Kato,et al.  The hydraulically powered biped walking machine with a high carrying capacity , 1972 .

[23]  Anindya Chatterjee,et al.  Small slope implies low speed for McGeer's passive walking machines , 2000 .

[24]  Joel E. Chestnutt,et al.  Design and Philosophy of the BiMASC, a Highly Dynamic Biped , 2007, Proceedings 2007 IEEE International Conference on Robotics and Automation.

[25]  Guy Bessonnet,et al.  Sagittal gait of a biped robot during the single support phase. Part 1: passive motion , 2001, Robotica.

[26]  Christine Chevallereau,et al.  RABBIT: a testbed for advanced control theory , 2003 .

[27]  Arthur D. Kuo,et al.  Choosing Your Steps Carefully , 2007, IEEE Robotics & Automation Magazine.

[28]  R. McN. Alexander,et al.  Three Uses for Springs in Legged Locomotion , 1990, Int. J. Robotics Res..

[29]  Jessy W. Grizzle,et al.  Experimental Validation of a Framework for the Design of Controllers that Induce Stable Walking in Planar Bipeds , 2004, Int. J. Robotics Res..

[30]  T. Yang,et al.  A Framework for the Control of Stable Aperiodic Walking in Underactuated Planar Bipeds , 2007, ICRA.

[31]  Martijn Wisse,et al.  A Three-Dimensional Passive-Dynamic Walking Robot with Two Legs and Knees , 2001, Int. J. Robotics Res..

[32]  Guy Bessonnet,et al.  Impactless sagittal gait of a biped robot during the single support phase , 1998, Proceedings. 1998 IEEE International Conference on Robotics and Automation (Cat. No.98CH36146).

[33]  Bram Vanderborght,et al.  Exploiting Natural Dynamics to Reduce Energy Consumption by Controlling the Compliance of Soft Actuators , 2006, Int. J. Robotics Res..

[34]  Chee-Meng Chew,et al.  Virtual Model Control: An Intuitive Approach for Bipedal Locomotion , 2001, Int. J. Robotics Res..

[35]  R. Kram,et al.  Energetic cost and preferred speed of walking in obese vs. normal weight women. , 2005, Obesity research.

[36]  Kikuo Fujimura,et al.  The intelligent ASIMO: system overview and integration , 2002, IEEE/RSJ International Conference on Intelligent Robots and Systems.

[37]  Andy Ruina,et al.  A Bipedal Walking Robot with Efficient and Human-Like Gait , 2005, Proceedings of the 2005 IEEE International Conference on Robotics and Automation.

[38]  Leonard Barolli,et al.  Real time gait generation for autonomous humanoid robots: A case study for walking , 2003, Robotics Auton. Syst..

[39]  D. T. Pham,et al.  Derivation of optimal walking motions for a bipedal walking robot , 1992, Robotica.

[40]  Daniel E. Koditschek,et al.  Hybrid zero dynamics of planar biped walkers , 2003, IEEE Trans. Autom. Control..