A computational study of the flow around an isolated wheel in contact with the ground

The flow around an isolated wheel in contact with the ground is computed by the Unsteady Reynolds-Averaged Navier-Stokes (URANS) method. Two cases are considered, a stationary wheel on a stationary ground and a rotating wheel on a moving ground. The computed wheel geometry is a detailed and accurate representation of the geometry used in the experiments of Fackrell and Harvey. The time-averaged computed flow is examined to reveal both new flow structures and new details of flow structures known from previous experiments. The mechanisms of formation of the flow structures are explained. A general schematic picture of the flow is presented. Surface pressures and pressure lift and drag forces are computed and compared to experimental results and show good agreement. The grid sensitivity of the computations is examined and shown to be small. The results have application to the design of road vehicles.

[1]  Philippe R. Spalart,et al.  Detached-Eddy Simulations Over a Simplified Landing Gear , 2002 .

[2]  T. Shih,et al.  A new k-ϵ eddy viscosity model for high reynolds number turbulent flows , 1995 .

[3]  E. Mercker,et al.  On the Aerodynamic Interference Due to the Rolling Wheels of Passenger Cars , 1991 .

[4]  Robert Dominy,et al.  The Air Flow About an Exposed Racing Wheel , 2002 .

[5]  P. W. Bearman,et al.  The Effect of a Moving Floor on Wind-Tunnel Simulation of Road Vehicles , 1988 .

[6]  Gunther Ramm,et al.  Some salient features of the time - averaged ground vehicle wake , 1984 .

[7]  Savill,et al.  Formula 1 car wheel aerodynamics , 1999 .

[8]  R. Martinuzzi,et al.  Energy balance for turbulent flow around a surface mounted cube placed in a channel , 1996 .

[9]  Jochen Wiedemann,et al.  Flow around an Isolated Wheel - Experimental and Numerical Comparison of Two CFD Codes , 2004 .

[10]  John Edward Fackrell,et al.  The aerodynamics of an isolated wheel rotating in contact with the ground. , 1974 .

[11]  T. Han,et al.  Computational analysis of three-dimensional turbulent flow around a bluff body in ground proximity , 1988 .

[12]  Jeff Howell,et al.  An evaluation of CFD for modelling the flow around stationary and rotating isolated wheels , 1998 .

[13]  Lee Axon,et al.  The aerodynamic characteristics of automobile wheels - CFD prediction and wind tunnel experiment , 1999 .

[14]  Robert Dominy,et al.  An Investigation into the Flow-Field About an Exposed Racing Wheel , 2004 .

[15]  Lars Davidson,et al.  Numerical Study of the Flow Around a Bus-Shaped Body , 2003 .

[16]  P M Nelson,et al.  QUIETER ROAD SURFACES , 1998 .

[17]  Sinisa Krajnovic,et al.  Large-Eddy Simulation of the Flow Around a Bluff Body , 2002 .

[18]  Ben Agathangelou,et al.  Aerodynamic Design Considerations of a Formula 1 Racing Car , 1998 .

[19]  P. Spalart.  A One-Equation Turbulence Model for Aerodynamic Flows , 1992 .

[20]  C. Tropea,et al.  The Flow Around Surface-Mounted, Prismatic Obstacles Placed in a Fully Developed Channel Flow (Data Bank Contribution) , 1993 .

[21]  P. R. Bullen,et al.  CFD Simulations and Experimental Measurements of the Flow Over a Rotating Wheel in a Wheel Arch , 2000 .