Plasma Engineering of Basal Sulfur Sites on MoS2@Ni3S2 Nanorods for the Alkaline Hydrogen Evolution Reaction

Inexpensive and efficient catalysts are crucial to industrial adoption of the electrochemical hydrogen evolution reaction (HER) to produce hydrogen. Although two‐dimensional (2D) MoS2 materials have large specific surface areas, the catalytic efficiency is normally low. In this work, Ag and other dopants are plasma‐implanted into MoS2 to tailor the surface and interface to enhance the HER activity. The HER activty increases initially and then decreases with increasing dopant concentrations and implantation of Ag is observed to produce better results than Ti, Zr, Cr, N, and C. At a current density of 400 mA cm−2, the overpotential of Ag500‐MoS2@Ni3S2/NF is 150 mV and the Tafel slope is 41.7 mV dec−1. First‐principles calculation and experimental results reveal that Ag has higher hydrogen adsorption activity than the other dopants and the recovered S sites on the basal plane caused by plasma doping facilitate water splitting. In the two‐electrode overall water splitting system with Ag500‐MoS2@Ni3S2/NF, a small cell voltage of 1.47 V yields 10 mA cm−2 and very little degradation is observed after operation for 70 hours. The results reveal a flexible and controllable strategy to optimize the surface and interface of MoS2 boding well for hydrogen production by commercial water splitting.

[1]  P. Chu,et al.  Ni3S2 Nanocomposite Structures Doped with Zn and Co as Long-Lifetime, High-Energy-Density, and Binder-Free Cathodes in Flexible Aqueous Nickel-Zinc Batteries. , 2021, ACS applied materials & interfaces.

[2]  P. Chu,et al.  Experimental and theoretical investigation of the control and balance of active sites on oxygen plasma-functionalized MoSe2 nanosheets for efficient hydrogen evolution reaction , 2021, Applied Catalysis B: Environmental.

[3]  Zhemin Shen,et al.  Distance synergy of single Ag atoms doped MoS2 for hydrogen evolution electrocatalysis , 2021 .

[4]  Hong Zhang,et al.  Atomic Sulfur Filling Oxygen Vacancies Optimizes H Absorption, Boosts Hydrogen Evolution Reaction in Alkaline Media. , 2021, Angewandte Chemie.

[5]  P. Chu,et al.  3D urchin-like NiCo2O4 coated with carbon nanospheres prepared on flexible graphite felt for efficient bifunctional electrocatalytic water splitting , 2021, Journal of Materials Science.

[6]  Yujin Chen,et al.  Ni/MoC heteronanoparticles encapsulated within nitrogen-doped carbon nanotube arrays as highly efficient self-supported electrodes for overall water splitting , 2021 .

[7]  Wenping Sun,et al.  Interface engineering of heterostructured electrocatalysts towards efficient alkaline hydrogen electrocatalysis. , 2020, Science bulletin.

[8]  P. Chu,et al.  Co-doped Ni3S2 porous nanocones as high-performance bifunctional electrocatalysts in water splitting , 2021 .

[9]  Li Xu,et al.  Chromium-modulated multifunctional electrocatalytic activities of spinel oxide for Zn-air batteries and overall water splitting , 2020 .

[10]  Zongping Shao,et al.  Anion Etching for Accessing Rapid and Deep Self-Reconstruction of Precatalysts for Water Oxidation , 2020, Matter.

[11]  Geoffrey I N Waterhouse,et al.  Underwater superaerophobic Ni nanoparticle-decorated nickel–molybdenum nitride nanowire arrays for hydrogen evolution in neutral media , 2020 .

[12]  Z. Tang,et al.  Structural transformation of highly active metal–organic framework electrocatalysts during the oxygen evolution reaction , 2020, Nature Energy.

[13]  M. Koper,et al.  The role of adsorbed hydroxide in hydrogen evolution reaction kinetics on modified platinum , 2020, Nature Energy.

[14]  Huisheng Peng,et al.  High-valence metals improve oxygen evolution reaction performance by modulating 3d metal oxidation cycle energetics , 2020, Nature Catalysis.

[15]  Mao Chen,et al.  Ultrathinning Nickel Sulfide with Modulated Electron Density for Efficient Water Splitting , 2020, Advanced Energy Materials.

[16]  Yibo Dou,et al.  Alkali-Etched Ni(II)-Based Metal-Organic Framework Nanosheet Arrays for Electrocatalytic Overall Water Splitting. , 2020, Small.

[17]  Xinggui Zhou,et al.  Atomic Insights into Robust Pt–PdO Interfacial Site-Boosted Hydrogen Generation , 2020 .

[18]  Dehui Deng,et al.  Boosting hydrogen evolution on MoS2 via co-confining selenium in surface and cobalt in inner layer , 2020, Nature Communications.

[19]  A. W. Maijenburg,et al.  Atomic Layer Deposition of Cobalt Phosphide for Efficient Water Splitting , 2020, Angewandte Chemie.

[20]  Weijia Zhou,et al.  Water Splitting: From Electrode to Green Energy System , 2020, Nano-Micro Letters.

[21]  Yibing Li,et al.  Implanting Ni-O-VOx sites into Cu-doped Ni for low-overpotential alkaline hydrogen evolution , 2020, Nature Communications.

[22]  Wenjun Yan,et al.  O-coordinated W-Mo dual-atom catalyst for pH-universal electrocatalytic hydrogen evolution , 2020, Science Advances.

[23]  J. Greeley,et al.  In-situ structure and catalytic mechanism of NiFe and CoFe layered double hydroxides during oxygen evolution , 2020, Nature Communications.

[24]  X. Xia,et al.  Site-specific electrodeposition enables self-terminating growth of atomically dispersed metal catalysts , 2020, Nature Communications.

[25]  Zhichuan J. Xu,et al.  Surface Composition Dependent Ligand Effect in Tuning the Activity of Nickel-copper Bimetallic Electrocatalysts towards Hydrogen Evolution in Alkaline. , 2020, Journal of the American Chemical Society.

[26]  Jie Yin,et al.  Optimized Metal Chalcogenides for Boosting Water Splitting , 2020, Advanced science.

[27]  P. Chu,et al.  In situ formation of N-doped carbon-coated porous MoP nanowires: a highly efficient electrocatalyst for hydrogen evolution reaction in a wide pH range , 2020 .

[28]  W. Ou,et al.  Two-dimensional ultrathin MoS2-modified black Ti3+–TiO2 nanotubes for enhanced photocatalytic water splitting hydrogen production , 2020 .

[29]  T. Isimjan,et al.  Electron-transfer enhanced MoO2-Ni heterostructures as a highly efficient pH-universal catalyst for hydrogen evolution , 2020, Science China Chemistry.

[30]  Hua Zhang,et al.  Ag@MoS2 Core-Shell Heterostructure as SERS Platform to Reveal the Hydrogen Evolution Active Sites of Single-layer MoS2. , 2020, Journal of the American Chemical Society.

[31]  J. Nan,et al.  Copper and cobalt co-doped Ni3S2 grown on nickel foam for highly efficient oxygen evolution reaction , 2020 .

[32]  P. Chu,et al.  Atomic-scale intercalation of graphene layers into MoSe2 nanoflowers-sheets as a highly efficient catalyst for hydrogen evolution reaction. , 2019, ACS applied materials & interfaces.

[33]  Hong Zhang,et al.  Atomic Arrangement in Metal Doped NiS2 Boosts Hydrogen Evolution Reaction in Alkaline Media. , 2019, Angewandte Chemie.

[34]  Jiaguo Yu,et al.  0D/3D MoS2-NiS2/N-doped graphene foam composite for efficient overall water splitting , 2019, Applied Catalysis B: Environmental.

[35]  K. Uvdal,et al.  MoS2 nanosheets inlaid in 3D fibrous N-doped carbon spheres for lithium-ion batteries and electrocatalytic hydrogen evolution reaction , 2019, Carbon.

[36]  Shan Jiang,et al.  Interface engineering of (Ni, Fe)S2@MoS2 heterostructures for synergetic electrochemical water splitting , 2019, Applied Catalysis B: Environmental.

[37]  P. Chu,et al.  Mo2C/VC heterojunction embedded in graphitic carbon network: An advanced electrocatalyst for hydrogen evolution , 2019, Nano Energy.

[38]  Chen Chen,et al.  Zirconium‐Regulation‐Induced Bifunctionality in 3D Cobalt–Iron Oxide Nanosheets for Overall Water Splitting , 2019, Advanced materials.

[39]  Lichun Dong,et al.  Activating MoS2 with Super-High Nitrogen-Doping Concentration as Efficient Catalyst for Hydrogen Evolution Reaction , 2019, The Journal of Physical Chemistry C.

[40]  Hua Yu,et al.  Boundary activated hydrogen evolution reaction on monolayer MoS2 , 2019, Nature Communications.

[41]  Jaephil Cho,et al.  A Tannic Acid–Derived N‐, P‐Codoped Carbon‐Supported Iron‐Based Nanocomposite as an Advanced Trifunctional Electrocatalyst for the Overall Water Splitting Cells and Zinc–Air Batteries , 2018, Advanced Energy Materials.

[42]  J. Ding,et al.  Hollow Mo-doped CoP nanoarrays for efficient overall water splitting , 2018, Nano Energy.

[43]  Shaojun Guo,et al.  A Universal Strategy for Intimately Coupled Carbon Nanosheets/MoM Nanocrystals (M = P, S, C, and O) Hierarchical Hollow Nanospheres for Hydrogen Evolution Catalysis and Sodium‐Ion Storage , 2018, Advanced materials.

[44]  Yongye Liang,et al.  Molybdenum Phosphide/Carbon Nanotube Hybrids as pH‐Universal Electrocatalysts for Hydrogen Evolution Reaction , 2018 .

[45]  R. Ma,et al.  Unilamellar Metallic MoS2/Graphene Superlattice for Efficient Sodium Storage and Hydrogen Evolution , 2018 .

[46]  Shaojun Guo,et al.  Oxygen Vacancies Dominated NiS2/CoS2 Interface Porous Nanowires for Portable Zn–Air Batteries Driven Water Splitting Devices , 2017, Advanced materials.

[47]  Yi Xie,et al.  3D Nitrogen‐Anion‐Decorated Nickel Sulfides for Highly Efficient Overall Water Splitting , 2017, Advanced materials.

[48]  Wei Wang,et al.  NiO/CoN Porous Nanowires as Efficient Bifunctional Catalysts for Zn-Air Batteries. , 2017, ACS nano.

[49]  Shouheng Sun,et al.  Ni-C-N Nanosheets as Catalyst for Hydrogen Evolution Reaction. , 2016, Journal of the American Chemical Society.

[50]  Moon J. Kim,et al.  Covalent Nitrogen Doping and Compressive Strain in MoS2 by Remote N2 Plasma Exposure. , 2016, Nano letters.

[51]  Xinwei Wang,et al.  Vapor-Phase Atomic Layer Deposition of Nickel Sulfide and Its Application for Efficient Oxygen-Evolution Electrocatalysis , 2016 .

[52]  M. Kanatzidis,et al.  Design of active and stable Co-Mo-Sx chalcogels as pH-universal catalysts for the hydrogen evolution reaction. , 2016, Nature materials.

[53]  H. Fei,et al.  Edge‐Oriented MoS2 Nanoporous Films as Flexible Electrodes for Hydrogen Evolution Reactions and Supercapacitor Devices , 2014, Advanced materials.