Large eddy simulation of a bubble column using dynamic sub-grid scale model

Euler–Euler simulations of the gas–liquid flow in a square cross-sectioned bubble column with LES (two sub-grid scale models) and the k–e model are presented. The sub-grid scale modeling is based on the Smagorinsky kernel in both its original form and the dynamic procedure of Germano. The attempt has been made to assess the performance of these two sub-grid scale models. The Smagorinsky model with model constant Cs = 0.12 performs quite well, and gives results almost identical to those given by the dynamic procedure of Germano. The SGS models are modified to account for bubble induced turbulence (Sato model) and it is observed that it does not change the results much. Predictions are also compared with the available experimental data. All the non-drag forces (turbulent dispersion force (only for RANS), virtual mass force, lift force) and drag force were incorporated in the model. An extended k–e turbulence model has been used with extra source terms introduced to account for the interaction between the bubbles and the liquid. Though both LES models showed agreement in predictions, the Germano model still can be used to have estimates of Cs value which are not known a priori. Moreover, if objective is to understand the steady and time averaged features, RANS can also perform well. © 2007 Elsevier B.V. All rights reserved.

[1]  A. Leonard.  Energy Cascade in Large-Eddy Simulations of Turbulent Fluid Flows , 1975 .

[2]  Y. Sato,et al.  Liquid velocity distribution in two-phase bubble flow , 1975 .

[3]  P. Moin,et al.  Numerical investigation of turbulent channel flow , 1981, Journal of Fluid Mechanics.

[4]  Tron Solberg,et al.  Comparison of PIV and LDA Measurement Methods Applied to the Gasliquid Flow in Bubble Column , 2000 .

[5]  I. Žun,et al.  The mechanism of bubble non-homogeneous distribution in two-phase shear flow , 1990 .

[6]  M. Milelli.  A numerical analysis of confined turbulent bubble plumes , 2002 .

[7]  R. Clift,et al.  Bubbles, Drops, and Particles , 1978 .

[8]  M. Duduković,et al.  COMPUTATIONAL MODELING OF GAS-LIQUID FLOW IN BUBBLE COLUMNS , 2004 .

[9]  J. Lumley,et al.  A First Course in Turbulence , 1972 .

[10]  N. Zuber,et al.  Drag coefficient and relative velocity in bubbly, droplet or particulate flows , 1979 .

[11]  B. Smith,et al.  On the modelling of bubble plumes in a liquid pool , 1998 .

[12]  Donald A. Drew,et al.  The virtual mass and lift force on a sphere in rotating and straining inviscid flow , 1987 .

[13]  P. Moin,et al.  A dynamic subgrid‐scale eddy viscosity model , 1990 .

[14]  Gerhart Eigenberger,et al.  Applicability of the standard k–ε turbulence model to the dynamic simulation of bubble columns. Part II:: Comparison of detailed experiments and flow simulations , 1999 .

[15]  M. Lance,et al.  Turbulence in the liquid phase of a uniform bubbly air–water flow , 1991, Journal of Fluid Mechanics.

[16]  J. Smagorinsky,et al.  GENERAL CIRCULATION EXPERIMENTS WITH THE PRIMITIVE EQUATIONS , 1963 .

[17]  H. Werner,et al.  Large-Eddy Simulation of Turbulent Flow Over and Around a Cube in a Plate Channel , 1993 .

[18]  Jam Hans Kuipers,et al.  A three-demensional CFD model for gas-liquid bubble columns , 1999 .

[19]  Hallvard F. Svendsen,et al.  Modeling of Vertical Bubble-Driven Flows , 1997 .

[20]  H. Wagner,et al.  Hydrodynamic simulations of laboratory scale bubble columns fundamental studies of the Eulerian–Eulerian modelling approach , 1999 .

[21]  Donald A. Drew,et al.  Averaged Field Equations for Two‐Phase Media , 1971 .

[22]  Parviz Moin,et al.  Erratum: ‘‘A dynamic subgrid‐scale eddy viscosity model’’ [Phys. Fluids A 3, 1760 (1991)] , 1991 .

[23]  Jyeshtharaj B. Joshi,et al.  Computational flow modelling and design of bubble column reactors , 2001 .

[24]  D. Lilly,et al.  A proposed modification of the Germano subgrid‐scale closure method , 1992 .

[25]  Tron Solberg,et al.  Large eddy simulation of the Gas-Liquid flow in a square cross-sectioned bubble column , 2001 .

[26]  Jyeshtharaj B. Joshi,et al.  CFD simulations of bubble column reactors: 1D, 2D and 3D approach , 2005 .

[27]  G. Eigenberger,et al.  Simulation of Buoyancy Driven Bubbly Flow: Established Simplifications and Open Questions (Journal Review) , 2004 .

[28]  P. Comba,et al.  Part I. Theory , 2007 .

[29]  Knut Bech,et al.  Dynamic simulation of a 2D bubble column , 2005 .

[30]  G. M. Cartland Glover,et al.  The modelling of buoyancy driven flow in bubble columns , 2004 .

[31]  Robert F. Mudde,et al.  Gravity-driven bubbly flows , 2005 .

[32]  Djamel Lakehal,et al.  Large-eddy simulation of bubbly turbulent shear flows , 2002 .