Effect of sodium dodecyl sulfate on waste activated sludge hydrolysis and acidification

Abstract The effect of sodium dodecyl sulfate (SDS) on hydrolysis and acidification of waste activated sludge (WAS) was investigated, which has not been documented in the literature. Results showed that SDS improved the solubility of protein and carbohydrate in aqueous phase, and the concentrations of these two substrates increased with the amount of SDS. On the second day of fermentation the enzyme activities of protease and alkaline phosphatase were improved by SDS with its dosage in the range of 0.02–0.3 g/g, but the activities of α-glucosidase and acidic phosphatase decreased at SDS dosage above 0.05 and 0.2 g/g, respectively. The volatile fatty acids (VFAs) production was also enhanced by SDS under room temperature. On the sixth day of fermentation, concentration of total VFAs was 2243.04 mg COD/L at SDS dosage 0.1 g/g, while it was only 191.10 mg COD/L in the blank test. The maximum VFAs production increased with the amount of SDS. However, longer time was needed for WAS treated with higher SDS dosage to reach its own maximum VFAs production. The composition of VFAs was analyzed, and acetic acid was observed the most prevalent product. Further studies showed that methanogenesis was inhibited in the presence of SDS. Almost the same pH variations in the presence and absence of SDS indicated that the improvement of VFAs production and inhibition of methane production in WAS fermentation was more due to the effects of SDS than due to the variations of pH.

[1]  G. Gu,et al.  Effect of acid and surfactant treatment on activated sludge dewatering and settling. , 2001, Water research.

[2]  Hong Liu,et al.  Extraction of extracellular polymeric substances (EPS) of sludges. , 2002, Journal of biotechnology.

[3]  Qunhui Wang,et al.  Degradation of volatile fatty acids in highly efficient anaerobic digestion , 1999 .

[4]  T. Mino,et al.  Enzyme activities under anaerobic and aerobic conditions in activated sludge sequencing batch reactor , 1998 .

[5]  W. Gujer,et al.  Intracellular carbon flow in phosphorus accumulating organisms from activated sludge systems , 1997 .

[6]  Jian Chen,et al.  Recovery of poly-3-hydroxybutyrate from Alcaligenes eutrophus by surfactant–chelate aqueous system , 1999 .

[7]  W. Owen,et al.  Fundamentals of Anaerobic Digestion of Wastewater Sludges , 1986 .

[8]  Shuzo Tanaka,et al.  Effects of Photolytic Pretreatment on Biodegradation and Detoxification of Surfactants in Anaerobic Digestion , 1993 .

[9]  G. Zeeman,et al.  The role of sludge retention time in the hydrolysis and acidification of lipids, carbohydrates and proteins during digestion of primary sludge in CSTR systems , 2000 .

[10]  D. Wareham,et al.  Use of volatile fatty acids from an acid-phase digester for denitrification. , 2004, Journal of biotechnology.

[11]  A. R. Pitman,et al.  Fermentation of Raw Sludge and Elutriation of Resultant Fatty Acids to Promote Excess Biological Phosphorus Removal , 1992 .

[12]  P. Elefsiniotis,et al.  Anaerobic acidogenesis of primary sludge: The role of solids retention time , 1994, Biotechnology and bioengineering.

[13]  G. Gu,et al.  High-rate anaerobic hydrolysis and acidogenesis of sewage sludge in a modified upflow reactor. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[14]  T. Mino,et al.  Sludge hydrolysate as a carbon source for denitrification. , 2001, Water science and technology : a journal of the International Association on Water Pollution Research.

[15]  Andrew A Randall,et al.  The efficiency of enhanced biological phosphorus removal from real wastewater affected by different ratios of acetic to propionic acid. , 2004, Water research.

[16]  Gary A. Pope,et al.  Measurement of mass-transfer rates for surfactant-enhanced solubilization of nonaqueous phase liquids , 1999 .

[17]  J. Ferguson,et al.  Solubilization of particulate organic carbon during the acid phase of anaerobic digestion , 1981 .

[18]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[19]  W. Verstraete,et al.  Evaluation of current wet sludge disintegration techniques , 1998 .

[20]  C. Forster,et al.  An examination of the effects of detergents on anaerobic digestion. , 2003, Bioresource technology.

[21]  Yinguang Chen,et al.  Influence of pretreating activated sludge with acid and surfactant prior to conventional conditioning on filtration dewatering , 2004 .

[22]  O. H. Lowry,et al.  Protein measurement with the Folin phenol reagent. , 1951, The Journal of biological chemistry.

[23]  D. Lloyd,et al.  The effects of detergents on anaerobic digestion , 1988, Applied Microbiology and Biotechnology.

[24]  Aaron Marc Saunders,et al.  Enhanced biological phosphorus removal in a sequencing batch reactor using propionate as the sole carbon source , 2004, Biotechnology and bioengineering.

[25]  M. N. Jones,et al.  The biodegradation of surfactants in the environment. , 2000, Biochimica et biophysica acta.

[26]  H. Feitkenhauer.  ANAEROBIC DIGESTION OF DESIZING WASTEWATER: INFLUENCE OF PRETREATMENT AND ANIONIC SURFACTANT ON DEGRADATION AND INTERMEDIATE ACCUMULATION , 2003 .

[27]  H. Siegrist,et al.  Products from primary sludge fermentation and their suitability for nutrient removal , 1998 .

[28]  Shuzo Tanaka,et al.  Effects of thermochemical pretreatment on the anaerobic digestion of waste activated sludge , 1997 .

[29]  Maria A M Reis,et al.  Synthesis of polyhydroxyalkanoates from different short-chain fatty acids by mixed cultures submitted to aerobic dynamic feeding. , 2006, Journal of biotechnology.

[30]  A. Charlier,et al.  Primary fermentation of soluble and particulate organic matter for wastewater treatment , 1994 .

[31]  J. A. Hudson,et al.  Treatment and Disposal of Sewage Sludge in the Mid-1990s , 1995 .

[32]  C. W. Randall,et al.  The Effect of Organic Compounds on Biological Phosphorus Removal , 1991 .