A MEMS Device Capable of Measuring Near-Field Thermal Radiation between Membranes

For sensors constructed by freestanding membranes, when the gap between a freestanding membrane and the substrate or between membranes is at micron scale, the effects of near-field radiative heat transfer on the sensors' thermal performance should be considered during sensor design. The radiative heat flux is transferred from a membrane to a plane or from a membrane to a membrane. In the current study of the near-field thermal radiation, the scanning probe technology has difficulty in making a membrane separated at micron scale parallel to a plane or another membrane. A novel MEMS (micro electromechanical system) device was developed by sacrificial layer technique in this work to realize a double parallel freestanding membrane structure. Each freestanding membrane has a platinum thin-film resistor and the distance between the two membranes is 1 μm. After evaluating the electrical and thermal characteristics of the lower freestanding membrane,experimental measurements of near-field radiative heat transfer between the lower membrane and the upper membrane were carried out by setting the lower membrane as a heat emitter and the upper membrane as a heat receiver. The near-field radiative heat transfer between the two membranes was validated by finding a larger-than-blackbody radiative heat transfer based on the experimental data.

[1]  Gang Chen,et al.  Near-field radiative heat transfer between a sphere and a substrate , 2008, 0909.0784.

[2]  Gang Chen,et al.  Surface phonon polaritons mediated energy transfer between nanoscale gaps. , 2009, Nano letters.

[3]  Pasqualina M. Sarro,et al.  A silicon-silicon nitride membrane fabrication process for smart thermal sensors , 1994 .

[4]  Jean-Jacques Greffet,et al.  ENHANCED RADIATIVE HEAT TRANSFER AT NANOMETRIC DISTANCES , 2002, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[5]  Masafumi Kimata,et al.  Low-cost 320x240 uncooled IRFPA using a conventional silicon IC process , 1999, Defense, Security, and Sensing.

[6]  Shanhong Xia,et al.  An ac microcalorimeter for measuring specific heat of thin films , 2004, Microelectron. J..

[7]  Tang Zhen-an,et al.  A Novel CMOS Device Capable of Measuring Near-Field Thermal Radiation , 2012 .

[8]  Y. Çengel.  Heat Transfer: A Practical Approach , 1997 .

[9]  Jean-Jacques Greffet,et al.  Thermal radiation scanning tunnelling microscopy , 2006, Nature.

[10]  Ching-Liang Dai,et al.  Fabrication and Characterization of CMOS-MEMS Thermoelectric Micro Generators , 2010, Sensors.

[11]  Pierre Temple-Boyer,et al.  Realization and performance of thin SiO2/SiNx membrane for microheater applications , 1998 .

[12]  Zhenan Tang,et al.  Measurement of the Heat Capacity of Copper Thin Films Using a Micropulse Calorimeter , 2010 .

[13]  Euisik Yoon,et al.  A high fill-factor infrared bolometer using micromachined multilevel electrothermal structures , 1999 .

[14]  Frédérick Mailly,et al.  Anemometer with hot platinum thin film , 2001 .

[15]  J. Parisi,et al.  Heat transfer in ultrahigh vacuum scanning thermal microscopy , 1999 .

[16]  Jean-Jacques Greffet,et al.  Radiative heat transfer at the nanoscale , 2009 .

[17]  Wolfgang Müller-Hirsch,et al.  Near-field heat transfer in a scanning thermal microscope. , 2005, Physical review letters.

[18]  Andrea Irace,et al.  Measurement of thermal conductivity and diffusivity of single and multilayer membranes , 1999 .

[19]  T. Tanaka,et al.  Infrared focal plane array incorporating silicon IC process compatible bolometer , 1996 .

[20]  C. M Hargreaves,et al.  Anomalous radiative transfer between closely-spaced bodies , 1969 .

[21]  R. A. Smith,et al.  Book Reviews: The Detection and Measurement of Infra-Red Radiation , 1957 .

[22]  Lu Hu,et al.  Near-field Thermal Radiation Between Two Closely Spaced Glass Plates Exceeding Planck’s Blackbody Radiation Law , 2008 .

[23]  Jinfeng Li,et al.  A MicroPirani Pressure Sensor Based on the Tungsten Microhotplate in a Standard CMOS Process , 2009, IEEE Transactions on Industrial Electronics.

[24]  J. Meseguer,et al.  Thermal radiation heat transfer , 2012 .

[25]  R. Carminati,et al.  Surface electromagnetic waves thermally excited: Radiative heat transfer, coherence properties and Casimir forces revisited in the near field , 2005, physics/0504068.

[26]  Rolf Möller,et al.  Heat transfer between two metallic surfaces at small distances , 1994 .

[27]  Li-Tian Liu,et al.  Study on new structure uncooled a-Si microbolometer for infrared detection , 2007, Microelectron. J..

[28]  Robert E. Higashi,et al.  Monolithic two-dimensional arrays of micromachined microstructures for infrared applications , 1998, Proc. IEEE.

[29]  C. L. Tien,et al.  MEASUREMENTS OF THERMAL RADIATION OF SOLIDS AT LIQUID-HELIUM TEMPERATURES , 1969 .

[30]  C. L. Tien,et al.  Experimental Investigation of Radiative Transfer Between Metallic Surfaces at Cryogenic Temperatures , 1970 .