Transport limitations in ion exchange membranes at low salt concentrations

In this work we show that the electrical resistance of ion exchange membranes strongly depends on the solution concentration: especially at low solution concentrations (<0.1 M NaCl) we observe a very strong increase in electrical resistance of the membrane with decreasing concentration. To understand and clarify this behavior we systematically investigate the influence of the solution concentration on ion transport phenomena in two anion exchange membranes (Neosepta AMX and Fumasep FAD) and two cation exchange membranes (Neosepta CMX and Fumasep FKD) in the concentration range from 0.017 M to 0.5 M NaCl and for different hydrodynamic conditions. The results are highly valuable for processes that operate in the low concentration range (<0.5 M) such as reverse electrodialysis, electrodialysis, microbial fuel cells and capacitive deionization, where the standard membrane characterization values as usually determined in 0.5 M NaCl solutions do not represent the practical application.

[1]  Victor Nikonenko,et al.  Effect of structural membrane inhomogeneity on transport properties , 1993 .

[2]  R. Audinos,et al.  Characterization of electrodialysis membranes by chronopotentiometry , 1988 .

[3]  Matthias Wessling,et al.  Chronopotentiometry for the advanced current–voltage characterisation of bipolar membranes , 2001 .

[4]  G. Pourcelly,et al.  Chronopotentiometric response of a cation exchange membrane in contact with chromium(III) solutions , 1996 .

[5]  C. Buess-Herman,et al.  Study of water content and microheterogeneity of CMS cation exchange membrane , 2007 .

[6]  J. Weinstein,et al.  Electric Power from Differences in Salinity: The Dialytic Battery , 1976, Science.

[7]  Hubertus V. M. Hamelers,et al.  Performance of non-porous graphite and titanium-based anodes in microbial fuel cells , 2008 .

[8]  O. Kedem,et al.  Role of the membrane surface in concentration polarization at ion-exchange membrane , 1988 .

[9]  E. Staude,et al.  Ion transfer across electrodialysis membranes in the overlimiting current range: chronopotentiometric studies , 1992 .

[10]  Matthias Wessling,et al.  Multi-layer spacer geometries with improved mass transport , 2006 .

[11]  Joseph Jagur-Grodzinski,et al.  Novel process for direct conversion of free energy of mixing into electric power , 1986 .

[12]  Electric power produced from two solutions of unequal salinity by reverse electrodialysis , 1992 .

[13]  Jae-Hwan Choi,et al.  An approach to fouling characterization of an ion-exchange membrane using current-voltage relation and electrical impedance spectroscopy. , 2006, Journal of colloid and interface science.

[14]  R. Lacey.  Energy by reverse electrodialysis , 1980 .

[15]  Marian Turek,et al.  Power production from coal-mine brine utilizing reversed electrodialysis , 2008 .

[16]  M Wessling,et al.  Morphology and microtopology of cation-exchange polymers and the origin of the overlimiting current. , 2007, The journal of physical chemistry. B.

[17]  S M Rubinstein,et al.  Direct observation of a nonequilibrium electro-osmotic instability. , 2008, Physical review letters.

[18]  R. E. Pattle.  Production of Electric Power by mixing Fresh and Salt Water in the Hydroelectric Pile , 1954, Nature.

[19]  C. Buess-Herman,et al.  Properties of CMV cation exchange membranes in sulfuric acid media , 2006 .

[20]  Matthias Wessling,et al.  Cation permeable membranes from blends of sulfonated poly(ether ether ketone) and poly(ether sulfone) , 2002 .

[21]  Matthias Wessling,et al.  Current status of ion exchange membranes for power generation from salinity gradients , 2008 .

[22]  G. Pourcelly,et al.  Chronopotentiometric response of an ion-exchange membrane in the underlimiting current-range. Transport phenomena within the diffusion layers , 1997 .

[23]  Matthias Wessling,et al.  Chronopotentiometry and overlimiting ion transport through monopolar ion exchange membranes , 1999 .

[24]  J. Veerman,et al.  Reducing power losses caused by ionic shortcut currents in reverse electrodialysis stacks by a validated model , 2008 .

[25]  F. Harnisch,et al.  The suitability of monopolar and bipolar ion exchange membranes as separators for biological fuel cells. , 2008, Environmental science & technology.

[26]  Matthias Wessling,et al.  Role of membrane surface in concentration polarization at cation exchange membranes , 2004 .

[27]  Jae-Hwan Choi,et al.  Direct measurement of concentration distribution within the boundary layer of an ion-exchange membrane. , 2002, Journal of colloid and interface science.

[28]  Stefano Freguia,et al.  Microbial fuel cells: methodology and technology. , 2006, Environmental science & technology.

[29]  C. Larchet,et al.  Comparative Study of Methods Used for the Determination of Electroconductivity of Ion-Exchange Membranes , 2001 .

[30]  Matthias Wessling,et al.  Concentration polarization with monopolar ion exchange membranes: current-voltage curves and water dissociation , 1999 .

[31]  F. Suda,et al.  Transient changes in the power output from the concentration difference cell (dialytic battery) between seawater and river water , 2007 .

[32]  H. Hamelers,et al.  Effects of membrane cation transport on pH and microbial fuel cell performance. , 2006, Environmental science & technology.

[33]  I. Rubinstein,et al.  Polarization effects at charged membranes. , 1983 .

[34]  J. Post,et al.  Salinity-gradient power : Evaluation of pressure-retarded osmosis and reverse electrodialysis , 2007 .

[35]  A. Yamauchi,et al.  Ion transport behavior in diffusion layer of new designed ion exchange-mosaic composite polymer membrane , 2006 .

[36]  J. Balster,et al.  Preparation and characterisation of monovalent ion selective cation exchange membranes based on sulphonated poly(ether ether ketone) , 2005 .

[37]  Jae-Hwan Choi,et al.  An electrical impedance spectroscopic (EIS) study on transport characteristics of ion-exchange membrane systems. , 2006, Journal of colloid and interface science.

[38]  K. Urano,et al.  Electric resistances of ion-exchange membranes in dilute solutions , 1986 .