Hard carbon coatings with low optical absorption

Hydrogenated amorphous (a‐C:H) films were prepared by rf‐plasma deposition from benzene vapor. Complete optical absorption spectra from the UV to the IR (0.2–20.0 μm) have been measured. The optical gap depends linearly on hydrogen content and Eopt can be varied between 0.8 and 1.8 eV. For energies below Eopt the films are almost transparent and absorption is especially low in the 2–6‐μm region (e.g., α=15 cm−1 at λ=2.8 μm). Sharp C–H stretch absorption bands occur near 3.4 μm, giving insight into the microstructure of the films. A newly reported weak band at 3.03 μm is first evidence for C–C triple bonds (sp1 hybridization) in a‐C:H, where sp3 (single) and sp2 (double) C–C bonds dominate.

[1]  C. Weissmantel.  Ion-based growth of special films: Techniques and mechanisms , 1982 .

[2]  D. Anderson.  The electrical and optical properties of amorphous carbon prepared by the glow discharge technique , 1977 .

[3]  T. Moore,et al.  Carbyne Forms of Carbon: Do They Exist? , 1982, Science.

[4]  D. Joy,et al.  Ion‐beam‐deposited polycrystalline diamondlike films , 1976 .

[5]  R. Williamson,et al.  The deposition of hard surface layers by hydrocarbon cracking in a glow discharge , 1976 .

[6]  William Paul,et al.  Optical constants of rf sputtered hydrogenated amorphous Si , 1979 .

[7]  K. Weiser,et al.  dc Conductivity, Optical Absorption, and Photoconductivity of Amorphous Arsenic Telluride Films , 1970 .

[8]  B. G. Brooks,et al.  Disorder and the Optical-Absorption Edge of Hydrogenated Amorphous Silicon , 1981 .

[9]  S. Aisenberg,et al.  Ion‐Beam Deposition of Thin Films of Diamondlike Carbon , 1971 .

[10]  Ion beam sputter-deposited diamondlike films , 1982 .

[11]  D. Mckenzie,et al.  Hydrogenated carbon films produced by sputtering in argon-hydrogen mixtures. , 1982, Applied optics.

[12]  S. Berg,et al.  Diamond-like carbon films produced in a butane plasma , 1979 .

[13]  B. Meyerson,et al.  Electrical and optical properties of hydrogenated amorphous carbon films , 1980 .

[14]  S. Ojha,et al.  Deposition of hard and insulating carbonaceous films on an r.f. target in a butane plasma , 1976 .

[15]  B. Dischler,et al.  Optical properties of hydrogenated hard carbon thin films , 1982 .

[16]  L. Ley,et al.  Infrared Spectrum and Structure of Hydrogenated Amorphous Silicon , 1980 .

[17]  L. Young.  Prediction of Absorption Loss in Multilayer Interference Filters , 1962 .

[18]  H. Dimigen,et al.  Frictional properties of diamondlike carbon layers , 1980 .