Investigations of suction caissons in dense sand

Offshore structures are used in a variety of applications ranging from the traditional oil and gas extraction facilities to emerging renewable energy concepts. These structures must be secured to the seabed in an efficient and cost effective manner. A novel approach is to use shallow inverted buckets as foundations, installed by suction, in place of the more usual piles. These foundations lead to cost savings through reduction in materials and in time required for installation. It is necessary to determine how these foundations perform under typical offshore loading conditions so that design calculations may be developed. This thesis presents experimental data from a comprehensive series of investigations aimed at determining the important mechanisms to consider in the design of these shallow foundations for dense sand. Initially the long term loading behaviour (e.g. wind and current) was investigated by conducting three degree of freedom loading {V:M/2R:H} tests on a foundation embedded in dry sand. The results were interpreted through existing work-hardening plasticity theories. The analysis of the data has suggested a number of improved modelling features. Cyclic and transient tests, representing wave loading, were carried out on a foundation embedded in an oil saturated sand. The novel feature of the cyclic loading was that a 'pseudo-random' load history (based on the 'NewWave' theory) was used to represent realistic loading paths. Of particular interest was the tensile load capacity of the foundation. The results observed suggested that for tensile loading serviceability requirements rather than capacity may govern design. Under combined-load cyclic conditions the results indicated that conventional plasticity theory would not provide a sufficient description of response. A new theory, termed 'continuous hyperplasticity' was used, reproducing the results with impressive accuracy. Surprisingly, under the conditions investigated, loading rate was found to have a negligible effect on response.

[1]  E. Beer,et al.  Experimental Determination of the Shape Factors and the Bearing Capacity Factors of Sand , 1970 .

[2]  T. I. Tjelta,et al.  Large-Scale Penetration Test At A Deepwater Site , 1986 .

[3]  Samy Alhayari,et al.  Innovative Developments in Suction Pile Technology , 1998 .

[4]  L. Borgman,et al.  Ocean wave simulation for engineering design , 1967 .

[5]  K. Terzaghi.  Theoretical Soil Mechanics , 1943 .

[6]  Lidija Zdravković,et al.  Pull-out Capacity of Bucket Foundations in Soft Clay , 2001 .

[7]  Denis Senpere,et al.  Suction Anchor Piles - A Proven Alternative to Driving or Drilling , 1982 .

[8]  Charles L. Bretschneider,et al.  Wave variability and wave spectra for wind generated gravity waves , 1959 .

[9]  C. Chimisso,et al.  Deepwater FPSO for Aquila Field Development in the Adriatic , 1998 .

[10]  C. T. Erbrich,et al.  Installation of Bucket Foundations and Suction Caissons in Sand - Geotechnical Performance , 1999 .

[11]  F. Myrvoll.  INSTRUMENTATION OF THE SKIRT FILED GULLFAKS C GRAVITY PLATFORM FOR PERFORMANCE MONITORING , 1992 .

[12]  Hans Petter Jostad,et al.  Foundation design of skirted foundations and anchors in clay , 1999 .

[13]  T. I. Tjelta.  Geotechnical Experience from the Installation of the Europipe Jacket with Bucket Foundations , 1995 .

[14]  Tor Inge Tjelta,et al.  Development and Structural Design of the Bucket Foundations for the Europipe Jacket , 1995 .

[15]  S. L. Anderson,et al.  STATISTICAL LINEARIZATION OF VELOCITY-SQUARED DRAG FORCES , 1986 .

[16]  K Hoeg,et al.  PROBABILISTIC CONSIDERATIONS IN THE FOUNDATION ENGINEERING FOR OFFSHORE STRUCTURES , 1978 .

[17]  Mark Randolph,et al.  Shallow foundations subject to combined loadings , 1997 .

[18]  P. S. Tromans,et al.  VALIDATION OF 'NEWWAVE' THEORY AND RDWF PREDICTIONS AGAINST MEASURED GLOBAL LOADING ON A NORTH SEA JACKET , 1992 .

[19]  T I Tjelta,et al.  FOUNDATION DESIGN FOR DEEPWATER GRAVITY BASE STRUCTURE WITH LONG SKIRTS ON SOFT SOILS , 1988 .

[20]  Mark Randolph,et al.  H-adaptive FE Analysis of Bearing Capacity of Skirted Foundations , 1998 .

[21]  K Hoeg,et al.  SOIL-STRUCTURE INTERACTION ANALYSIS OF EMBEDDED CAISSON ANCHOR UNDER TENSION LOAD , 1994 .

[22]  N H Christensen,et al.  A Computer Program To Analyze Suction Effects , 1992 .

[23]  Michael J. Morrison,et al.  A Centrifuge and Analytical Study to Evaluate Suction Caissons for TLP Applications in the Gulf of Mexico , 1993 .

[24]  H. Poulos,et al.  Elastic solutions for soil and rock mechanics , 1973 .

[25]  V. A. Nacci,et al.  Applications of Suction Anchors in Offshore Technology , 1978 .

[26]  Roy E. Olson,et al.  Laboratory Modeling of Suction Caisson Foundations , 1998 .

[27]  G. Lindgren,et al.  Some Properties of a Normal Process Near a Local Maximum , 1970 .

[28]  V. A. Nacci,et al.  Breakout capacity of model suction anchors in soil , 1977 .

[29]  Gregory B. Baecher,et al.  Uncertainty in Bearing Capacity of Sands , 1983 .

[30]  Paul H. Wirsching,et al.  Fatigue under Wide Band Random Stresses , 1980 .

[31]  Mark Randolph,et al.  A yield envelope design approach for caisson foundations in calcareous sediments , 1997 .

[32]  Alexander M. Puzrin,et al.  A thermomechanical framework for constitutive models for rate-independent dissipative materials , 2000 .

[33]  T. Simon,et al.  Centrifuge And Numerical Modelling of Horizontally Loaded Suction Piles , 1999 .

[34]  Tor-lnge Tjelta.  GEOTECHNICAL ASPECTS OF BUCKET FOUNDATIONS REPLACING PILES FOR THE EUROPIPE 16/11-E JACKET , 1994 .

[35]  C. Ganapathy,et al.  Pullout behavior of model suction anchors in soft marine clays , 1997 .

[36]  Alexander M. Puzrin,et al.  A thermomechanical framework for rate-independent dissipative materials with internal functions , 2001 .

[37]  G. Masing,et al.  Eigenspannungen und Verfestigung beim Messing , 1926 .

[38]  E. C. Clukey,et al.  The response of suction caissons in normally consolidated clays to cyclic TLP loading conditions , 1995 .

[39]  T. S. Ølberg,et al.  Field trial for taut leg moorings , 1997 .

[40]  Jean H. Prevost,et al.  MATHEMATICAL MODELLING OF MONOTONIC AND CYCLIC UNDRAINED CLAY BEHAVIOUR , 1977 .

[41]  Mladen Vucetic,et al.  DEGRADATION OF MARINE CLAYS UNDER CYCLIC LOADING , 1988 .

[42]  S. Narasimha Rao,et al.  Pullout behavior of suction anchors in soft marine clays , 1997 .

[43]  H. R. Wassink,et al.  The statistics of the extreme response of offshore structures , 1992 .

[44]  Mark Randolph,et al.  Limiting aspect ratio for suction caisson installation in clay , 1999 .

[45]  L. Prandtl,et al.  Hauptaufsätze: Über die Eindringungsfestigkeit (Härte) plastischer Baustoffe und die Festigkeit von Schneiden , 1921 .

[46]  Mark Randolph,et al.  Failure envelopes for caisson foundations in calcareous sediments , 1998 .

[47]  J. D. Steensen-Bach.  Recent Model Tests With Suction Piles in Clay and Sand , 1992 .

[48]  K. H. Andersen,et al.  Skirted foundations for offshore structures , 1993 .

[49]  J. B. Hansen,et al.  A general formula for bearing capacity , 1961 .

[50]  W. Pierson,et al.  A proposed spectral form for fully developed wind seas based on the similarity theory of S , 1964 .

[51]  Roy E. Olson,et al.  The Pullout Capacity of Suction Caisson Foundations For Tension Leg Platforms , 1998 .

[52]  J. Hogervorst,et al.  Field Trails With Large Diameter Suction Piles , 1980 .

[53]  E. Buckingham.  On Physically Similar Systems; Illustrations of the Use of Dimensional Equations , 1914 .

[54]  Guido Gottardi,et al.  ON THE BEARING CAPACITY OF SURFACE FOOTINGS ON SAND UNDER GENERAL PLANAR LOADS , 1993 .

[55]  Paul M. Hagemeijer,et al.  A New Model For The Kinematics Of Large Ocean Waves-Application As a Design Wave , 1991 .

[56]  Magued Iskander,et al.  Application of suction caisson foundations in the Gulf of Mexico , 1998 .

[57]  C. Madshus,et al.  Horizontal capacity of large-scale model anchors , 1996 .

[58]  M. Baerheim,et al.  Design, operations planning and experience from the marine operations for the Europipe jacket with bucket foundations , 1995 .

[59]  Wilfred D. Iwan,et al.  On a Class of Models for the Yielding Behavior of Continuous and Composite Systems , 1967 .

[60]  T. I. Tjelta,et al.  Geotechnical Design of Bucket Foundations , 1995 .

[61]  Martin S. Williams,et al.  Development of non-linear numerical models appropriate for the analysis of jack-up units , 1996 .

[62]  Guido Gottardi,et al.  Plastic response of circular footings on sand under general planar loading , 1999 .

[63]  B Andreasson,et al.  FIELD MODEL TESTS AND ANALYSES OF SUCTION INSTALLED LONG-SKIRTED FOUNDATIONS , 1988 .

[64]  Knut H. Andersen,et al.  PULL-OUT CAPACITY ANALYSES OF SUCTION ANCHORS FOR TENSION LEG PLATFORMS , 1992 .

[65]  Magued Iskander,et al.  AXIAL CAPACITY OF SUCTION PILES IN SAND , 1994 .

[66]  I. K. Suastika.  Ringing of Gravity Base Structures , 1997 .

[67]  Mark Randolph,et al.  Finite element modelling of skirted strip footings subject to combined loading , 1997 .

[68]  Wai-Fah Chen,et al.  Bearing Capacity of Shallow Foundations , 1991 .

[69]  A Bezuijen,et al.  OFFSHORE SKIRT PENETRATION IN CLAY IN THE GEO-CENTRIFUGE , 1992 .

[70]  J. Hermstad,et al.  Concrete anchors for offshore mooring systems , 1993 .

[71]  R Renzi,et al.  MODELLING THE BEHAVIOUR OF SKIRT PILES , 1994 .

[72]  M. Efthymiou,et al.  EXTREME STORM LOADING ON FIXED OFFSHORE PLATFORMS , 1992 .

[73]  A. Eide,et al.  The Yme Jack-Up with Skirt Foundation , 1996 .

[74]  J. L. Mitcha,et al.  The Heidrun Field - Development Overview , 1996 .

[75]  M. Longuet-Higgins,et al.  The statistical distribution of the maxima of a random function , 1956, Proceedings of the Royal Society of London. Series A. Mathematical and Physical Sciences.

[76]  C. K. Lau,et al.  Scale effects in tests on footings , 1988 .

[77]  Mladen Vucetic,et al.  Normalized behavior of clay under irregular cyclic loading , 1990 .

[78]  Malcolm D. Bolton,et al.  Vertical bearing capacity factors for circular and strip footings on Mohr–Coulomb soil , 1993 .

[79]  Guido Gottardi,et al.  Standardized sign conventions and notation for generally loaded foundations , 1997 .

[80]  Bjørn Kalsnes,et al.  Soil Parameters for Design of Suction Caissons for Gulf of Mexico Deepwater Clays , 1998 .

[81]  S Bysveen,et al.  INNOVATIVE FOUNDATION SYSTEMS SELECTED FOR THE SNORRE FIELD DEVELOPMENT , 1992 .

[82]  Michael C. Georgiadis,et al.  DISPLACEMENTS OF FOOTINGS ON SAND UNDER ECCENTRIC AND INCLINED LOADS , 1988 .

[83]  C. P. Wroth.  Soil mechanics, property characterisation and analysis , 1985 .

[84]  Aleksandar S. Vesic,et al.  Analysis of Ultimate Loads of Shallow Foundations , 1973 .

[85]  R. Pyke,et al.  NONLINEAR SOIL MODELS FOR IRREGULAR CYCLIC LOADINGS , 1979 .

[86]  Jan Krishna Mangal.  Partially-drained loading of shallow foundations on sand , 1999 .

[87]  J. Ewing,et al.  Directional Wave Spectra Observed during JONSWAP 1973 , 1980 .

[88]  P. S. Tromans,et al.  Response based design conditions in the North Sea: Application of a new method , 1995 .

[89]  T. I. Tjelta,et al.  Analyses of skirted foundations and anchors in sand subjected to cyclic loading , 1997 .

[90]  M. Randolph,et al.  Performance of Suction Anchors in Fine-Grained Calcareous Soils , 1998 .

[91]  Mark Randolph,et al.  Vertical Capacity of Caisson Foundations In Calcareous Sediments , 1997 .

[92]  Steinar Bysveen,et al.  Field tests of anchors in clay. II: Predictions and interpretation , 1993 .

[93]  P. Boisard,et al.  Caisson Foundations as Alternative Anchors for Permanent Mooring of a Process Barge Offshore Congo , 1995 .

[94]  Ian Burgess,et al.  Stability of installation of marine caisson anchors in clay , 1983 .

[95]  Mark Randolph,et al.  Skirted foundations in calcareous soil , 1998 .

[96]  D. Hagen,et al.  Innovative Suction Anchor Design and Installation , 1998 .

[97]  P H Taylor.  ON THE KINEMATICS OF LARGE OCEAN WAVES , 1992 .

[98]  Chris Martin.  Physical and numerical modelling of offshore foundations under combined loads , 1994 .

[99]  Leon Emry Borgman,et al.  Spectral Analysis of Ocean Wave Forces on Piling (Coastal Engineering Conference in Santa Barbara, California, October 1965) , 1967 .

[100]  N. Barltrop,et al.  Dynamics of Fixed Marine Structures , 1991 .

[101]  Philip Jonathan,et al.  TIME DOMAIN SIMULATION OF JACK-UP DYNAMICS WITH THE EXTREMES OF A GAUSSIAN PROCESS , 1997 .

[102]  P. Boisard,et al.  Design and Installation of Suction Anchor Piles at a Soft Clay Site in the Gulf of Guinea , 1996 .

[103]  E. Solhjell,et al.  Comparison and Back Calculation of Penetration Resistance From Subtion Anchor Installation In Soft To Stiff Clay At The Njord And Visund Fields In The North Sea , 1998 .

[104]  Stein Ølberg,et al.  Full Scale Field Trial of Taut Leg Mooring using Fiber Rope and Suction Anchor attached to a Semi-Submersible Drilling Unit , 1997 .

[105]  Guy T. Houlsby,et al.  Application of thermomechanical principles to the modelling of geotechnical materials , 1997, Proceedings of the Royal Society of London. Series A: Mathematical, Physical and Engineering Sciences.

[106]  P. Larsen.  Suction Anchors as an Anchoring System for Floating ,Offshore Constructions , 1989 .

[107]  Cong Luan Ngo-Tran.  The analysis of offshore foundations subjected to combined loading , 1996 .

[108]  David W. Clarke,et al.  Generalized predictive control - Part I. The basic algorithm , 1987, Autom..

[109]  R. Jonsrud,et al.  Instrumentation for monitoring the installation and performance of the concrete foundation templates for the Snorre tension leg platform , 1993 .

[110]  J. R. Morison,et al.  The Force Exerted by Surface Waves on Piles , 1950 .

[111]  S. Fines,et al.  Snorre TLP Tethers and Foundation , 1991 .

[112]  A. N. Schofield,et al.  THE BEARING CAPACITY OF CONICAL FOOTINGS ON SAND IN RELATION TO THE BEHAVIOUR OF SPUDCAN FOOTINGS OF JACKUPS , 1993 .

[113]  Guy T. Houlsby,et al.  Investigations of suction caissons in dense sand , 2000 .

[114]  Bin Teng,et al.  The wave-current force spectrum on inclined cylinders , 1991 .

[115]  Harvey J. Burd,et al.  Numerical studies of bearing-capacity factor Nγ , 1997 .

[116]  Guido Gottardi,et al.  A complete three-dimensional failure envelope for shallow footings on sand , 1994 .

[117]  R. O. Davis,et al.  DILATION-INDUCED PORE FLUID CAVITATION IN SANDS , 1997 .

[118]  O. J. StlfWe,et al.  New Foundation Systems for the Snorre Development , 1992 .

[119]  Knut H. Andersen,et al.  Foundation engineering for offshore gravity structures , 1979 .