Growth and compaction behaviour of copper concentrate granules in a rotating drum

In order to understand the growth and compaction behaviour of chalcopyrite (copper concentrate), batch granulation tests were carried out using a rotating drum. The granule growth exhibited induction-type behaviour, as defined by Iveson and Litster [AIChE J. 44 (1998) 15 10]. There were two consecutive stages during granulation: the induction stage, during which the granules are gradually being compacted and little or no growth occurs, and the rapid growth stage, which starts when the granules have become surface wet and are rapidly growing. In agreement with earlier findings. an increased amount of binder liquid shortened the induction time. The compaction behaviour was also investigated. A displaced volume method was adopted to determine the porosity of the granules. It was shown that this technique had a limitation as it was unable to detect the reduction of the volumes of the granule pores after the granules had become surface wet. Due to this, some of the measurements were not suited for fitting a three-parameter empirical model. Attempts were made to determine whether the rapid growth stage started with the pore saturation exceeding a certain critical value, but due to the scatter in the porosity measurements and the fact that some of the measurements could not be used, it was not possible to determine a critical pore saturation, However, the porosity measurements clearly demonstrated that the porosity of the granules decreased during the induction stage of an experiment and that when rapid growth occurred, the granules had a pore saturation was around 0.85. This value was slightly lower than unity, which is most likely due to trapped air bubbles. (C) 2002 Published by Elsevier Science B.V.

[1]  James D. Litster,et al.  Fundamental studies of granule consolidation Part 1: Effects of binder content and binder viscosity , 1996 .

[2]  Ekkehard Fluck,et al.  Gmelins Handbuch der anorganischen Chemie , 1931, Nature.

[3]  P. C. Kapur,et al.  Size Distributions and Kinetic Relationships in Nuclei Region of Wet Pelletization , 1966 .

[4]  M NewittD,et al.  A contribution to the theory and practice of granulation. , 1958 .

[5]  B. J. Ennis,et al.  A microlevel-based characterization of granulation phenomena , 1991 .

[6]  P. C. Kapur.  Balling and Granulation , 1978 .

[7]  James D. Litster,et al.  Fundamental studies of granule consolidation. Part 2 : Quantifying the effects of particle and binder properties , 1998 .

[8]  James D. Litster,et al.  Growth regime map for liquid-bound granules: further development and experimental validation , 2001 .

[9]  P. V. Danckwerts,et al.  GRANULE FORMATION BY THE AGGLOMERATION OF DAMP POWDERS PART I: THE MECHANISM OF GRANULE GROWTH , 1981 .

[10]  Torben Schæfer,et al.  Granulation: A Review on Pharmaceutical Wet-Granulation , 1987 .

[11]  Torben Schæfer,et al.  A REVIEW ON PHARMACEUTICAL WET-GRANULATION , 1987 .

[12]  Tatsuo Tanaka,et al.  The Probability of Coalescence in Granulation Kinetics , 1975 .

[13]  Ananth Annapragada,et al.  On the modelling of granulation processes: A short note , 1996 .

[14]  James D. Litster,et al.  Coalescence of deformable granules in wet granulation processes , 2000 .

[15]  Sotiris E. Pratsinis,et al.  Agglomeration behaviour of powders in a Lödige mixer granulator , 1998 .

[16]  P. C. Kapur,et al.  Coalescence Model for Granulation , 1969 .

[17]  James D. Litster,et al.  Growth regime map for liquid-bound granules , 1998 .