Radiation Hardness Comparison of CMOS Image Sensor Technologies at High Total Ionizing Dose Levels

The impact of the manufacturing process on the radiation-induced degradation effects observed in CMOS image sensors (CISs) at the MGy total ionizing dose (TID) levels is investigated. Moreover, the vulnerability of the partially pinned PHDs at moderate-to-high TIDs is evaluated for the first time to our knowledge (PHD stands for “photodiode”). It is shown that the 3T-standard partially pinned PHD has the lowest dark current before irradiation, but its dark current increases to ~1 pA at 10 kGy(SiO2). Beyond 10 kGy(SiO2), the pixel functionality is lost. The comparison between several CIS technologies points out that the manufacturing process impacts the two main radiation-induced degradations: the threshold voltage shift of the readout chain MOSFETs and the dark current increase. For all the tested technologies, 1.8-V MOSFETs exhibit the lower threshold voltage shift, and the nMOSFETs are the most radiation tolerant. Among all the tested devices, 1.8-V sensors achieve the best dark current performance. Several radiation-hardening-by-design solutions are evaluated at the MGy level to improve further the understanding of CIS radiation hardening at extreme TID.

[1]  Guang Yang,et al.  Multi-megarad (Si) radiation-tolerant integrated CMOS imager , 2001, IS&T/SPIE Electronic Imaging.

[2]  R. Harboe-Sorensen,et al.  Radiation effects on a radiation-tolerant CMOS active pixel sensor , 2004, IEEE Transactions on Nuclear Science.

[3]  Andrew Holland,et al.  Gamma radiation damage study of 0.18 µm process CMOS image sensors , 2010, Astronomical Telescopes + Instrumentation.

[4]  P. Magnan,et al.  Dark Current Sharing and Cancellation Mechanisms in CMOS Image Sensors Analyzed by TCAD Simulations , 2017, IEEE Transactions on Electron Devices.

[5]  Federico Faccio,et al.  Radiation tolerant VLSI circuits in standard deep submicron CMOS technologies for the LHC experiments: practical design aspects , 1999 .

[6]  Albert J. P. Theuwissen,et al.  Degradation of CMOS image sensors in deep-submicron technology due to γ-irradiation , 2008 .

[7]  P. Paillet,et al.  Analysis of Total Dose-Induced Dark Current in CMOS Image Sensors From Interface State and Trapped Charge Density Measurements , 2010, IEEE Transactions on Nuclear Science.

[8]  B. Dierickx,et al.  Total dose and displacement damage effects in a radiation-hardened CMOS APS , 2003 .

[9]  G. Hopkinson.  Radiation effects in a CMOS active pixel sensor , 2000 .

[10]  Olivier Marcelot,et al.  Total Ionizing Dose Effects on a Radiation-Hardened CMOS Image Sensor Demonstrator for ITER Remote Handling , 2018, IEEE Transactions on Nuclear Science.

[11]  A. J. P. Theuwissen,et al.  Analyzing the Radiation Degradation of 4-Transistor Deep Submicron Technology CMOS Image Sensors , 2012, IEEE Sensors Journal.

[12]  Donald B. Hondongwa,et al.  A Review of the Pinned Photodiode for CCD and CMOS Image Sensors , 2014, IEEE Journal of the Electron Devices Society.

[13]  P. Magnan,et al.  Generic Radiation Hardened Photodiode Layouts for Deep Submicron CMOS Image Sensor Processes , 2011, IEEE Transactions on Nuclear Science.

[14]  Romain Molina,et al.  Influence of Transfer Gate Design and Bias on the Radiation Hardness of Pinned Photodiode CMOS Image Sensors , 2014, IEEE Transactions on Nuclear Science.

[16]  Bedabrata Pain,et al.  Hardening CMOS imagers: radhard-by-design or radhard-by-foundry , 2004, SPIE Optics + Photonics.

[17]  G. Cervelli,et al.  Radiation-induced edge effects in deep submicron CMOS transistors , 2005, IEEE Transactions on Nuclear Science.

[18]  A. Smolin,et al.  Investigation of Nonuniform Degradation of CMOS-Sensor Light-Sensitive Surface under Gamma-Irradiation , 2015, 2015 15th European Conference on Radiation and Its Effects on Components and Systems (RADECS).