Experimental and Theoretical Investigation of Degradation Mechanisms by Particle Coarsening in SOFC Electrodes

Performance degradation data obtained on single solid oxide fuel cells tested at 850°C with air and humidified H2 and using Ni-YSZ anode supported cells are presented. Microscopic investigation is carried out on both anode and cathode to quantify variations in morphology at different operation times. The comparison between the measurements on the cells and the SEM image analysis allows concluding that there is no relationship between the initial cell activation and micro-structural modifications of the electrodes. On the other hand, it was found that cell degradation is strictly related to the coarsening of Ni particles occurring in the anode. A theoretical analysis based on an electrode micro-model has been performed in order to compare the variation in performance, expected from particle size change, with the observed data. The model confirmed the conclusions taken from the experimental results.

[1]  V. Antonucci,et al.  Micro-modelling of solid oxide fuel cell electrodes , 1998 .

[2]  Peter Vang Hendriksen,et al.  Assessment of the Cathode Contribution to the Degradation of Anode-Supported Solid Oxide Fuel Cells , 2008 .

[3]  J. herle,et al.  Conductivity of Mn and Ni-doped stabilized zirconia electrolyte , 2004 .

[4]  J. H. Kuo,et al.  Oxidation-reduction behavior of undoped and Sr-doped LaMnO3: Defect structure, electrical conductivity, and thermoelectric power , 1990 .

[5]  Meilin Liu,et al.  Influence of cell voltage and current on sulfur poisoning behavior of solid oxide fuel cells , 2007 .

[6]  Shin-ichiro Takahashi,et al.  Effect of annealing on the electrical conductivity of the Y2O3–ZrO2 system , 2004 .

[7]  S. Alam,et al.  Framework Convention on Climate Change , 1993 .

[8]  S. Jiang,et al.  Issues on development of (La,Sr)MnO3 cathode for solid oxide fuel cells , 2003 .

[9]  Y. Matsuzaki,et al.  Electrochemical properties of a SOFC cathode in contact with a chromium-containing alloy separator , 2000 .

[10]  J. Van herle,et al.  Nickel–Zirconia Anode Degradation and Triple Phase Boundary Quantification from Microstructural Analysis , 2009 .

[11]  L. Gauckler,et al.  Thermodynamic modeling of the La–Mn–Y–Zr–O system , 2006 .

[12]  F. Lange,et al.  Relation between percolation and particle coordination in binary powder mixtures , 1991 .

[13]  Paola Costamagna,et al.  Effect of composition on the performance of cermet electrodes. Experimental and theoretical approach , 2002 .

[14]  Ludwig J. Gauckler,et al.  La2Zr2O7 formation and oxygen reduction kinetics of the La0.85Sr0.15MnyO3, O2(g)|YSZ system , 1998 .

[15]  Peter Vang Hendriksen,et al.  Degradation of Anode Supported SOFCs as a Function of Temperature and Current Load , 2006 .

[16]  Taniguchi Shunsuke,et al.  Degradation phenomena in the cathode of a solid oxide fuel cell with an alloy separator , 1995 .

[17]  S. A. Barnett,et al.  A direct-methane fuel cell with a ceria-based anode , 1999, Nature.

[18]  Y. Matsuzaki,et al.  The Poisoning Effect of Sulfur-Containing Impurity Gas on a SOFC Anode: Part I , 2000 .

[19]  S. Jiang,et al.  Sintering behavior of Ni/Y2O3-ZrO2cermet electrodes of solid oxide fuel cells , 2003 .

[20]  Daniel Favrat,et al.  Modeling and Study of the Influence of Sealing on a Solid Oxide Fuel Cell , 2008 .

[21]  Electrical behaviour of strontium-doped lanthanum manganite interfaces , 2005 .

[22]  N. Minh.  Ceramic Fuel Cells , 1993 .

[23]  Harumi Yokokawa,et al.  Thermodynamic considerations on Cr poisoning in SOFC cathodes , 2006 .

[24]  Adriana Del Borghi,et al.  Effects of Mass Transport on the Performance of Solid Oxide Fuel Cells Composite Electrodes , 2007 .

[25]  Daniel Favrat,et al.  Simulation of SOFC stack and repeat elements including interconnect degradation and anode reoxidation risk , 2006 .

[26]  Sun-Woo Choi,et al.  Viable image analyzing method to characterize the microstructure and the properties of the Ni/YSZ cermet anode of SOFC , 2005 .

[27]  U. Stimming,et al.  Advances, aging mechanisms and lifetime in solid-oxide fuel cells , 2004 .

[28]  P. Costamagna,et al.  Simulation of mass transport in SOFC composite electrodes , 2008 .

[29]  Hermann Schichl,et al.  Degradation of the electrical conductivity in stabilised zirconia system: Part II: Scandia-stabilised zirconia , 2005 .

[30]  Kazunari Sasaki,et al.  Multi-Fuel Capability of Solid Oxide Fuel Cells , 2004 .

[31]  S. Jiang,et al.  Sintering and grain growth of (La,Sr)MnO3 electrodes of solid oxide fuel cells under polarization , 2005 .

[32]  H. Yokokawa,et al.  Thermodynamic database MALT2 and its applications to high temperature materials chemistry , 1994 .