Harvesting microalgae by flocculation–sedimentation

Abstract Slurries of five marine and freshwater microalgae (Chlorella vulgaris, Choricystis minor, Cylindrotheca fusiformis, Neochloris sp., Nannochloropsis salina) were effectively flocculated using aluminum sulfate and ferric chloride as flocculants. The flocculant dose for 95% removal of the algal biomass by sedimentation in a standardized 62 min treatment depended on the following factors: the type of the flocculant; the algal species and cell diameter; the concentration of the biomass in the algal slurry; and the ionic strength of the suspending fluid. For all algae, the flocculant dose for 95% removal of the cells increased linearly with the concentration of the biomass in the slurry. Aluminum sulfate was a generally better flocculant than ferric chloride. Less flocculant was required for flocculation from a high ionic strength medium for the one alga (C. vulgaris) that could be grown both in freshwater- and seawater-based media. Quantitative relationships are reported for the flocculant dose dependence on the biomass concentration in suspensions of the five algae.

[1]  John Bratby,et al.  Coagulation and Flocculation in Water and Wastewater Treatment , 2008 .

[2]  Tawan Chatsungnoen,et al.  An assessment of inexpensive methods for recovery of microalgal biomass and oils : a thesis presented in partial fulfilment of the requirements for the degree of Doctor of Philosophy in Biotechnology at Massey University, Palmerston North, New Zealand , 2015 .

[3]  B. Jefferson,et al.  Successful Removal of Algae through the Control of Zeta Potential , 2008 .

[4]  Yusuf Chisti,et al.  Constraints to commercialization of algal fuels. , 2013, Journal of biotechnology.

[5]  D. Bilanović,et al.  Flocculation of microalgae in brackish and sea waters , 1988 .

[6]  P. Ashman,et al.  Harvesting, Thickening and Dewatering Microalgae Biomass , 2013 .

[7]  E. Becker.  Microalgae: Biotechnology and Microbiology , 1994 .

[8]  Yi Zhu,et al.  Evaluation of several flocculants for flocculating microalgae. , 2015, Bioresource technology.

[9]  Michael K. Danquah,et al.  Dewatering of microalgal culture for biodiesel production: exploring polymer flocculation and tangential flow filtration , 2009 .

[10]  Francisco Gabriel Acién Fernández,et al.  Downstream Processing of Cell‐Mass and Products , 2013 .

[11]  Yoon,et al.  Effects of harvesting method and growth stage on the flocculation of the green alga Botryococcus braunii , 1998 .

[12]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[13]  Cristina González-Fernández,et al.  Microalgae autoflocculation: an alternative to high-energy consuming harvesting methods , 2012, Journal of Applied Phycology.

[14]  R. Guillard,et al.  Counting Cells in Cultures with the Light Microscope , 2005 .

[15]  Hui Shen,et al.  Basic Culturing Techniques , 2007 .

[16]  P. Abreu,et al.  Screening of commercial natural and synthetic cationic polymers for flocculation of freshwater and marine microalgae and effects of molecular weight and charge density , 2015 .

[17]  D. Bilanović,et al.  Flocculation of microalgae with cationic polymers — Effects of medium salinity , 1988 .

[18]  Jo‐Shu Chang,et al.  Dewatering and Drying Methods for Microalgae , 2015 .

[19]  R. Andersen,et al.  Algal culturing techniques , 2005 .

[20]  Michael A. Borowitzka,et al.  Microalgae as sources of pharmaceuticals and other biologically active compounds , 1995, Journal of Applied Phycology.

[21]  Q. Hu,et al.  Influence of growth phase on harvesting of Chlorella zofingiensis by dissolved air flotation. , 2012, Bioresource technology.

[22]  Peter J. Ashman,et al.  Harvesting of marine microalgae by electroflocculation: The energetics, plant design, and economics , 2013 .

[23]  J. Gregory,et al.  Coagulation by hydrolysing metal salts , 2003 .

[24]  Yusuf Chisti,et al.  Raceways-based Production of Algal Crude Oil , 2013 .

[25]  Andrew Hoadley,et al.  Dewatering of microalgal cultures : a major bottleneck to algae-based fuels , 2010 .

[26]  Boudewijn Meesschaert,et al.  Flocculation of microalgae using cationic starch , 2009, Journal of Applied Phycology.

[27]  Bruce Jefferson,et al.  The impact of algal properties and pre-oxidation on solid-liquid separation of algae. , 2008, Water research.

[28]  Michael K. Danquah,et al.  Microalgal growth characteristics and subsequent influence on dewatering efficiency , 2009 .

[29]  D. Vandamme,et al.  Flocculation as a low-cost method for harvesting microalgae for bulk biomass production. , 2013, Trends in biotechnology.

[30]  C. Samorì,et al.  Flocculation induced by homogeneous and heterogeneous acid treatments in Desmodesmus communis , 2015 .

[31]  Jo‐Shu Chang,et al.  Microalgae biomass harvesting by bioflocculation-interpretation by classical DLVO theory , 2015 .

[32]  Y. Chisti,et al.  Recovery of microalgal biomass and metabolites: process options and economics. , 2003, Biotechnology advances.

[33]  J. L. Pavoni,et al.  Algal flocculation with synthetic organic polyelectrolytes. , 1969, Applied microbiology.

[34]  Dion Matthew Frederick Frampton,et al.  Production of microalgal concentrates by flocculation and their assessment as aquaculture feeds , 2006 .

[35]  Michael L. Gerardo,et al.  Harvesting of microalgae within a biorefinery approach: A review of the developments and case studies from pilot-plants , 2015 .

[36]  B. Jefferson,et al.  Characterisation of algogenic organic matter extracted from cyanobacteria, green algae and diatoms. , 2008, Water research.

[37]  Yusuf Chisti,et al.  Potential fuel oils from the microalga Choricystis minor , 2010 .

[38]  F. G. Acién,et al.  Evaluation of flocculants for the recovery of freshwater microalgae. , 2012, Bioresource technology.

[39]  René H. Wijffels,et al.  Harvesting of microalgae by bio-flocculation , 2010, Journal of Applied Phycology.

[40]  K. Gorin,et al.  Methods coagulation/flocculation and flocculation with ballast agent for effective harvesting of microalgae. , 2015, Bioresource technology.

[41]  Jay R. Werber,et al.  Application of membrane dewatering for algal biofuel , 2015 .

[42]  Peter J. Ashman,et al.  Microbial flocculation, a potentially low-cost harvesting technique for marine microalgae for the production of biodiesel , 2009, Journal of Applied Phycology.

[43]  Y. Chisti,et al.  Forward osmosis with waste glycerol for concentrating microalgae slurries , 2015 .

[44]  Aikaterini Papazi,et al.  Harvesting Chlorella minutissima using cell coagulants , 2010, Journal of Applied Phycology.