A phenomenological model of the mechanisms of lignocellulosic biomass pyrolysis processes

Abstract A comprehensive particle scale model for pyrolysis of biomass has been developed by coupling the reaction mechanisms and transport phenomena. The model, which also accounts for the combined effect of various parameters such as particle shrinkage and drying, was validated using available experimental data from the literature. The validated model was then used to study the effect of operating temperature and biomass particle size, both of which strongly influenced the rate of biomass conversion. For example, for particle sizes less than 1 mm, a uniform temperature throughout the particle was predicted, thus leading to higher conversion rates in comparison to those in the larger particles. On the other hand, any increase in moisture content led to considerable decrease in the rate of biomass conversion. For the operating conditions considered in this study, the volumetric particle shrinkage also increased the decomposition of biomass to end products.

[1]  Havva Balat,et al.  Potential contribution of biomass to the sustainable energy development. , 2009 .

[2]  F. Thurner,et al.  Kinetic investigation of wood pyrolysis , 1981 .

[3]  Z. Qi,et al.  Review of biomass pyrolysis oil properties and upgrading research , 2007 .

[4]  Shrikar Chakravarti,et al.  Natural gas enhanced biomass to liquids: Project development and modeling , 2012, Comput. Chem. Eng..

[5]  Colomba Di Blasi,et al.  Analysis of Convection and Secondary Reaction Effects Within Porous Solid Fuels Undergoing Pyrolysis , 1993 .

[6]  Edward J. Kansa,et al.  Mathematical model of wood pyrolysis including internal forced convection , 1977 .

[7]  Colomba Di Blasi,et al.  Pyrolytic behavior and products of some wood varieties , 2001 .

[8]  W. Peters,et al.  Product yields and kinetics from the vapor phase cracking of wood pyrolysis tars , 1989 .

[9]  Yang Wang,et al.  Combined Coal Gasification and Methane Reforming for Production of Syngas in a Fluidized-Bed Reactor , 2005 .

[10]  B. B. Krieger,et al.  Modelling and experimental verification of physical and chemical processes during pyrolysis of a large biomass particle , 1985 .

[11]  K. W. Ragland,et al.  Modeling thermally thick pyrolysis of wood , 2002 .

[12]  C. Blasi,et al.  Temperatures of Wood Particles in a Hot Sand Bed Fluidized by Nitrogen , 2003 .

[13]  Mathew J. Hagge,et al.  Modeling the combined impact of moisture and char shrinkage on the pyrolysis of a biomass particle , 2003 .

[14]  B. Peters.  Validation of a numerical approach to model pyrolysis of biomass and assessment of kinetic data , 2011 .

[15]  C. Diblasi,et al.  Modeling and simulation of combustion processes of charring and non-charring solid fuels , 1993 .

[16]  L Fagbemi,et al.  Pyrolysis products from different biomasses: application to the thermal cracking of tar , 2001 .

[17]  V. S. Vaidhyanathan,et al.  Transport phenomena , 2005, Experientia.

[18]  Thomas Nussbaumer,et al.  Mechanisms and kinetics of homogeneous secondary reactions of tar from continuous pyrolysis of wood chips , 2002 .

[19]  H. Baum,et al.  Experimental and theoretical investigation of heat and mass transfer processes during wood pyrolysis , 2010 .

[20]  Ayhan Demirbas,et al.  Global Renewable Energy Resources , 2006 .

[21]  O. Levenspiel,et al.  Fluidization engineering, 2nd edition , 1991 .

[22]  A. Demirbas,et al.  An Overview of Biomass Pyrolysis , 2002 .

[23]  Larry L. Baxter,et al.  Effects of particle shape and size on devolatilization of biomass particle , 2010 .

[24]  Colomba Di Blasi,et al.  Modeling intra- and extra-particle processes of wood fast pyrolysis , 2002 .

[25]  A. Galgano,et al.  Modeling Wood Degradation by the Unreacted-Core-Shrinking Approximation , 2003 .

[26]  Progress of conversion in a shrinking wet cylindrical wood particle pyrolyzing in a hot fluidized bed , 2009 .

[27]  Colomba Di Blasi,et al.  Modeling chemical and physical processes of wood and biomass pyrolysis , 2008 .

[28]  Lilly Shen,et al.  An experimental study of oil recovery from sewage sludge by low-temperature pyrolysis in a fluidised-bed , 2003 .

[29]  W. Prins,et al.  Modelling of flash pyrolysis of a single wood particle. , 2000 .

[30]  C. Blasi,et al.  Kinetics of the isothermal degradation of wood in the temperature range 528–708 K , 2003 .

[31]  Yang Wang,et al.  Methane Cracking over a Bituminous Coal Char , 2007 .

[32]  William A. Peters,et al.  Heterogeneous cracking of wood pyrolysis tars over fresh wood char surfaces , 1989 .

[33]  B. Babu,et al.  Heat transfer and kinetics in the pyrolysis of shrinking biomass particle , 2004 .

[34]  C. Branca,et al.  Kinetics of primary product formation from wood pyrolysis , 2001 .

[35]  Behdad Moghtaderi,et al.  The state‐of‐the‐art in pyrolysis modelling of lignocellulosic solid fuels , 2006 .

[36]  Colomba Di Blasi,et al.  Heat, momentum and mass transport through a shrinking biomass particle exposed to thermal radiation , 1996 .

[37]  Y. Zhang,et al.  Cracking of Simulated Oil Refinery Off-Gas over a Coal Char, Petroleum Coke, and Quartz , 2008 .

[38]  D. Ross.  Devolatilisation times of coal particles in a fluidised-bed , 2000 .

[39]  Nicolas Meunier,et al.  The continuous self stirred tank reactor: measurement of the cracking kinetics of biomass pyrolysis vapours , 2005 .

[40]  Morten Grønli,et al.  Mathematical Model for Wood PyrolysisComparison of Experimental Measurements with Model Predictions , 2000 .

[41]  Rafael Font,et al.  Kinetics of the pyrolysis of almond shells and almond shells impregnated with cobalt dichloride in a fluidized bed reactor and in a pyroprobe 100 , 1990 .

[42]  Colomba Di Blasi,et al.  Physico-chemical processes occurring inside a degrading two-dimensional anisotropic porous medium , 1998 .

[43]  N. Papayannakos,et al.  Modelling of the pyrolysis of biomass particles. Studies on kinetics, thermal and heat transfer effects , 1991 .

[44]  F. Berruti,et al.  A KINETIC MODEL FOR THE PRODUCTION OF LIQUIDS FROM THE FLASH PYROLYSIS OF BIOMASS , 1988 .

[45]  Daniel D. Joseph,et al.  Nonlinear equation governing flow in a saturated porous medium , 1982 .