Ionizing radiation effects on ultra-thin oxide MOS structures

We have briefly reviewed the most important degradation mechanisms affecting ultra-thin gate oxides after exposure to ionizing irradiation. The increase of the gate leakage current seems the most crucial issue for device lifetime, especially for non-volatile memory and dynamic logic. The build-up of positive charge in the oxide and the subsequent threshold voltage shift, which was the major concern for thicker oxide, are no longer appreciable in today's devices due to the reduced oxide thickness permitting a fast recombination of trapped holes with electrons from interfaces. Among the leakage currents affecting thin oxides we have considered here the Radiation Induced Leakage Current (RILC) and the Radiation Soft Breakdown (RSB). RILC is observed after irradiation with a low Linear Energy Transfer (LET) radiation source and comes from a trap-assisted tunneling of electrons mediated by the neutral traps produced by irradiation. RILC depends on the applied bias during irradiation and the maximum is measured when devices are biased in flat band. Contrarily to RILC, RSB is observed after irradiation with high LET ions and derives from the formation of several conductive paths across the oxide corresponding to the ion hits. RSB conduction is explained by the theory of the Quantum Point Contact as also proposed for the electrically induced Soft breakdown. Finally, we present some preliminary results, which indicate that although the direct effects of irradiation (in terms of gate leakage current increase) are small for oxide thinner than 3nm, it is possible that these devices may experience an accelerated wear-out and/or breakdown after subsequent electrical stress relative to a fresh (not irradiated) device.

[1]  E. Cartier,et al.  MECHANISM FOR STRESS-INDUCED LEAKAGE CURRENTS IN THIN SILICON DIOXIDE FILMS , 1995 .

[2]  Gabriella Ghidini,et al.  Noise characteristics of radiation-induced soft breakdown current in ultrathin gate oxides , 2001 .

[3]  H. E. Boesch,et al.  Reversibility of trapped hole annealing , 1988 .

[4]  A. Reisman,et al.  Radiation‐Induced Neutral Electron Trap Generation in Electrically Biased Insulated Gate Field Effect Transistor Gate Insulators , 1991 .

[5]  Alessandro Paccagnella,et al.  Radiation induced leakage current and stress induced leakage current in ultra-thin gate oxides , 1998 .

[6]  Jordi Suñé,et al.  Soft breakdown conduction in ultrathin (3-5 nm) gate dielectrics , 2000 .

[7]  M. Lenzlinger,et al.  Fowler‐Nordheim Tunneling into Thermally Grown SiO2 , 1969 .

[8]  Alessandro Paccagnella,et al.  Electrically and radiation induced leakage currents in thin oxides , 2000 .

[9]  Yuan Taur,et al.  Device scaling limits of Si MOSFETs and their application dependencies , 2001, Proc. IEEE.

[10]  Elyse Rosenbaum,et al.  Mechanism of stress-induced leakage current in MOS capacitors , 1997 .

[11]  Gabriella Ghidini,et al.  Breakdown properties of irradiated MOS capacitors , 1996 .

[12]  T. Oldham,et al.  Ionizing radiation effects in MOS oxides , 2000 .

[13]  Alessandro Paccagnella,et al.  Ionizing radiation induced leakage current on ultra-thin gate oxides , 1997 .

[14]  Shinichi Takagi,et al.  Experimental evidence of inelastic tunneling in stress-induced leakage current , 1999 .

[15]  A. Candelori,et al.  Heavy ion irradiation of thin gate oxides , 2000 .

[16]  Robert H. Dennard,et al.  CMOS scaling for high performance and low power-the next ten years , 1995, Proc. IEEE.

[17]  Alessandro Paccagnella,et al.  From Radiation Induced Leakage Current to Soft Breakdown in Irradiated MOS Devices With Ultrathin Gate Oxide , 1999 .

[18]  R. S. Scott,et al.  Thickness dependence of stress-induced leakage currents in silicon oxide , 1997 .

[19]  N. Ajika,et al.  Identification of stress-induced leakage current components and the corresponding trap models in SiO/sub 2/ films , 1997 .

[20]  Exploration of heavy ion irradiation effects on gate oxide reliability in power MOSFETs , 1995 .

[21]  D. B. Brown,et al.  Growth and Annealing of Trapped Holes and Interface States Using Time-Dependent Biases , 1987, IEEE Transactions on Nuclear Science.

[22]  D. Dimaria,et al.  Determination of insulator bulk trapped charge densities and centroids from photocurrent‐voltage charactersitcs of MOS structures , 1976 .

[23]  Alessandro Paccagnella,et al.  Soft breakdown current noise in ultra-thin gate oxides , 2002 .

[24]  Alessandro Paccagnella,et al.  Radiation effects on floating-gate memory cells , 2001 .

[25]  Yuri D. Glinka.  LUMINESCENT OBSERVATION OF MULTIPHOTON IONIZATION-FRAGMENTATION OF CHROMATE IONS ADSORBED ON A DISPERSE SIO2 SURFACE , 1997 .

[26]  peixiong zhao,et al.  Heavy-ion-induced breakdown in ultra-thin gate oxides and high-k dielectrics , 2001 .

[27]  Alessandro Paccagnella,et al.  Low field leakage current and soft breakdown in ultra-thin gate oxides after heavy ions, electrons or X-ray irradiation , 1999 .