A combined Dual Hot-Gas Bypass Defrosting method with accumulator heater for an air-to-air heat pump in cold region

The Dual Hot-Gas Bypass Defrosting (DHBD) cycle is an effective defrosting method compared to a Reverse Cycle Defrosting (RCD) method to remove frost from the outdoor heat exchanger (HEX) of an air-to-air heat pump, especially the outdoor temperature is above 0°C. However, the DHBD method has a drawback when the heat pump operates in cold outdoor environment, below 0°C due to rapid decrease in refrigerant temperature followed by lower hot-gas bypass temperature. In order to overcome lower discharge temperature of compressor, a combined defrosting cycle with DHBD and the accumulator heating method is developed. An induction heater (IH) is adopted as the accumulator heater. The dynamic performance and defrosting time are compared between the conventional RCD method and the combined DHBD–IH method using a medium size air-to-air heat pump of 16kW under the condition of −5°C outdoor temperature. Due to the additional heater, the combined DHBD–IH method sustained higher discharge temperature of the compressor and reduced 15% of the defrosting time than that of the RCD method with nonstop indoor heating operation. The overall heating capacity of the DHBD–IH cycle including defrosting mode was 2.5kW higher than that of the RCD cycle.

[1]  Neil Hewitt,et al.  Defrost cycle performance for a circular shape evaporator air source heat pump , 2008 .

[2]  Honghyun Cho,et al.  Performance of a showcase refrigeration system with multi-evaporator during on–off cycling and hot-gas bypass defrost , 2005 .

[3]  Douglas T. Reindl,et al.  Hot gas defrost model development and validation , 2005 .

[4]  Ju-Suk Byun,et al.  Frost retardation of an air-source heat pump by the hot gas bypass method , 2008 .

[5]  Dong Huang,et al.  Dynamic characteristics of an air-to-water heat pump under frosting/defrosting conditions , 2007 .

[6]  Tae-Hee Lee,et al.  A one-dimensional model for frost formation on a cold flat surface , 1997 .

[7]  Yujiro Hayashi,et al.  Study of Frost Properties Correlating With Frost Formation Types , 1977 .

[8]  Dong Huang,et al.  Comparison between hot-gas bypass defrosting and reverse-cycle defrosting methods on an air-to-water heat pump , 2009 .

[9]  Byungsoon Kim,et al.  Defrosting method adopting dual hot gas bypass for an air-to-air heat pump , 2011 .

[10]  S. Jung,et al.  Payback Period Estimation of Ground-Source and Air-Source Multi Heat Pumps in Korea Based on Yearly Running Cost Simulation , 2010 .

[11]  Kyung-Min Kwak,et al.  A study on the performance enhancement of heat pump using electric heater under the frosting condition: Heat pump under frosting condition , 2010 .

[12]  Dennis L. O'Neal,et al.  Effect of short-tube orifice size on the performance of an air source heat pump during the reverse-cycle defrost , 1991 .

[13]  Wang Zhiyi,et al.  Defrost improvement by heat pump refrigerant charge compensating , 2008 .

[14]  Kamil Kaygusuz.  Performance of an air-to-air heat pump under frosting and defrosting conditions , 1994 .